Вы находитесь на странице: 1из 16

( )

Electric Far-infrared Tenter (Vertical Type)


()


Environment-friendly Far-Infrared Electric Tenter

Each chamber has 1 motor, 2 exhaust invert system!
1. Eco-friendly tenter compared to conventional oil or gas fueled tenter.
2. High efficiency in energy saving.
3. Maximizing users profit.
4. This tenter adopts vertical chain system. It occupies very limited space.
5. Quantity of heatloss is smaller than tenter with horizontal chain system.
6. Necessary time for warming-up to set temperature of tenter is very short in
electric tenter.
7. No need for piping work of oil or gas.
8. Oiled waste stack reduces very much.
9. It provides smooth feel of fabric.

11

1.

2.

3.

4.

5.

6.

7.

8.

9.

FAR-INFRARED VERTICAL TENTER SPECIFICATION


/ DIMENSIONS /

L37000 *W2600 *H2000

8 / 8 CHAMBER BASIC / 8

/ WORKING VOLTAGE /

380V

/ TOTAL POWER /

750KW

/ CONTROL BOX /

SSR, INVERTER / METHOD /

1 SET / 1

/ HEATING METHOD /

/ FAR-INFRARED /

/ CHAMBER /

8 / 8 CHAMBER / 8

1 CHAMBER*3,000 mm / 13000mm

/ INTERNAL STRUCTURE OF
THE CHAMBER /

1, 2 / 1MOTOR, 2 EXHAUST PIPE


1/2

1 / 1 CHAMBER BASIC /

/ PRODUCTION SPEED /

0~100m/min

/ WORKING WIDTH /

Max 1,800mm

70 / 70 INCH / 70

/ MANGLE WIDTH /

2, 000mm

70 / 70 INCH / 70

/ PADDING MANGLE /

5 / 5 Ton / 5

/ MANGLE RUBBER ROLLER /

360mm

/ INSULATION /

/ MINERAL WOOL /

/ DRIVE METHOD /

/ GEARED MOTOR / 20HP

/ MOTOR /

/ GEARED MOTOR / 10HP

/ TEXTER GUIDER /

2 / SET /

50/60 Hz3P


Without prior notice, the specification can change for quality improvement.

/ Machine Length / (mm)


6CH/

7CH/

8CH/

9CH/

10CH/

Chamber

18,000

21,000

24,000

27,000

30,000

Total

31,000

34,000

37,000

40,000

43,000

/Specification/

Length

(mm)

/ Machine width / (mm)

Working Width

Inch/
1,800

Inch/
2,000

Inch/
2,200

Inch/
2,400

Inch/
3,000

Inch/
3,400


Roll Width

2,000

2,200

2,400

2,600

3,200

3,600

Chamber width

2,700

3,000

3,400

3,700

4,200

4,700

Machine Total Power


/Chamber/

6CH/

7CH/

8CH/

9CH/

10CH/

Total Power

620 Kw

700 Kw

750 Kw

820 Kw

900 Kw

Fabric Transfer System

Fabric Entrance Part




-Entrance part consists of centering device and padder mangle, it can be
changed various type depending on character of fabric

Exit device

Plaiting device :

OVERFEED/

Overfeed
-Wide overfeed control : -20~+80%
(control in units of 0.1%)
-Simplified internal devices, allowing
easy maintenance and repair
-Equipped with convenient manual
weft controller

-: -20 +80%(0.1%)
-
-

PINNING SYSTEM/

Pinning Device
-Motor used to realize perfect
Interlocking of the overfeeding.
-Touch and clearance controll device
adopted to prevent occurrence.

-
.
-,


Application of Tandematic Uncurler Type

PADDER MANGLE/

Padder Mangle(2-Bowl Type)


-Mangle roller specially designed to ensure uniform spueezing
-Solid cast-iron frame resulting in enhanced durability

2
-
-


Far-Infrared Tenter, a top leader in the Textile finishing machines

60Inch Standard
60

Tenter

Far-infrared Tenter

Vertical chain system of electric tenter allows working place to occupy less wide in
installation space.



Horizontal chain system takes unnecessary flanks and heated air flows needlessly
that areas also . But vertical chain system occupies less side space. It takes short
time to heat the air to the aimed level and heat loss is smaller.

(8 )
Month fuel-cost comparison (8 Chamber Standard)
(8 )

KRW 4,500
USD 40,250
CNY 253,664

KRW 2,500
USD 22,361
CNY 140,924

KRW 1,200
USD 10,733
CNY 67,643

5,000

B-C Oil()
L.P.G()
Electricty(kwh)

B-C Oil()

: (KRW)
:

L.P.G()

Electricty(kwh)

WARM-UP TIME COMPARISON

HEATING METHODS

OPERATION CONDITIONS

WARM-UP TIME

1 ~ 1 30

1hour ~1hour and 30 minutes


1 ~ 1 30

Excessive fuel consumption

BUNKER-C OIL
SAME CONDITIONS
: (KRW)

N O T E

1 ~ 1 30

SAME CONDITIONS

1hour ~1hour and 30 minutes


1 ~ 1 30

Excessive fuel consumption

15 ~ 30

SAME CONDITIONS

15 minutes ~ 30 minutes
15 ~ 30

Time and fuel savings

LPG,LNG

FAR-INFRARED TENTER

.
Oiled waste stack reduces very much.

Tenter

Far-infrared Tenter




The amount of fabric sludge can be shrunk when electric tenter is used rather than
traditional oil or gas fuel tenter. Air pollution at dust collector can be reduced by half
with electric tenter.

50%

.
No need for piping work of oil or gas.




The electric tenter does not need thermo oil. It does not need to spend time and cost for
changing thermo oil which is expected to take place every 2 or 3 years.
As the electric tenter does not use oil or gas, it does not need piping works and its
maintenance jobs which generates high expenditure.
2~3
100%

. / Maximizing users profit. /



Far-infrared Method
( )

,
Oil, Cas Methods
( )



Thermo oil or gas fueled tenter requires high energy cost compared to the economic
level of electric cost on electric tenter.
The electric tenter offers comparatively high productivity with less energy cost.
Around 70% of efficiency is reported through enhanced productivity and energy cost
saving.
70%

. / It provides smooth feel of fabric. /



Treatment of fabric with


comparativ ely cleaner
hot air heated by electric
far infrared rays.

Hand Touch UP





The amount of fabric sludge circulated through heated air in chamber effects the
nature of heated air and also effects the hand feel of fabric.
Electric tenter helps shrink the amount of fabric sludge and it helps for comparatively
cleaner air to be circulated in the chamber. The nature of heated air effects the fabric
quality. The electric tenter gives better hand feel of fabric through comparatively
cleaner heated air circulation in the chamber.

50%

MAIN PRODUCTS
- ELECTRIC FAR-INFRARED TENTER /
- ELECTRIC FAR-INFRARED COLOR FASTENING DRYER /
- EMBOSS MACHINE ROLLER TYPE, FLAT TYPE /
- ROLLER PRINT MACHINE FOR COLOR PRINT & BURN OUT /


TEL : 031-865-2449

FAX : 031-865-2441

HEAD OFFICE & FACTORY :


#501-3, UNAM-RI, EUNHYEON-MYEON, YANGJU-SI,
GYEONGGI-DO, KOREA 482-861
TEL : 031-865-2449

FAX : 031-865-2441

: 501-3
TEL: 82-31-865-2449 FAX : 82-31-865-2441
E-MAIL : paice9004@nate.com

Вам также может понравиться