Академический Документы
Профессиональный Документы
Культура Документы
1
OVERVIEW
SEISMIC PROVISIONS
ANCHOR REINFORCEMENT
DESIGN REPORT
CANADA
www.hilti.com R.T. Morgan | PA2.1 Design Report | October 2010
Detailed Report shows equations, variables and calculations. complete transparency: no more black box. users can easily verify PA2.1 data input and calculations only available in U.S. at this time Long Report is the same as the current Detailed report in PA2.0.9. shows some variables calculation results Short Report is the same as the current Short report in PA2.0.9. brief 1-page summary
www.hilti.com R.T. Morgan | PA2.1 Design Report | October 2010
www.hilti.com
| October 2010
Steel Strength parameters for post-installed anchors are taken from the Evaluation Service Report. Steel Strength parameters for cast-in-place anchors are in the PA2.1 database.
www.hilti.com R.T. Morgan | PA2.1 Design Report | October 2010
Equations used to calculate Design Concrete Breakout Strength are shown. Each equation is referenced to AC318-08, Appendix D.
www.hilti.com
| October 2010
Concrete Breakout Strength variables for post-installed anchors are input by the user or taken from the Evaluation Service Report. Concrete Breakout Strength variables for cast-in-place anchors are input by the user or taken from the PA2.1 internal database.
www.hilti.com
| October 2010
Calculations for each parameter used to calculate the Nominal Concrete Breakout Strength are shown. Users can easily check these results by inputting the variables into the equations.
www.hilti.com
| October 2010
Calculation results for the Nominal Concrete Breakout Strength are shown. All relevant factors are shown. The factored tension load is shown. Users can easily check the calculated results.
www.hilti.com
| October 2010
Equations used to calculate Design Bond Strength are shown. Each equation is referenced to AC308. The same equations and references are given in the ESR.
www.hilti.com R.T. Morgan | PA2.1 Design Report | October 2010
www.hilti.com
| October 2010
Calculations for each parameter used to calculate the Nominal Bond Strength are shown. Users can easily check these results by inputting the variables into the equations.
www.hilti.com
| October 2010
bond
Calculation results for the Nominal Bond Strength are shown. All relevant factors are shown. The factored tension load is shown. Users can easily check the calculated results.
www.hilti.com
| October 2010
single anchor
www.hilti.com
| October 2010
anchor group
Parameter for anchor group condition designated group. Reference D.5.4.2, equation (D-18).
www.hilti.com
| October 2010