Академический Документы
Профессиональный Документы
Культура Документы
MD0503099C3
SB-WA930EE
Colour (S)... Silver Type
Specification
n Active subwoofer Type Speaker unit(s) 1. Woofer 2. Woofer Output sound pressure Frequency range Dimensions (W x H x D) Mass n General Power consumption Power supply Power consumption (standby mode) 390 W AC 230V, 50Hz 0.7 W 15 cm Cone type 15 cm Cone type 84 dB/W (1.0 m) 34 Hz-220 Hz (-16 dB) 38 Hz-190 Hz (-10 dB) 202 x 410 x 500 mm 13.7 kg n System : SC-HT930(EE) Music Center: SA-HT930(EE) Satellite Speakers: SB-HT880(EB) Active Subwoofer: SB-WA930(EE) 1 way, 2 speaker system, Bass reflex Note : Specifications are subject to change without notice. Mass and dimensions are approximate.
CONTENTS
Page
1 Safety Precautions 1.1. GENERAL GUIDELINES 2 Handling the Lead-free Solder 3 3 4 2.1. About lead free solder (PbF) 3 Before Repair and Adjustment 4 Protection Circuitry
Page
4 4 4
2005 Matsushita Electric Industrial Co. Ltd.. All rights reserved. Unauthorized copying and distribution is a violation of law.
SB-WA930EE
5 Connection of the Speaker Cables 6 Disassembly Procedure 6.1. Disassembly flow chart 6.2. Disassembly of the Speaker Unit and Checking of the P.C.B. 7 Voltage Measurement and Waveform Chart 7.1. Voltage Measurement 7.2. Waveform Chart 8 Block Diagram 9 Notes of Schematic Diagram 10 Schematic Diagram 10.1. Power Circuit 10.2. Transformer Circuit and AC Inlet Circuit
5 6 6 8 14 14 15 16 17 18 18 20
10.3. Amplifier Circuit 11 Printed Circuit Board 11.1. Power P.C.B. 11.2. AC Inlet P.C.B. and Transformer P.C.B. 11.3. Amplifier P.C.B. 12 Wiring Connection Diagram 13 Illustration of ICs, Transistors and Diodes 14 Parts Location and Replacement Parts List 14.1. Cabinet 14.2. Electrical Parts List 14.3. Packing Materials & Accessories Parts List 14.4. Packaging
21 22 22 24 25 26 27 28 29 32 35 35
SB-WA930EE
1 Safety Precautions
1.1. GENERAL GUIDELINES
1. When servicing, observe the original lead dress. If a short circuit is found, replace all parts which have been overheated or damaged by the short circuit. 2. After servicing, ensure that all the protective devices such as insulation barriers, insulation papers shields are properly installed. 3. After servicing, check for leakage current to prevent from being exposed to shock hazards.
1.1.1.
1. Unplug the AC cord and connect a jumper between the two prongs on the plug. 2. Using an ohmmeter measure the resistance value, between the jumpered AC plug and each exposed metallic cabinet part on the equipment such as screwheads, connectors, control shafts, etc. When the exposed metallic part has a return path to the chassis, the reading should be between 1M and 5.2. When the exposed metal does not have a return path to the chassis, the reading must be .
Fig. 1
1.1.2.
1. Plug the AC cord directly into the AC outlet. Do not use an isolation transformer for this check. 2. Connect a 1.5k, 10 watts resistor, in parallel with a 0.15F capacitors, between each exposed metallic part on the set and a good earth ground such as a water pipe, as shown in Figure 1. 3. Use an AC voltmeter, with 1000 ohms/volt or more sensitivity, to measure the potential across the resistor. 4. Check each exposed metallic part, and measure the voltage at each point. 5. Reverse the AC plug in the AC outlet and repeat each of the above measurements. 6. The potential at any point should not exceed 0.75 volts RMS. A leakage current tester (Simpson Model 229 or equivalent) may be used to make the hot checks, leakage current must not exceed 1/2 milliamp. Should the measurement is outside of the limits specified, there is a possibility of a shock hazard, and the equipment should be repaired and rechecked before it is returned to the customer.
SB-WA930EE
4 Protection Circuitry
The protection circuitry may have operated if either of the following conditions are noticed: No sound is heard when the power is turned on. Stops during a performance. The function of this circuitry is to prevent circuitry damage if, for example, the positive and negative speaker connection wires are shorted, or if speaker systems with an impedance less than the indicated rated impedance of the amplifier are used. If this occurs, follow the procedure outlines below: 1. Turn off the power. 2. Determine the cause of the problem and correct it. 3. Turn on the power once again after one minute. Note: When the protection circuitry functions, the unit will not operate unless the power is first turned off and then on again.
SB-WA930EE
SB-WA930EE
6 Disassembly Procedure
ATTENTION SERVICER Some chassis components may have sharp edges. Be careful when disassembling and servicing. 1. This section describes procedures for checking the operation of the major printed circuit boards and replacing the main components. 2. For reassembly after operation checks or replacement, reverse the respective procedures. Special reassembly procedures are described only when required. 3. Select items from the following index when checks or replacement are required. Disassembly of the Front Panel Unit Disassembly of Woofer Speaker Unit 1 Disassembly of Woofer Speaker Unit 2 Disassembly of the Power Amp Unit Disassembly of the Rear Panel and Fan Unit Disassembly and checking of the AC Inlet P.C.B. and Amplifier P.C.B. Disassembly and checking of the Power P.C.B. and Transformer P.C.B. Replacement of Power ICs and Transistors
6.1.
The following chart is the procedure for disassembling the casing and inside parts for internal inspection when carrying out the servicing. To assemble the unit, reverse the steps shown in the chart below.
6.1.1.
SB-WA930EE
6.1.2.
SB-WA930EE
6.2.
6.2.1.
Step 1: Slot in a steel ruler to give a gap between the Front Panel Unit and the Speaker Cabinet Assembly as arrow shown.
Step 3: Use the screwdriver to slightly lift up the Front Panel Unit as arrow shown. Note: Be careful with the bosses which are glued to the Speaker Cabinet Assembly Unit.
Steps 2: Slot a piece of wood chip in between the Front Panel Unit and the steel ruler as arrow shown. Step 4: Remove the Front Panel Unit from the Speaker Cabinet Assembly Unit as arrow shown.
SB-WA930EE
Step 1: Remove 4 screws. Step 1: Clean up the remaining glue at the 6 bosses points and replace with the normal glue.
Step 2: Replace the Front Panel Unit firmly back to the Speaker Cabinet Assembly Unit.
Step 2: Remove the Woofer 1 by detaching the (+) red and (-) black wires.
SB-WA930EE
6.2.4.
Step 1: Lay the speaker unit as shown. Remove 7 screws from the bottom of the Speaker Cabinet Assembly Unit.
Step 2: Remove the Woofer 2 by detaching the (+) red and (-) black wires.
10
SB-WA930EE
6.2.5.
Step 3: Pull out the Power Amp Unit slightly as arrow shown.
Step 4: Disconnect the connector (CN604). Step 3: Disconnect the connector (CN507) to detach the rear panel.
11
SB-WA930EE
Step 5: Lay the rear panel and remove the Fan Unit as arrow shown.
6.2.6.
Follow Step (1) to Step (5) described in section 6.2.4. Follow Step (1) to Step (3) described in section 6.2.5.
6.2.7.
Step 3: Flip the Power P.C.B. as shown for checking both the Power P.C.B. and Transformer P.C.B.
Follow Step (1) to Step (5) described in section 6.2.4. Follow Step (1) to Step (3) described in section 6.2.5.
6.2.8.
Follow Step (1) to Step (5) described in section 6.2.4. Follow Step (1) to Step (3) described in section 6.2.5.
12
SB-WA930EE
Step 1: Disconnect the connector (CN502). Step 2: Remove the AC Inlet P.C.B. by pulling the P.C.B. support claw as arrow shown). Step 7: Flip the Power P.C.B. as shown to desolder the terminals of the Power IC501, Transistors Q511 and Q512.
Step 3: Desolder the terminals of IC601, Transistors Q601 and Q602. Step 4: Disconnect the connectors CN601, CN602 and CN603 and remove the Amplifier P.C.B..
SB-WA930EE
7.1.
7.1.1.
Voltage Measurement
Power P.C.B.
POWER P.C.B.
Ref No. MODE CD PLAY STANDBY Ref No. MODE CD PLAY STANDBY Ref No. MODE CD PLAY STANDBY Ref No. MODE CD PLAY STANDBY Ref No. MODE CD PLAY STANDBY 1 32.9 0 21 -67.9 0.3 E 0 0 E 5.2 0.3 E 5.2 0.3 2 32.9 0 22 0 0 Q501 C 4.9 0.6 Q511 C 33.9 -0.2 Q554 C 0 3 68.0 15.1 23 0 0 B 0 0 B 5.9 -0.2 B 4.7 0 4 -67.9 0.3 24 0 0 5 0 0 25 0 0 E 0 0 E -11.2 0.3 E 4.8 0.4 6 33.6 -0.1 26 0 0 Q502 C 4.9 0.6 Q512 C -33.9 0 Q555 C 5.2 0.3 7 -33.6 0 8 0 0 9 0 0 10 0 0 IC501 11 0 0 IC501 12 0 0 13 0 0 14 -0.2 0 15 33.9 -0.1 16 -33.9 0 17 -10.5 0 18 0 0 19 0 0 20 68.0 15.1
B 0 0 B -11.8 0 B 0
1 0 0 E 0 0 E 0 0
3 -0.7 0 B 0 0 B -0.2 0
E 0 0 E 0 0 E 0.4 0.3
B 0 0 B 0.2 0 B 0 0
7.1.2.
Amplifier P.C.B.
AMPLIFIER P.C.B.
Ref No. MODE CD PLAY STANDBY Ref No. MODE CD PLAY STANDBY Ref No. MODE CD PLAY STANDBY 1 68.0 0.9 21 0 0 E 49.7 0.3 2 -67.8 -0.3 22 0 0 Q601 C 68.0 0.9 3 0 0 4 33.7 1.2 5 -33.6 -0.7 6 0 0 7 0 0 8 0 0 9 -12.3 0.2 10 0 0 IC601 11 0 0 IC601 12 -0.2 0 13 33.9 1.2 14 -33.9 -0.6 15 -10.2 0 16 0 0 17 0 0 18 49.7 0.5 19 -50.8 0.1 20 0 0
B 50.2 0.9
E -50.7 -0.1
B -51.4 -0.3
E 0 0
B 0.5 0.3
7.1.3.
AC Inlet P.C.B.
AC INLET P.C.B.
Ref No. MODE CD PLAY STANDBY E 0 -0.1 Q515 C 0.1 5.9 B 0.8 0 E 0 -0.1 Q516 C 3.5 3.2 B -0.2 -0.3 E 6.0 5.9 Q517 C 12.3 10.0 B 6.6 6.5 E 0 -0.1 Q519 C 0.8 0 B 0 0
14
SB-WA930EE
7.2.
Waveform Chart
15
SB-WA930EE
8 Block Diagram
IC501 RSN311W64D-P
POWER HIC
+ + + + -
IN_1(IN_2)
+DI SENS
+VCC LOW
26 (25)
22
23
18 (19)
15
20
6 D501
1 (2)
11(12)
24
13
14
16
21
B B
Q506 INTERFACE SWITCH Q505 SWITCHING D502
SL(R)
FILTER
-DI SENS
+VCC HI
SUB_O
SUBIN
+VD
-VCC HI
SLIN(R)
IN GND
IH DET
AC IN
CIN
C_O
-VD
16
FILTER
FILTER
CN603 SUBWOOFER
FRONTL(R)
FILTER
B
DC_DET D508 Q559 SW Q552~Q557
B B
B
D598,D599
M
Q520 HP_CNT INTERFACE SWITCH Q503 SWITCH Q511 VOLTAGE REGULATOR AC1 AC2 FL1 FL2
Q512
VOLTAGE REGULATOR
B
Q515,Q519 PCONT DCDET SWITCH RLY501
B
Q517 VOLTAGE REGULATOR
B
D528
T502
BACK-UP TRANSFORMER
Z501 L500
F1
E500
D602
20 (21)
L_IN(R_IN)
11
DISP HMUT
19
-VD
2
-VCC HI
18
+VD
1
+VCC HI
6 (3)
L_OUT(R_OUT)
7
AC IN
4 13 14 5
D604
IC601 RSN312H24A-P
POWER HIC
12
IH DET
D603
SIGNAL LINES
: MAIN SIGNAL LINE ( ) Indicates Pin No. of Right Channel Note : Signal Lines are applicable to the Left Channel only.
16
POWER TRANSFORMER
DC DET SWITCH
JK500 AC INLET
SB-WA930EE
17
SB-WA930EE
10 Schematic Diagram
10.1. Power Circuit
SCHEMATIC DIAGRAM-1 POWER CIRCUIT
C551 0.01
DISP HMUT
+VCC LOW
-VCC LOW
+VH OUT
-VH OUT
IC501
IN GND RELAY SUBin IN_1 IN_2 SRin SLin +VD -VD Cin
+VCC HI
-VCC HI
SUB_O
IH DET
OUT_2
OUT_1
SR_R
AC IN
GND
C_O
E501 K4CZ01000027
SR_L
RSN311W64D-P
POWER HIC
IC501
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
C506 1000P
C505 1000P
C508 18P
R523 120K
R524 120K
D502
R516
C504 1000P
C510 22P
R515
56K
4.7K
C509 22P
R550 10K
R511 15K
R522 56K
3 4 5 6 7 8 9 10 11
AC2 SYS6V HP_CNT D.GND FL SUB+B A.GND A.GND FR SL A.GND SR C A.GND D503 MA2C700A0F R547 390K
C517 0.01
C515 0.01
R520 22K
C516 0.01
C514 6.3V100
DC_DET
C513 0.047
R519 820K
AC1
R551 10K
R512 15K
R529 22K
R530
1 R531 1
R402 1K
R532
Q503
B1AACF000117
SWITCH
Q503
12 13 14 15 16
D504 B0AACK000004
Q506 B1GCCFJJ0016
INTERFACE SWITCH R546 R545 220K 1K Q501,Q502 SWITCH Q559
20 FAN CONTROL 21 22 23 24 25
SYNC FL AC2 FL AC1
Q505
C534 50V33 R548 330K
Q501
Q502
D508 B0AACK000004
17 SW A.GND 18 PCONT 19
D503
B1AACF000117
Q559
C648 0.1 R627 10K R626 10K
R603 10K
2SD0592ARA B1AACF000117
FAN MOTOR DRIVE SWITCHING
Q557
Q505
R611 10K
R521 56K
CN501
R510
SUBW
D501
R506 15K
D501-D502 B0JAPG000019
B1AACF000117
DC DETECT SWITCH
D560
Q556 B1ACCF000094
D557 B0EAKM000117
D560 B0AACK000004
Q557
R581 6.8K
B1ACCF000094
FAN MOTOR DRIVE R562 4.7K R558 100K R559 10K C578 0.01 C579 0.01
B1ACCF000094
FAN MOTOR DRIVE
Q554
C574 0.01
D558,D559 B0AACK000004 D559 D558 R584 47K R583 100 C576 16V 10P C577 16V 10
R564 220K
Q553 Q554
C575 0.01 R582 220K D555 D556 B0BA01100004 B0AACK000004 R563 C570 1K 16V 330 Q555
Q552
R602 4.7K
Q555
22
R606
2SD0592ARA
FAN MOTOR DRIVE
TO FAN
CN507
1 2
+ -
2SD0592ARA
FAN MOTOR DRIVE
Q553
R604 2.2M
18
SB-WA930EE
JK502
4 3 2 1
+
-
CENTER S Rch
+
-
S Lch
+
F Rch
+
F Lch CN603
10
1 2
C569 0.047 C519 0.047 C518 0.047 C526 0.047 C522 0.047 C523 0.047 R534 10 R533 10 C527 0.047 C528 0.047 C618 0.01 C617 0.01
R625
10
3 4 5 6 7 8
R577 1.5K
R537 10
R538 10
E500 K4CZ01000027
C530 1000P
C531 1000P
C532 1000P
C533 1000P
1 2 3 4 5 6 7
C550 0.01
C560 50V10
D509
CN601
10 9
Q511 B1BACG000048
VOLTAGE REGULATOR C543 1000P R568 150 R571 2.2K
C546 12V3300
C547 42V4700
8 7 6 5 4 3
B0FBAM000009
R565
3.9K
R569 1.5K
D599
B0FBAM000009
D598
2 1
H503/W500
C544 50V100
D510 B0BA5R700008
C554 0.1
15 14 13 12
D561 B0BA01100004
C572 50V100
R560 150
D597
B0FBAM000009
11 10 9
C573 1000P
C553 0.1
8
FP1 K5G502AA0002
7 6 5
5A
Q512 B1BCCG000023
VOLTAGE REGULATOR R600 47K R601 47K D563
FP1
4 3
D564
2 1
19
SB-WA930EE
R589 10K
C555 35V4.7
Q516 B1GACFJJ0018
SYNC SWITCH CN502
R578 10K
HELP PCONT D.GND SYNC SYS6V SUB+B R580 22 D527~D530 B0EAKM000122 R587 2.7K
6 7
C556 0.01
R588 150
C558 16V1000
2 3 4 5
Q517 B1BACG000048
VOLTAGE REGULATOR
D528
D527
Q519 B1AACF000117
DCDET SWITCH
Q515
Q515
T502 G4C2AAJ00005
B1AACF000117
DC DET SWITCH
W1 W2
15 14 13 12 11
D500 B0AACK000004
D500
RLY501 K6B1AEA00003
10 9 8 7 6 5 4 3 2 1
Z501 ERZV10V511CS AC IN 230 V / 50Hz F1 250V 5A FC502 FC501 L500 ELF15N035AN JK500
TRANSFORMER CIRCUIT
AC INLET CIRCUIT
20
SB-WA930EE
IC601
OVER LOAD DISP HMUT +VCC LOW -VCC LOW +Di SENS -Di SENS +VCC HI -VCC HI IN GND DCDET R_OUT IH DET L_OUT RELAY AC IN R_IN GND L_IN +Hin
IC601
+VD
-Hin
-VD
RSN312H24A-P
POWER HIC CN604 L601
22
21
20
19
18
17 R619
16
15 56K
14
13
12
11
10
1 2 3 4
D603
D604
C607 18P
R620
56K
C608 18P
3.9K
C611 1000P
R630 10 R631 10
R623
C610 0.01
R633 820K
C615 0.047
8 7 6 5 4 3 2 1
R626 10K
C609 0.01
C619 0.047
3.9K
C618
0.047
R624
C620 0.1 FAN_DRV 1 FL 2 INGND 3 FR 4 AC IN 5 HMUTE 6 DCDET 7 GND 8 R622 R621 10K 27K R628 R627 150K 120K
H602 /W602
C621 0.1
Q601 B1BACG000048
VOLTAGE REGULATOR R615 47K R616 4.7K
C604 100V3300
C603 100V4700
VOLTAGE REGULATOR
Q603 B1BAAJ000003
C613 0.01
R613 2.7K
R617 8.2K R618 47K D605 B0BA01200008 D606 B0BA01200008 D607 B0BA02300017 D602 B0FBAM000009
1 2
C605 0.1
+VCCLO GND
3 4 5 6
7 8
4
R614 2.7K R612 4.7 D608 D609
1
-VCCHI
9 10
B1BCCG000023
VOLTAGE REGULATOR
Q602
Q602
R634 47K
C606 0.1
D609,D611 B0BA01900005
21
SB-WA930EE
A 1
J570 J528
21 19 17 15
J501
23
C550
J591
J507
J592
J502 J571
2 1
J508
E500
CP502
7 6 5 4 3 2 1
D508
J534
TO MAIN UNIT
11 9 7 5
R583
C576
Q
E
J572 J573
C577
J568
R521
R522
D504
J416
J513
J512
Q506
R545 C529 R547 D503 R549
C534
B C E
D558 R581
D55
J505
R548
C E
JK502
4
J521
R611
R577
C528
C533
Q505
C530
C549
C531
R537
J538
J514
J535
3-C
C532
J565
1-SR
C522
R625
L505
R622 L502
C526
J596 J595
J574
C527
3-FR
C519
R534
CN603
8
C518
R533
R531
R621 L501
JK501
C618 C617
1 2
6 5 4
J563 J562
C513
J599
3 2
R538 C523
C569
J561
J598
IC501
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 1
22
R519
R530
R529
1-FL
D501
CN507
J511
J532
J537
C547
5-SL
J594
R565
J577
J593
C548
J579
SB-WA930EE
J515
J584
FP1
J583
5A
J507
J508
J546
J548
J520 J517
C647
R584
C570
R562
R563
R602
R603
R583
C576
Q556
Q557
B C E
Q552
C578
R559
B C E
C580
J547
D562
J545
J910
D508
CN602
1 2 3 4 5 6 7 8
H503/W500
1
522
D504
R606
D559
C575
Q506
C534
B B C E
C579
R604
Q555 Q554
B C B
Q553
E C B
C514
R546
R548
C574
D556
J549
J530
J506
C E
R581
R564
R402
Q520
E C B
C E
R520 J589
D558
D555
R558
Q501
B
Q502
B C E
J586
2
J529 J587
3 4
C560
Q505
D599
1+ 2~ 3~ 4-
J544
J588
10 9 8 7 6 5
J902
CN601
5 6 7 8 9 10 11 12 13 14 15
J542
J565
J579
D598
1+ 2~ 3~ 4-
C554
J543
J578 J522
4 3 2
J552
R565
C546
C547
D597
1+ 2~ 3~ 4-
C553
J569
J580
J560
J566
J532
J558
D566
D501
J564
R529
C545
J903
R626
J585
J511
J563 J562
R570
D509
C572 R567 D561
R519
R532
Q503
R523
E C B
R627
C648
C513
R501
R513 C507
599 561
J590
J519
J523
J518
R569
R609
R524
R514 C508
J559
R526
R525
R505
R506
J576
D502
R515 C509
C517
R516 C510
Q559
R571 R568 C543
D510
J509
R560 R561 R610 R600 D563
R601 C551
J417 R502
J516
C515
C505
C503
C544
J510
D565
E501
1 2 3
597
C516
J598
C504
R510
R512
IC501
5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
R511
C506
R551 R550
R509
J541
21
22
23
24
25
26
Q511
B C E
Q512
B C E
C573
D564
PbF
23
SB-WA930EE
A 1
2
FC501
W2
(BRW)
W1
T5AL 250V
Z501
F1
FC502
(BACK UP TRANSFORMER)
T502
J6010
3
AC IN 230V 50Hz
JK500
J6001 J6002 J6003
4
L500
2 1
Q516
RLY501
2 1
Q517
B C
Q515
R590
B
R589 R578
D529
D527
C E
R587
R588 C556
D500
J6004
3 4 5
4 3
Q519 B
C
R579 J6009
C559
R401
J6007 J6008
J6006
R580
J6005
CN502
7 6 5 4 3 2 1
CAUTION RISK OF ELECTRIC SHOCK AC VOLTAGE LINE. PLEASE DO NOT TOUCH THIS P.C.B
6
12 11 10
(BLU)
W2
(BRW)
W1
9
8 7
6 5
4 3 2
8
SECONDARY PRIMARY
J415
24
D528 D530
D525
SB-WA930EE
A 1
9 8 7 6 5 4 3 2 1
D608
D609
J615
J665 D602
R625
R635
R626
J679
J624
J616
10
J675 R634
CN604
1 2 3 4
D611
D610
J617
J625
C606
C601
1+
2~
3~
4-
C604
R628
R627
H603 /W603
8
J676
J677
J626
R631
7 6
J640
C602
1+
2~
3~
4-
R622
3
J655
C615
J618
C603
J687
J688
J698
L601
C617
D601
C621
5 4 3
J689
R621
J629
R629
2 1
C605
J628
C620
R632
J630
J631
C618 C616
D605
C610
R611
R619 C607
C609
R623
C613
4
1 5
J695
10
J691
15 20
R613
R615 J656
J620
IC601
22
R617
B C E
Q601
Q602
R618
25
L602
J643
J690
J621
R616
D607
D606
Q603
R612
R630
R614 C614
PbF
SB-WA930EE
POWER P.C.B.
CN501 24 . . . . . . 2 25 . . . . . . . 1
SOLDER SIDE
TO MAIN UNIT
7. . . . . .1 CP502
CN602 1. . . . . . . .8
H503/W503 CN601 10 . . . . . . . . 1 1 . . . . . . . . . . . . 15
JK502 CENTRE SPEAKER SURROUND RIGHT SPEAKER SURROUND LEFT SPEAKER FRONT RIGHT SPEAKER FRONT LEFT SPEAKER JK501 CN507 1 2 CN603 8 . . . . . . 1
FAN
PbF
TRANSFORMER P.C.B.
H601/ W601 10 . . . . . . . 1 8. . . . . . . . . . .1 H602/W602 CN604 1. . . .4 H603/ W603 8 . . . . . . 1 CN503 T501 15 . . . . . . . . . . 1
(BLU)
W2
(BRW)
W1
SPEAKER WOOFER
SOLDER SIDE
PbF
AMPLIFIER P.C.B.
SOLDER SIDE
PbF
AC INLET P.C.B.
CAUTION RISK OF ELECTRIC SHOCK AC VOLTAGE LINE. PLEASE DO NOT TOUCH THIS P.C.B
(BACK UP TRANSFORMER)
T502
(BLU) (BRW)
W2
W1
JK500
AC IN 230V 50Hz
CN502 7. . . . . .1
SOLDER SIDE
PbF
26
SB-WA930EE
RSN312H24A-P
B1AACF000117 B1ACCF000094
B1GCCFJJ0016
B1BACG000048 B1BCCG000023
1 22
C B
26
B1GACFJJ0018
2SD0592ARA
B1BAAJ000003
B0FBAM000009
B0EAKM000122
Ca Cathode A
E C
B C E
B
B
Anode
B0JAPG000019 B0EAKM000117
B0AACK000004
MA2C700A0F
Ca Cathode A
Anode
Ca Cathode A Anode
27
SB-WA930EE
28
SB-WA930EE
14.1. Cabinet
14.1.1. Cabinet Parts Location
29
SB-WA930EE
30
SB-WA930EE
31
SB-WA930EE
Part Name & Description DIODE DIODE DIODE DIODE DIODE DIODE CONNECTORS
SYSTEM CONNECTOR 7P CONNECTOR 15P CONNECTOR 2P CONNECTOR 10P CONNECTOR 8P CONNECTOR 8P CONNECTOR 4P CONNECTOR 7P CONNECTOR COILS & TRANSFORMERS
LINE FILTER CHOKE COIL CHOKE COIL CHOKE COIL CHOKE COIL CHOKE COIL TRANSFORMER BACK-UP TRANSFORMER COMPONENT COMBINATION
Z501
ERZV10V511CS
ZENER SPEAKER
[M]
SP1
EAS15PL05A
[M]
RLY501
K6B1AEA00003
[M]
F1
K5D502BK0006
[M]
FC501 FC502
EYF52BCY EYF52BCY
[M] [M]
FP1
K5G502AA0002
[M]
15P WIRE HOLDER 10P WIRE HOLDER WIRE HOLDER WIRE HOLDER JACKS
E500
K4CZ01000027
TERMINAL
[M]
32
SB-WA930EE
Remarks [M]
PRI WIRE (BLUE) PRI WIRE (BROWN) 15P WIRE 10P WIRE 8P WIRE 8P WIRE RESISTORS
R401 R402 R501 R502 R505 R506 R509 R510 R511 R512 R513 R514 R515 R516 R519 R520 R521 R522 R523 R524 R525 R526 R529 R530 R531 R532 R533 R534 R537 R538 R545 R546 R547 R548 R549 R550 R551 R558 R559 R560 R561 R562 R563 R564 R565 R567 R568 R569 R570 R571 R577 R578 R579 R580 R581 R582 R583 R584 R587 R588
ERDS2TJ224T ERDS2TJ102T ERDS2TJ472T ERDS2TJ472T ERDS2TJ153T ERDS2TJ153T ERDS2TJ472T ERDS2TJ472T ERDS2TJ153T ERDS2TJ153T ERDS2TJ563T ERDS2TJ563T ERDS2TJ563T ERDS2TJ563T ERDS2TJ824T ERDS2TJ223T ERDS2TJ563T ERDS2TJ563T ERDS2TJ124T ERDS2TJ124T ERDS2TJ154T ERDS2TJ124T ERDS2TJ223T ERD25FVJ1R0T ERD25FVJ1R0T ERDS2TJ472T ERDS1FVJ100T ERDS1FVJ100T ERDS1FVJ100T ERDS1FVJ100T ERDS2TJ224T ERDS2TJ102T ERDS2TJ394T ERDS2TJ334T ERDS2TJ392T ERDS2TJ103T ERDS2TJ103T ERDS2TJ104T ERDS2TJ103T ERDS2TJ151T ERDS1FVJ392T ERDS2TJ472T ERDS1FVJ102T ERDS2TJ224T ERDS1FVJ392T ERDS1FVJ152T ERDS2TJ151T ERDS1FVJ152T ERDS2TJ103T ERDS1FVJ222T ERDS2TJ152T ERDS2TJ103T ERDS2TJ332T ERDS2TJ220T ERDS2TJ682T ERDS2TJ224T ERDS2TJ101T ERDS2TJ473T ERDS2TJ272T ERDS2TJ151T
220K 1/4W 1K 1/4W 4.7K 1/4W 4.7K 1/4W 15K 1/4W 15K 1/4W 4.7K 1/4W 4.7K 1/4W 15K 1/4W 15K 1/4W 56K 1/4W 56K 1/4W 56K 1/4W 56K 1/4W 820K 1/4W 22K 1/4W 56K 1/4W 56K 1/4W 120K 1/4W 120K 1/4W 150K 1/4W 120K 1/4W 22K 1/4W 1 1/4W 1 1/4W 4.7K 1/4W 10 1/2W 10 1/2W 10 1/2W 10 1/2W 220K 1/4W 1K 1/4W 390K 1/4W 330K 1/4W 3.9K 1/4W 10K 1/4W 10K 1/4W 100K 1/4W 10K 1/4W 150 1/4W 3.9K 1/2W 4.7K 1/4W 1K 1/2W 220K 1/4W 3.9K 1/2W 1.5K 1/2W 150 1/4W 1.5K 1/2W 10K 1/4W 2.2K 1/2W 1.5K 1/4W 10K 1/4W 3.3K 1/4W 22 1/4W 6.8K 1/4W 220K 1/4W 100 1/4W 47K 1/4W 2.7K 1/4W 150 1/4W
[M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M]
Ref. No. R589 R590 R600 R601 R602 R603 R604 R606 R609 R610 R611 R611 R612 R613 R614 R615 R616 R617 R618 R619 R620 R621 R621 R622 R622 R623 R624 R625 R625 R626 R626 R627 R627 R628 R629 R630 R631 R632 R633 R634 R635
Part No. ERDS2TJ103T ERDS2TJ102T ERDS2TJ473T ERDS2TJ473T ERDS2TJ472T ERDS2TJ103T ERDS2TJ225T ERG2SJ220E ERDS1FVJ152T ERD2FCVJ4R7T ERD2FCVJ4R7T ERDS2TJ103T ERD2FCVJ4R7T ERDS2TJ272T ERDS2TJ272T ERDS2TJ473T ERDS2TJ472T ERDS2TJ822T ERDS2TJ473T ERDS2TJ563T ERDS2TJ563T ERDS2TJ100T ERDS2TJ273T ERDS2TJ100T ERDS2TJ103T ERDS2TJ392T ERDS2TJ392T ERDS2TJ100T ERDS2TJ153T ERDS2TJ103T ERDS2TJ153T ERDS2TJ103T ERDS2TJ124T ERDS2TJ154T ERDS2TJ100T ERDS2TJ100T ERDS1FVJ100T ERDS1FVJ100T ERDS2TJ824T ERDS2TJ473T ERDS2TJ473T
Part Name & Description 10K 1/4W 1K 1/4W 47K 1/4W 47K 1/4W 4.7K 1/4W 10K 1/4W 2.2M 1/4W 22 2W 1.5K 1/2W 4.7 1/4W 4.7 1/4W 10K 1/4W 4.7 1/4W 2.7K 1/4W 2.7K 1/4W 47K 1/4W 4.7K 1/4W 8.2K 1/4W 47K 1/4W 56K 1/4W 56K 1/4W 10 1/4W 27K 1/4W 10 1/4W 10K 1/4W 3.9K 1/4W 3.9K 1/4W 10 1/4W 15K 1/4W 10K 1/4W 15K 1/4W 10K 1/4W 120K 1/4W 150K 1/4W 10 1/4W 10 1/4W 10 1/2W 10 1/2W 820K 1/4W 47K 1/4W 47K 1/4W CAPACITORS
Remarks [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M]
C503 C504 C505 C506 C507 C508 C509 C510 C513 C514 C515 C516 C517 C518 C519 C522 C523 C526 C527 C528 C529 C530 C531 C532 C533 C534 C543 C544 C545
F1D1H102A012 F1D1H102A012 F1D1H102A012 F1D1H102A012 F1D1H180A015 F1D1H180A015 F1D1H220A015 F1D1H220A015 F1D1H473A012 ECEA0JKA101B F1B2H103A060 F1B2H103A060 F1D1C103A007 F1D1H473A012 F1D1H473A012 F1D1H473A012 F1D1H473A012 F1D1H1040002 F1D1H1040002 F1D1H473A012 F1D1H1040002 F1D1H102A012 F1D1H102A012 F1D1H102A012 F1D1H102A012 ECA1HM330B F1D1H102A012 ECA1HM101B F1D1H1040002
1000P 50V 1000P 50V 1000P 50V 1000P 50V 18P 50V 18P 50V 22P 50V 22P 50V 0.047 50V 100 6.3V 0.01 500V 0.01 500V 0.01 16V 0.047 50V 0.047 50V 0.047 50V 0.047 50V 0.1 50V 0.1 50V 0.047 50V 0.1 50V 1000P 50V 1000P 50V 1000P 50V 1000P 50V 33 50V 1000P 50V 100 50V 0.1 50V
[M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M]
33
SB-WA930EE
Ref. No. C546 C547 C548 C549 C550 C551 C553 C554 C555 C556 C557 C558 C559 C560 C569 C570 C572 C573 C574 C575 C576 C577 C578 C579 C580 C601 C602 C603 C604 C605 C606 C607 C608 C609 C610 C611 C612 C613 C614 C615 C616 C617 C618 C619 C620 C621 C647 C648
Part No. ECA1SM332C5 ECA1SM472C5 ECA1SM472C5 ECA1SM332C5 F1D1C103A007 F1D1H103A046 ECQE2104KF3 ECQE1104KF3 ECEA1VKA4R7B F1D1H103A046 ECEA1CKA220B ECA1CM102B F1D1H103A046 ECA1HM100B F1D1H473A012 ECA1EM331B ECA1HM101B F1D1H102A012 F1D1H103A046 F1D1H103A046 F2J1H100A048 ECEA1CKA100B F1D1H103A046 F1D1H103A046 ECEA1HKA2R2B ECA1SM332C5 ECA1SM472C5 ECA1SM472C5 ECA1SM332C5 ECQE1104KF3 ECQE1104KF3 F1D1H180A015 F1D1H180A015 F1B2H103A060 F1B2H103A060 F1D1H102A012 F1D1H102A012 F1B1H103A153 F1B1H103A153 F1D1H473A012 F1D1H473A012 F1D1H103A046 F1D1H103A046 F1D1H473A012 F1D1H1040002 F1D1H1040002 ECA0JM471B F1D1H1040002
Part Name & Description 3300 100V 4700 100V 4700 100V 3300 100V 0.01 16V 0.01 50V 0.1 250V 0.1 100V 4.7 35V 0.01 50V 22 16V 1000 16V 0.01 50V 10 50V 0.047 50V 330 25V 100 50V 1000P 50V 0.01 50V 0.01 50V 10P 50V 10 16V 0.01 50V 0.01 50V 2.2 50V 3300 100V 4700 100V 4700 100V 3300 100V 0.1 100V 0.1 100V 18P 50V 18P 50V 0.01 500V 0.01 500V 1000P 50V 1000P 50V 0.01 50V 0.01 50V 0.047 50V 0.047 50V 0.01 50V 0.01 50V 0.047 50V 0.1 50V 0.1 50V 470 6.3V 0.1 50V
Remarks [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M] [M]
34
SB-WA930EE
14.4. Packaging
35
FLE0503/A/S/E/N/J/P