Академический Документы
Профессиональный Документы
Культура Документы
Submitted as partial fulfillment of the requirements for the Technical writing for the degree of Master of Technology in Communication Systems
FACULTY OF ENGINEERING AND TECHNOLOGY DEPARTMENT OF COMMUNICATION SYSTEMS PRIST UNIVERSITY THANJAVUR - 613 403. November - 2012
FACULTY OF ENGINEERING AND TECHNOLOGY DEPARTMENT OF COMMUNICATION SYSTEMS PRIST UNIVERSITY THANJAVUR - 613 403.
BONAFIDE CERTIFICATE
This is to certify that the Technical Writing titled ZIGBEE AND GPRS BASED ON METER READING SYSTEM is a bonafide record of work done by ILAYARAJA .V (2111272006) in partial fulfillment of the requirements for Technical writing for the degree of Master of Technology in Communication Systems of PRIST University, Thanjavur.
Internal Guide
External Examiner
Internal Examiner
ACKNOWLEDGEMENT
1. Chancellor 2. Pro chancellor 3. Vice chancellor 4. Dean 5. Director 6. Associate Dean 7. HOD 8. Internal Guide
Dr. P.Murugasen Dr.PSM.Kannan Dr.N.Ethirajalu Dr.Vincent H.Willson Prof MG.Abdhul Ganikhan Prof G.Kannan Prof A.Rijuvana Begum Asst.Proff. S.Dinesh Sundar
ABSTRACT
Because of the traditional way of metering error and low efficiency, we propose household metering system design based on Zigbee and GPRS technologies, using PIC18LF4620 as the core processor and CC2430 chip as close communication function, using SIM300 chip as Communications function in distance. Clustering structure of the network to reduce data traffic, Energy-saving sleep cycle has been achieved. Experiments have proved that this system can be safely.
ii
TABLE OF CONTENTS
TITLE
PAGE NO
ACKNOWLEDGEMENT SYNOPSIS CHAPTER 1: CHAPTER 2: CHAPTER 3: 3.1 3.2 INTRODUCTION LITERATURE SURVEY ZIGBEE AND GPRS TECHNOLOGIES ZIGBEE Technology GPRS Technology
i ii 1 1 2 2 6 7 7 8 9 9 11 12
CHAPTER 4: DESIGN OF SYSTEM STRUCTURE AND NETWORK 4.1 4.2 Structure of Design and Function Network Design Structure
CHAPTER 5: DESIGN OF HARDWARE 5.1 Design of Meter Reading Module Design 5.2 Interface of GPRS data transmitting module CHAPTER 6: SOFTWARE DESIGN
15 17 21