Академический Документы
Профессиональный Документы
Культура Документы
GX120/140/160/200/240/270/340/390 GXV140/160/270/340/390
1 2 4 8 9
10
FUEL
COMBUSTION ESSENTIALS
8 6 1 2
COMPRESSION
IGNITION
Before inspecting the fuel system, perform the minimum inspection for compression and ignition system.
Engine speed will not increase Poor performance at high speed Unstable engine speed
1
Pilot screw clogged. Remove foreign material/dirt. Replace pilot screw.
3
Engine will not start Difcult starting Engine starts but stops quickly
4
Main jet clogged. Remove foreign material/dirt.
Use needle A ( 0.5) to clean
10
9 4
4
5 7
11
Remove foreign material/dirt. Air ow Fuel ow Mixture
12
11
Drain gasoline from oat chamber by running the engine until it stops or by loosening the drain screw while engine is stopped.
When the cap is removed, the pilot screw breaks at the neck. To remove the remaining screw, t an appropriate rubber tube over the remaining stub and unscrew.
Install a new pilot screw and set it to the specied position. (Refer to shop manual.) Then install the limiter cap with LOCTITE 638.
10
Remove foreign material/dirt. Take care not to damage the seat surface.
12
Water inside oat chamber. Take off oat chamber and clean or replace.
Pump nozzle
Screw driver
www.honda-engines-eu.com