100%(4)100% нашли этот документ полезным (4 голоса)
7K просмотров3 страницы
The document outlines the steps and potential hazards involved in performing a pressure leakage test on pipes, including checking pipe lengths and joints, injecting water pressure using a manual pump, releasing water pressure, and having the site supervisor oversee each step and ensure safety procedures are followed.
The document outlines the steps and potential hazards involved in performing a pressure leakage test on pipes, including checking pipe lengths and joints, injecting water pressure using a manual pump, releasing water pressure, and having the site supervisor oversee each step and ensure safety procedures are followed.
Авторское право:
Attribution Non-Commercial (BY-NC)
Доступные форматы
Скачайте в формате XLS, PDF, TXT или читайте онлайн в Scribd
The document outlines the steps and potential hazards involved in performing a pressure leakage test on pipes, including checking pipe lengths and joints, injecting water pressure using a manual pump, releasing water pressure, and having the site supervisor oversee each step and ensure safety procedures are followed.
Авторское право:
Attribution Non-Commercial (BY-NC)
Доступные форматы
Скачайте в формате XLS, PDF, TXT или читайте онлайн в Scribd
STEPS/ PRESSURE LEAKAGE TEST POTENTIAL HAZARD HAZARDS CONTROL RESPONSIBLE PARTY 1) Check pipe length Trip hazard Watch your steps Site supervisor 2) Check mech. joints & pipe joints Trip hazard Proper handling of tools Site supervisor
Follow safety procedure for small tools
3) Check manual pump Parts defect/ Malfunction requirement inspection Site supervisor 4) Inject water pressure w/ manual pump Bursting of rubber hose Pump gradually/ constant observation Site supervisor 5)Water pressure established, repeat #2 Bursting of main pipes body and procedure its joints Initial backfill of trench Site supervisor 6) Check end caps Detachment where installed Secure support/ tightly installed Site supervisor 7) Release of water pressure Hit by pressurized water Complete PPE suits and stand clear Site supervisor REVISION: Concrete Batching Plant Requirements Description unit Qty 1) Design Mix 20N/mm2 or 3000 psi ( 28 days ) ea 1 2) Design Mix 28N/mm2 or 3500 psi ( 28 days ) ea 1 3) Test Certificate a. Cement ea 1 b. Sand ea 1 c. Gravel stone ea 1 d. Water ea 1 e. Admixture ea 1 4) Batching plant calibration certificate ea 1 5) Testing equipment calibration certificate ea 1 6) Concrete cylinder sample a. 3000 psi ( 28 days ) ea 3 b. 3500 psi ( 28 days ) ea 3
Note: All of the above, need to be submitted today to CTJV