Академический Документы
Профессиональный Документы
Культура Документы
Components required:i. ii. iii. iv. v. vi. vii. Two 68uf 25v tantalum capacitor.(C1,C2) Two 10 ohm, 5 watt Resistor.(R1,R2) Two 180 ohm, 1 watt Resistor.(R3,R4) Two 1N4007 Silicon Diode.(D1,D2) Two 2N3055 NPN Transistor.(Q1,Q2) One 24v Centre tapped Transformer.(T1) Other requirements like wire ,case etc.
The inverters use electro mechanical switch , to immediately switch to the mode of discharging circuit of the inverter as soon as there is a power cut. This technique uses electro magnetic force to either make or break the circuit, i.e to switch it on or off.
Within the Transformer, there are two coils namely primary and secondary coils. Number of turns in each of these coils is significant . let the number of turns in and e.m.f of the primary and secondary coils be N1,E1 & N2,E2;
Then they satisfy the relation : E2= -(N2/N1)E1 On the basis of the above relation ,the voltage output is determined.
NOTE: Tantalum capacitors are used instead of other capacitors because they do not have regular electrolytes which possibly over heat and explode.
References:
http://www.aaroncake.net/circuits/inverter.asp GOOGLE images.
THANK YOU