Академический Документы
Профессиональный Документы
Культура Документы
Cable Sizing
Standard in my country using IEC standard
Metric 50Hz
Tick Load Amp to use standard cable ampacity It means ETAP will select based on load FLA without concern with Voltage drop
Tick Vst Min to use calculated Voltage Start Minimum It means ETAP will select based on Voltage Drop when Starting Motor
Tick Short Circuit use calculated current withstand It means ETAP will select based on shortcircuit current (we will discuss later after I study about this)
Tick Short Circuit use calculated current withstand It means ETAP will select based on shortcircuit current (we will discuss later after I study about this)
Tick MF (multiplication factor) It means ETAP will select based on multiplication factor regarding with the application (we will discuss later after I study about this)
Tick Load Amp and Vst to combine the calculation It means ETAP will select based on FLA and Voltage start
Load Flow
Using Motor starting simulation to calculate Vst As we can see, even we set the Vst to 95% the result is 86.5%
Bus voltage
Motor current
Thank You