Вы находитесь на странице: 1из 1

Pipe Wall Thickness Calculation

Pipe Wall thickness Calculation Procedure for Internal Pressure (ASME B 31.3)
******************************************************************
Step1: Select the Pipe Material
-------------------------------------------------------------------------------------------------------Step2: List Down

Pipe Outside Diameter, (mm) = D


Internal Design Pressure,(Kg/cm) = P
Design Temperature, (C) = T

For the material under consideration.


-------------------------------------------------------------------------------------------------------Step 3: List down
Allowable Stress, (Kg/cm) = S
ASME B 31.3 @ Design Temperature. (TABLE A-1)
-------------------------------------------------------------------------------------------------------Step 4: Select
Joint Efficiency factor = E
Temperature Co-efficient = Y

(TABLE A-1A)
(TABLE-304.1.1)

ASME B 31.3 (TABLE-1A)


-------------------------------------------------------------------------------------------------------Step 5: Select
Corrosion Allowance, (mm) = c
-------------------------------------------------------------------------------------------------------Step 6: Formula @ ASME B 31.3
P*D
tm = ---------------------- + c
2*[(S*E) + (P*Y)]
tm= Calculated thickness including corrosion Allowance, (mm).
-------------------------------------------------------------------------------------------------------Step 7: Selection of pipe Schedule No.
TN
Ta =
--------------[1-(e/100)]
Ta = Thickness for selected pipe
TN = Available Thickness for selected pipe @ Sch No.
e = Mill Tolerance
-------------------------------------------------------------------------------------------------------Step 7: Compare thickness
If Ta > tm::::::::::: Then selected thickness of pipe is OK

Вам также может понравиться