Академический Документы
Профессиональный Документы
Культура Документы
ESLV90
English
13
23
34
Before operating this unit, please read these instructions completely and save them for future use.
, .
English
Important
This shaver has a built-in rechargeable battery. Do not throw into
fire, apply heat, or charge, use, or leave in a high temperature
environment.
Using the shaver
Caution
The outer foil is very thin and can be damaged if not used
correctly. Check that the foil is not damaged before using
the shaver. Do not use the shaver if the foil is damaged as
you will cut your skin.
Terminate the usage when there is an abnormality or failure.
Do not shave with soap or clean it with water when operating
with the AC adaptor.
Do not share your shaver with your family or other people.
Doing so may result in infection or inflammation.
This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience and knowledge, unless they have been
given supervision or instruction concerning use of the
appliance by a person responsible for their safety. Children
should be supervised to ensure that they do not play with the
appliance.
Persons using an implanted medical electronic device, such as
a pacemaker, should not allow this unit to touch the skin where
the medical electronic device is implanted because this may
cause a malfunction.
Charging the shaver
Never use the AC adaptor in the bathroom or shower room.
Do not use any power cord or AC adaptor other than the AC
adaptor (RE759).
Warning
Parts identification
a
c
e
b
d
f
g
English
Trimmer
Trimmer handle
Main body rear terminal
E Self-cleaning recharger
Water tank cap
Water tank
Water maximum line
Detergent cartridge
Socket
CLEAN lamp
DRY lamp
SELECT button
STATUS lamp
Cleaning tray
F AC adaptor (RE759)
Power cord
Appliance plug
Travel case
H Cleaning brush
I Oil
A Protective cap
B Outer foil section
1 Foil frame
2 System outer foil
3 System outer foil release
buttons
C Inner blades
D Main body
4 Foil frame release buttons
5 LCD panel
a. Used time
b. Battery capacity
c. Charge status
d. Sonic vibration
e. Foil/blade check
f. Clean
g. Battery capacity
6 Appliance socket
7 Lock ring
8 Power switch [0/1]
9 Finger rest
English
Charge
Charging using the self-cleaning recharger
Thoroughly wipe off any drops of water on or around the selfcleaning recharger so that it is dry before charging the shaver.
3
1
Cord shaving
If you insert the appliance plug to the shaver and plug in the
adaptor into a household outlet, you can use it even if the battery
capacity is low.
If the shaver does not work, continue charging it for approx. 1
minute.
Shave
Using the shaver
LOCK
You can lock the shaver head.
Page 3
We recommend using the shaver in an ambient temperature
range of 5 - 35C. If used outside this range, the appliance may
stop operating.
English
Caution
If you press the power switch for more than 2 seconds, the
sonic vibration cleaning mode is activated. Page 9
You cannot shave in this mode.
Do not place your fingers on the power switch while using the
shaver. This may cause the shaver to turn off or enter the sonic
vibration cleaning mode. Place your fingers on the finger rest
while using the shaver.
During use
After use
Clean
Cleaning using the self-cleaning recharger
Preparing the self-cleaning recharger
Remove the shaver and the appliance plug from the self-cleaning
recharger.
The used time and the
remaining battery capacity are
shown alternately after turning
off the shaver.
English
3
1
Course
English
1 Charge
2 Clean/Dry/
Charge
Clean
10 min
Dry
80 min
(170 min*)
Charge
0 to 60 min
Blinks
Glows
Continue a course.
English
Warning
Lubrication
To maintain shaving comfort for a long time, it is recommended
that the oil provided with the shaver is used.
1. Switch off the shaver.
2. Apply one drop of oil to each of the outer foils.
3. Raise the trimmer and apply a drop of oil.
4. Switch the shaver on, and run it for
approximately five seconds.
5. Switch off the shaver, and wipe off any excess
oil from the outer foils with a soft cloth.
It is not necessary to oil the blades after
cleaning the shaver with the self-cleaning
recharger. (Lubricant is included in the cleaning
detergent.)
(B)
10
inner blades
2 3
WES9171
Inner blades
WES9170
Detergent cartridge
WES035
Warning
Do not wash or apply water to the AC adaptor or selfcleaning recharger. Failure to observe this may cause
electric shock or result in short circuits.
When the water does not drain from the cleaning tray
Beard trimmings may clog the drain at the
bottom of the cleaning tray.
In this case, you cannot clean or dry the
shaver.
Push the beard trimmings down through the
drain with a toothpick etc.
English
Replacement parts
Do not pull hard on the rubber blade protector (a) at the bottom
of the cleaning tray. The rubber may come off if you pull hard on
it. It is only necessary to pull it up slightly.
11
12
Specifications
Power source
Motor voltage
3.6 V
Charging time
Approx. 1 hour
RE759
95%
13
Panasonic ESLV90
a
c
e
b
d
f
g
A
B
1
2
3
C
D
4
5
a. min
14
DRY
SELECT
STATUS
F RE759
H
I
E
CLEAN
b.
c.
d.
e. /
f.
g.
6
7
8 [0/1]
9
1
2
3
1
STATUS
1
2
1
2
3
10% 0% 100%
5 35
15
FREE
LOCK
1
2
14
5 35
2
19
16
5
10
[000]
10%
5 2
10%
14 3
2
3
Panasonic
WES035 Panasonic
17
15 35
2
3
3
1
2 /
/
/ /
/
18
0 60
10
80
170 *
0 60
/ /
3 /
180
0 60
/
/ /
* 15
0
/ /
/
[CLEAN]
1.
2.
3.
4. 2
4
20
5. 2
6.
5
7.
8.
9.
19
STATUS
1.
2. /
3.
1.
2.
3.
4.
5.
20
(A)
(B)
(A)
(B)
30
1.
2.
3.
4.
1.
2.
3.
1.
2 3
2.
ESLV90
WES9171
WES9170
WES035
a
21
Panasonic
1 4
22
3.6V
.
, , ,
.
.
.
.
.
AC
.
. .
( ) , ,
.
.
AC
.
AC (RE759) AC
.
AC
. .
.
.
.
. .
. , ,
.
.
.
.
.
.
AC .
.
.
.
.
.
.
23
AC
.
.
.
AC .
Panasonic ESLV90 .
.
.
.
95% .
.
.
a
c
e
24
b
d
f
g
E
(CLEAN)
(DRY)
(STATUS)
F AC (RE759)
H
I
.
.
.
, ,
A
B
1
2
3
C
D
4
5 LCD
a.
b.
c.
d.
e. /
f.
g.
6
7
8 [0/1]
9
3
1
.
.
.
.
(STATUS)
.
1 .
AC
. .
.
1 .
LCD
LCD 10% 0% 100%
.
5 .
1
.
2
.
AC
3
.
1
.
AC
2
.
25
5~35 .
.
LCD .
6
LCD .
.
2
. 30
.
.
.
.
.
.
FREE
.
1
2
24
5 ~ 35
. ,
.
.
.
.
.
26
LOCK
.
.
.
LCD
.
5
.
10
[0'00"] .
)
(
.
1
.
2
.
.
.
10% ) .
1 3 14
. (
.)
3
.
4
.
10% 1 ~ 2
.
(
.)
27
2
5
.
.
.
15 ~35 .
.
.
.
6 .
.
6 . 6
.
Panasonic
.
.
.
.
28
1
.
2
.
AC
3
.
3
1
.
.
.
.
4 .
.
/ /
/
.
6 .
.
.
.
.
2 / /
( )
0 ~ 60
10
80
(170 *)
0 ~ 60
[CLEAN]
.
.
,
,
.
3 /
180
0 ~ 60
AC
.
.
, .
.
( 15 )
*
.
( 0 )
. / /
(CLEAN) (DRY)
, /
(DRY) .
/ /
/ .
/ /
.
29
LCD
.
1. .
2. .
3.
.
4
4. 2
.
.
LCD
20 ,
.
5. 2
5
.
6. .
7.
.
8.
9. .
30
.
1.
2. /
.
3. .
.
1. .
2.
.
3.
.
4. 5 .
5.
.
.
.
2.
.
3. (
)
( )
.
.
.
4. (
)
.
(A)
.
,
.
(B)
.
.
.
(A)
(B)
1 LCD . (
.)
.
30 .
2 1
1.
.
2. .
( )
.
3.
.
2 3
1.
.
.
ESLV90
WES9171
WES9170
WES035
31
. .
.
1.
.
.
.
.
.
2.
.
.
.
.
.
.
.
.
1 ~ 4
.
(a)
. .
.
AC .
.
32
.
.
AC .
( )
3.6 V
33
ESLV90
()
(RE7-59)
34
95%
a
c
e
b
d
f
g
F (RE759)
H
I
E
(CLEAN)
(DRY)
(STATUS)
a.
b.
c.
d.
e. /
f.
g.
6
7
8 [0/1]
9
A
B
1
2
3
C
D
4
5 LCD
35
3
1
,
1
36
2
1
1
2
LCD
LCD 0% 100% , 10%
5
5-35
LCD
6
LCD
FREE
1
2
35
5 - 35
LOCK
2
41
37
LCD
5
[000]
10
( )
1 2 10%
()
10%
14
3 ()
38
2
5
15 35
6
6
6
3
1
// /
6
(
)
39
2 /
3 /
0 60
10
()
80
(170 *)
0 60
//
180
0 60
//
/
* (
15)
(
0)
//
/
40
[CLEAN] (
)
LCD
1.
2.
3.
4. 2
4
LCD
20
5.
5
2
6.
7.
8.
9.
1.
2. /
3.
1.
2.
3.
4. 5
5.
(
)
41
1.
2.
()
3.
(A)
,
,
(B)
(A)
2 3
(B)
LCD ()
30
1.
2.
3. (
)
( )
4. (
)
42
ESLV90
WES9171
WES9170
WES035
1.
2.
1 4
(a)
Lithium-ion
( )
3.6 V
43
Printed in Japan
ES9700LV901J Y0511-0