Академический Документы
Профессиональный Документы
Культура Документы
Sketcher:
1. What is the difference between position sketch and sliding sketch?
2. How the changes sketch support and how to isolate sketch support?
4. How many constrains are required to arrest the degrees of freedom of a point and
ellipse on a plane?
13. What is the difference between geometric constrain and dimensional constrain?
23. How to give the angle between ellipse major axis and to a line?
24. What are the difference ways to enter in the sketch work bench?
25. What are the different ways to exit from the sketcher work bench?
Part:
1. What is the result if 5 concentric circles are padded?
2. What is the difference between limit and offset in the pad command?
5. Explain the possible results if an open profile is padded in a thin rectangular block?
7. How material will be added to the supports from an open profile in merge ends
option?
9. What is the length of the pad if extended a pad with X length by using mirror extend
option?
10. What is the difference between up to surface and up to plane in limit types in pad?
12. If a sketch contain 5 different boundaries? Explain different possible ways to extrude
the sketch?
18. What is the difference between Merge ends and merge rib ends?
19. What are the different profile control types in rib option?
26. What is the difference between rib and multi section solid?
28. What are the different coupling modes in multi section solid option?
32. How an end profile will be oriented to the spine if we use re-limitation option?
38. What are the different variations in the variable radius fillet?
42. Why it is not possible give the face to face fillets to two vertical faces?
44. What is the difference between parting element, limiting element and neutral
element?
49. What is the difference between remove face and replace face?
52. What is the function project rotation axis on the reference plane?
69. What is the difference between geometrical set and ordered geometrical set?
72. If a part contains 5 bodies if I use the shell…which body will effect due to shell
command?
9. What is the difference between connect types “normal” and “base curve” in
connect curve options?
11.What is the difference between close a spline and giving first point as last
point?
12.Define curvature?
13.What are the different radius variation methods in the helix option?
20.How to know the closing points in blend option when there is open section
are used?
28.Function of un trim?
40.Define spine?
47.What are the different parameters we can change by using law option in
sweep option?
49.Is it possible to give a curve as center curve to rotate a profile about a curve?
Assembly design:
1. What is the difference between product and a component?
15.What is the difference between save, save all and save management?
19.What is the difference between save, save as, save all, save
management?
Drafting:
1. What is associative drawing and non-associative drawing?
4. What is the difference between offset section view and offset section cue?
5. What is the difference between offset section view and aligned section
view?
6. What is the difference between detail view and quick detail view?
26.Is it possible to place a existing text table in the drawing sheet? How?
General: