A stepped steel shaft consists of a hollow shaft 2m
long, with an outside diameter of 100 mm and an
inside diameter of 70mm, rigidly attached to a solid shaft 1.5m long, and 70mm in diameter. Determine the maximum torque that can be applied without exceeding a shearing stress of 70MPa or a twist of 2.5o in a 3.5 m length. Use G=83Gpa
A solid steel shaft is loaded as shown. Using
G=83Gpa, determine the required diameter of the shaft if the shearing stress is limited to 60MPa and the angle of rotation at the free end is not to exceed 4.
A flange bolt coupling consists of 6-10mm
diameter steel bolts on a bolt circle 300mm in diameter and 4-10mm diameter steel on a concentric bolt circle 200mm in diameter. What torque can be applied without exceeding a shearing stress of 60MPa in the bolts? B) Determine the number of 10mm steel bolts that must be used on the 300mm bolt circle of the coupling to increase the torque capacity to 8KN-m.
The connection of 12 rivets shown, the load P =
200kN passes through the center of rivet C and has a slope of 4/3. Determine the resultant load on A flanged bolt coupling consists of eight steel 20mm bolts spaced evenly around a bolt circle of300mm in diameter. Determine the torque capacity of the coupling if the allowable shearing stress in the bolts is 40MPa.