Installation

Installation manual
manual
Installation
???????? of the roof outlets

5.4 Moisture barriers

On request, Wavin can supply moisture
barrier flanges that will secure a vapour
tight seal between the tail pipe and the foil
in the roof, which is used as a moisture
barrier. A rubber ring will secure the
vapour tight seal with the tail pipe while
the foil will be clamped between the
flange parts.

Figure 36. Shaft and cover for installation on a green roof.

Figure 34 and 35. Moisture barriers.

transferred to these parts of the roof

Each heating element consumes 3 Watt

construction. For parking decks a similar

in stand-by mode and takes 18 Watt

construction can be supplied. Please

when heating. Voltage is single phase

consult Wavin for further details.

230 VAC.

5.5 Wavin QuickStream

outlets on green roofs
and parking decks

5.6 De-icing electrical

heating elements

Wavin has developed special perforated

Wavin QuickStream roof outlets can be

shafts DN 315 wrapped with geotextile

provided with an automatic electric heating

that can be placed around standard

system. A heating system prevents

(QuickStream) roof outlets. The shaft can

blockage of the outlet in case of ice-rain,

be easily cut to the required height with a

freezing melt water or snow.

minimum height of 200 mm. The cover

A built in temperature probe will

should be positioned not higher than the

automatically switch-on the heating plate

adjacent surface. Depending on the load

when ambient temperature drops below

situation, various covers with gratings can

+ 4 C.

be supplied. The maximum load on the

The heating element (see figure 37) is

shaft should not exceed 15000 N. Prior

placed between the external surface of

to installation, the installer needs to check

the sump pan and the thermal insulation

whether the roof construction and the

pack. See also chapter 8.3; Thermal

roof foil can withstand the loads to be

insulation.

Figure 37. Heating element.

Wavin QuickStream PE
www.wavin.com

21