Вы находитесь на странице: 1из 1

Page 1

413/470/670 TECH NOTES

Delay in reverse cold only, rear servo shows slow pressure rise.
Servo seal not working or feed hole in plate over reverse less than .055. Replace seal, open feed
hole to .055, check for bent band strut. May use A4lD flat servo strut by removing adjuster bolt then
installing strut, readjust band.
Late 1-2 up shift, worse with temp. Line is normal & TV backed off all the way but minimum hot min
1-2 is still 25 mph.
Governor valve bore worn or wrong governor installed.
No up shifts or may have had up shifts once or twice but lost them/ no governor pressure.
tubes bent downward and blew out of case, rebend tubes so they are angled up slightly as vb is positioned in the car. Governor stuck also can cause this.
2nd StartsBinds in Low
Accumulator piston broken or rings cut

TransGo 2006

Вам также может понравиться