In the Control Block Word 2 is a Command Flag Register. Bit 7 is Buzzer Flag, this bit is used to control the operator terminals buzzer. Set the bit to ON (about 1 sec.) to start the buzzer. In the following example, a maintained button is used to set / reset the Buzzer Flag. Set the Address of the Control Block:
Choose the maintained button and double click on it:
ABB STOTZ-KONTAKT GmbH
Title
Lang.
Rev.
CP400 first steps
en
Page
54
No. o. p.
58
Set the write address as following:
Name the button of two states:
And there will be a button which activate and deactivate the buzzer: