Академический Документы
Профессиональный Документы
Культура Документы
Pressure Transmitter:
Close the main manual root isolation valve.
1. Close the manifold & keep safe the O ring of manifold & cover the
manifold properly.
2. Isolate the power supply with Insulation Tape.
3. Remove the transmitter from line.
4. Connect Tx into corresponding Tx calibration unit.
( If it is below 2 kgf/cm2 = use vaccum calibrator)
( If it is above 2 kgf/cm2 = Use press calibrator)
5. Connect 24 Vdc power supply across signal TB ( Inside the Tx)
6. Calibrate the Tx for the range required.
After Calibration: