Академический Документы
Профессиональный Документы
Культура Документы
The design head for side and end bulkhead plating and stiffeners of deckhouses on the freeboard deck is to
be obtained from the following:
h = c hb
where
h
So;
h = c hb
h = c hb
h = 1 x 6.847
h = 0.6 x 6.847
Plating
The plating thickness is not to be less than that obtained from the following equation:
t = 3s h mm
t = s/50in. h
In no case is the plate thickness to be less than 5.0 + 0.01L mm (0.2 + 0.00012L in.).
where
s = spacing of stiffeners, in m (ft)
h = design head, as defined in 3-2-3/15.3
So ;
t = 3s h mm
= 3 x 0.610
= 4.78 mm
6.847
Stiffeners
Each stiffener in association with the plating to which it is attached is to have a section modulus, SM, not
less than that obtained from the following equation:
SM = 3.5 sh2 cm3
SM = 0.00185 sh2 in3 ABS MODU 2014, Part 3-2-3/15.3 Page no.
82
where
s