S.

NO

ALARM DETAILS

ALARM CODE

VERIFICATION

To check the alarm Switch off the

1

Rectifier Mains Failure

7401

mains MCB from PIU.

To remove alarm turn on the

mains MCB.
To check the alarm first remove the

Rectifier Module Failure

7402

rectifier from the SMPS or switch off

the MCB of rectifier from SMPS.

To remove alarm switch on the MCB

of the rectifier module or insert the
new rectifier module.

Rectifier Major Fault

(Low Battery Voltage)

7403

To check the alarm set o/p voltage of

battery less than 48v.and then switch
of the mcb from PIU.
To remove the alarm switch on the
mcb.

Rectifier Minor Fault

(Site On Battery)

7404

To check the alarm switch off the

mains mcb from PIU.
To remove the alarm switch on the
mains.

To check the alarm rub thermister in

b/w hands .
5

High Room Temperature

7411

To remove alarm switch on the AC &

set AC temp on desired value.

To check the alarm open the door.

6

Shelter Door Open

7410

To remove alarm close and seal

proper the door.

To check the alarm create a small fire

7

by paper or jute.

Smoke Detected in
Shelter

7412

Air Condition Failed

7409

To remove alarm Reset smoke & fire

sensor and clean the smoke from the
sensor.
To check the alarm switch off the ACs.

To remove alarm switch

on/repair/replace ACs.
To check the alarm see if the desired
fuel level of DG is set on 40% or not.

10

Low Fuel

DG on Load

7407

7405

To remove alarm fill the tank of DG.

To check the alarm switch off the
mains MCB from PIU & switch on the
DG (if it is not in auto mode).

To remove alarm switch on the mains

MCB (if mains is available).

To check the alarm switch off the

12

DG on no Load

7408

mains mcb from PIU and check dg set

is not in auto mode or remove the
connection b/w PIU and Self.

To remove alarm start DG in manual

mode.

ASSOCIATE ALARMS

STATUS

site on battery.
(7404)

ok

site on battery. (7404)

ok

Rectifier mains failure.

(7401)

ok

Rectifier mains failure.

(7401)

ok

Ac fails (7409)

ok

ok

Rectifier minor fault

(7404)(site on battery),
A/C failed(7409), DG on
load (7405)

ok

ok

ok

Rectifier Minor fault

(7404)(site on battery).

ok

Rectifier Minor fault

(7404) (site on
battery).

ok

battery).