14. The three-dimensional truss shown in the accompanying figure is made of aluminum alloy
(E = 104 x 10*Ibvin®) and is to support a sign weighing 1000 Ib. The Cartesian coordinates
of the joints with respect to the coordinate system shown in the figure are given in feet. The
‘cross-sectional area of each member is 3.14 in”. Using ANSYS, determine the deflection of
joint E, the stresses in each member, and the reaction forces. Verify your results,
D (-05, 20,20)
(0.0.2) 1000 tb
E(1.0,25,0)
18. The three-dimensional truss shown in the accompanying figure is made of steel (E =
29 x 10° psi) andis to support the load shown in the figure. The Cartesian coordinates of the
joints with respect to the system shown in the figure arc given in feet. The cross-sectional
aca of each member is 3.093 in?, Using ANSYS, determine the deflection of each joint, the
stresses in each member, and the reaction forces. Verify your results.11. The members of the roof truss shown in the accompanying figure have a cross-sectional area
of approximately 21.5 in? and are made of Douglas-fir wood with a modulus of elasticity of
E = 19 x 10° Ibfin’. Using ANSYS, determine the deflection of each joint, the stresses in
each member, and the reaction forces. Verify your results. Also, replace one of the fixed
boundary conditions with rollers and obtain the stresses in each member. Discuss the differ-
ence in results.
12, ‘The members ofthe floor truss shown in the accompanying figure have a cross-sectional area
of approximately 21.5 in’ and are made of Douglas-fir wood with a modulus of elasticity of
E = 19 X 10° Ibvin’. Using ANSYS, determine the deflection of each joint, the stresses in
each member, and the reaction forces. Verify your results. Also, replace one of the fixed
boundary conditions with rollers and solve the problem again to obtain the stresses in each
member. Discuss the difference in results.
S001 0016 001 S001
NN9. Consider the power transmission-line tower shown in the accompanying figure. The members
have a cross-sectional area of 10 in’ and a modulus of elasticity of E = 29 x 10°lbvin?. Using
ANSYS, determine the deflection of each joint, the stress in each member, and the reaction
forces atthe base. Verify your results.
$.at101 +
ni noo 6 15 164.13, ncventre las deflexionss en los nuos pre la armadura mostada en la figura P4.13, Area transversal
in? para cada miembro.
1D kip
anon |19, The three-dimensional truss shown in the accompanying figure is made of steel (E =
29 x 10° psi) and is to support the load shown in the figure, Dimensions are given in feet. The
‘cross-sectional area of each member is 3.25 in?. Using ANSYS, determine the deflection of
each joint, the stresses in each member, and the reaction forces. Verify your results.
y