Академический Документы
Профессиональный Документы
Культура Документы
D-box® SN
D-box® CN
D1
D-box
Contents
GENERAL OPERATION of the D-box 3
SAFETY INSTRUCTIONS 3
REMOTE CONTROL 4
Back, Satellite Version 5
Back, Cable Version 5
Front, Satellite Version, Cable Version 6
USING THE SMART CARD 6
Pay TV services with a Smart Card 6
PIN Code 6
INSTALLATION of the D-box 7
The SCART sockets 7
Activate the remote control 7
D2
General Operation of the D-Box
They become state that the everyday normal operation of the D box on
one and menus screen-indicate row user-friendly picture be based.
These menus permit an exhausting of the full function spectrum to the
D-box and lead it by the installation, selection of channels as well as
indicating and other one Function.
All functions can be started over the keys on the remote maintenance;
some Functions can additionally over the keys on the operator console
are implemented. The D-box is easy to serve, at any time applicable
and for future functions expandable.
Note: Before you return the D-box to customer service for repair,
please try the following:
Try, to load a new version of the operating system into the D-box.
SAFETY INSTRUCTIONS
• Leave sufficient space around the D-box • Do not remove the outer cover.
for ventilation
• Do not expose the equipment to very
• Do not place anything on the D-box or put high or low temperatures or areas of
near a heat source. high humidity.
• Use a soft cloth and a mild cleaning • The equipment may only be repaired by
solution to clean the housing. an authorised Nokia or Premiere World
• Make sure no moisture or humidity can dealer.
enter the D-box. • The only way to remove the mains
• Do not connect cables to the D-box while voltage from the D-box is to remove the
the mains power is connected. mains cable from the wall socket!
• If you move the equipment from a very
cold area into an area of warm ambient
temperature then allow the D-box to
acclimatise before turning it on.
D3
REMOTE CONTROL
This section describes how the D-box is steered via the keys of the remote control. Some the functions can be
implemented also over the keys of the operator menu.
On/Off (Standby)
Red
Green
Text function keys, Function keys for on screen menus,
Yellow (function is menu dependant)
Blue
Audio mute
D4
Back, Satellite Version
D5
Front, Satellite/Cable Version
CARD: 1 CARD: 2
For a Smart Card For a Smart Card For activating and The up/down for use in the
deactivating the menus and for changing
Standby mode channels
Only for Pay TV services which are coded with the Beta Crypt
system
• Insert the Smart Card into the opening behind the cover on
the front of the D-box. The gold reference chip should point
downward and inward!
The gold chip must be on
PIN Code the lower surface and
inward on the smart card.
The Smart Card has a four digit code, also known as a PIN code
(Personnel Identification Number) this code is needed for the
access to future services from the service provider.
D6
INSTALLATION of the D-box
• The D-box.
• 2x AAA batteries pre installed in the remote control.
• A completely wired SCART cable (1 metre)
• Instruction Manual.
SCART CABLE
• Prepare the cable ends. Then bend the excess back over the
outer cable (see illustration)
• Push the F-plug onto the cable and turn clockwise until it sits F-Plug
firmly on the inner screen.
3 mm
• At the end of the F-plug there should still be roughly 3mm of
inner core showing.
D7
INSTALLATION of the D-box
TV
Video 2 1
D-box
Similar SAT - The key “0” switches you between signals from terrestrial TV
receiver and Video as well as back and forth between digital satellite to
receiver and d-box.
Connection to a similar SAT - receiver and a VCR with two SCART sockets.
TV
2 1
Video
D-box
VCR TV
Video 2 1
D-box
D8
Connections, Cable Version
TV
Video 2 1
d-box
TV
Video 2 1
d-box
D9
TECHNICAL DATA, Satellite version
Transmission standard
VCR STEURUNG
DVB-S, MPEG-2
Connexion 1 x RCA, IR transmitter
LNB/doing he entrance
Connexion 1x F-type (LNB)
TELEPHONE MODEM
Grinding through exit 1x F-type
Connexion Modular jack 6-pol, RJ-12
HF-impedance 75 & Minutes V.90 56 kbit/s
HF-incoming frequency 950-2150 MHz
HF-Eingangssignalstärke - 20 tons - 70 dBm
ETHERNET 10BaseT
Supply voltage 13,5/18.5 V ± 5% Connexion Modular jack 8-pol, RJ-45
Max. amperage 400 mA, overload-protected
Steering wheel signal 22 kHz, 0.65 V pp Smart Card interface:
Modulation QPSK Cutting hurry for two maps in accordance with ISO 7816
Symbol rate 1 - 45 ms/s Supports integrated Descrambler Betacrypt
DiSEqC 1.0 (1.1) Front LED display, 120 x of 64 segments,
Keys: , (Standby, program number
TV SCART upward/downward)
CVBS or Y/C 1 Vpp ± 1 railways/RL 75 &
exit (C± 1 railways rel. Y ampl)
General data
Audio exit 0.5 V rms/RL 10 kΩ
Article number: The model code, the variant and the serial number
RGB exit 0.75 V pp ± 1 railways/R
L 75 &
are on the housing lower surface.
RGB range 5.8 MHz ± 3 railways
Software: After switching on on appear to the D-box
Nearly blank 0/1.3 V/R L 75 &
first the software and boat version in
Status exit 0/6/12 V/R L 10 kΩ
CVBS entrance 1 Vpp/RL 75 & Display.
Audio entrance 0.5 V rms/RL 10 kΩ Supply voltage 230 V AC ± 15%, 50 cycles per second
Power input max. 27 W with 400 mA LNB load
Power input in the Standby enterprise 3.5 W
VCR SCART Operating temperature +5° C to +45° C
CVBS or Y/C exit 1 V ± 1 railways/RL 75 & Storage temperature - 40°C to +65° C
(C± 1 railways rel. Y ampl) Humidity 25 to 90% rel. Air humidity
Audio exit 0.5 V rms/RL 10 kΩ Maximum range of the remote maintenance: 10 metres
CVBS (or Y) entrance 1 V pp/RL 75 & Dimensions (B x T x H) 380 x 240 x 65 mm
RGB (or C) entrance 0.7 V pp/RL 75 & Weight approx. 1.8 kg
(C brush 0.34 V pp)
Status entrance 0/6/12 V/R L 10 kΩ SCART buchse
Nearly blank (RGB) 0/2 V/R L 75 & TV VCR
DIGITAL AUDIO 1 Audiofrom. right K. audiofrom. right K.
International Electronical 2 Audio-Ein. right K
Data minutes
Commission 958 (optical) 3 Audiofrom. left K. Audiofrom. left K.
AUDIO R L 4 Audio mass Audio mass
Connexion 2 x RCA (R+L) 5 RGB blue mass RGB blue mass
Exit 0.5 V r± 0.5 railways/RL 10 kΩ 6 Audio-Ein. left K.
7 RGB blue Signalaus. RGB blue Signalein.
SERIAL CONNEXION (R-S 232) serial data
8 Switch tension from. Schalterspannungein.
Connexion 9-polig D-Sub, plug
9 RGB green mass RGB green mass
Signals RS232, max. 56 kbit/s
Pole 1 DCD (DATA carrier detect) 10 AV left
not attached 11 RGB green Signalaus. RGB green Signalein.
2 RXD (Receive DATA) 12 -
3 TXD (Transmit DATA) 13 RGB red mass RGB red mass
4 DTR (DATA terminal ready) on „highly “ 14 High-speedfrom-groped.- Mass high-speedfrom-grope.- Mass
set 15 RGB red Signalaus. RGB red Signalein.
5 GND (Signal ground) 16 High-speedfrom grope from.Schnellaustast.ein.
6 DSR (DATA set ready) not attached 17 Video output mass video output mass
7 RTS (Ready ton send) 18 Video entrance mass
8 CTS (CLEAR ton send)
19 Video exit Video exit
9 RI (Ring indicator) not attached
20 Video entrance
21 Mass (housing) Mass (housing)
20 2
This equipment fulfills the standard 89/336/EEC
21 1
D 10
TECHNICAL DATA, cable version
D 11
D-box, Satellite Version
D 12