0 оценок0% нашли этот документ полезным (0 голосов)
398 просмотров1 страница
Waste pipe is classified into direct waste or indirect waste depending on if it is directly or indirectly connected to the plumbing system. Pipe fittings like long sweep bends are used to change the direction of waste flow. The bacteria found in sewage are mostly anaerobic. Copper pipes are best for hot water installations. Disinfection of drinking water removes bacteria.
Waste pipe is classified into direct waste or indirect waste depending on if it is directly or indirectly connected to the plumbing system. Pipe fittings like long sweep bends are used to change the direction of waste flow. The bacteria found in sewage are mostly anaerobic. Copper pipes are best for hot water installations. Disinfection of drinking water removes bacteria.
Waste pipe is classified into direct waste or indirect waste depending on if it is directly or indirectly connected to the plumbing system. Pipe fittings like long sweep bends are used to change the direction of waste flow. The bacteria found in sewage are mostly anaerobic. Copper pipes are best for hot water installations. Disinfection of drinking water removes bacteria.
into two ways, according to the type it serve, direct waste as one terminal solidly joined to the plumbing system, whereas indirect waste has terminal drain pipes simply empty into the; a.Plumbing system b.Environment c.Canal d. None of these 2.
Pipe fitting are intended to
make change direction, turn and offset, but their use must be planned carefully so that waste within the line have free passage, the fitting use in vertical to horizontal changes of direction is: a. long sweep bend b. tee c. wye fitting d. all of these
3. The bacteria in sewage
are mostly: a-anaerobic b-parasitic c-saprophytic d-pathogenic 4. The pipe that is
remarkable for hot water
lure installation: a. Copper pipes b. Brass pipes c. Stainless pipes d. Synthetic pipes 5. A state of complete
physical mental and
social well-being and not merely the absence of disease or infirmity. a. Health b. Vital statistics c. Fitness d. Statics
6. The rate of flow of liquid
measured per unit of time, usually gpm or lps. a. Capacity b. Static rate c. Flow rate d. Pump rate 7. Corrosion in pipe, what is the by-product of chemical reaction of oxidation in forming ferrous oxide or rust is covered by the action of: a. Carbon dioxide b. Sulfur oxide c. Methane gas d. All of these 8. What is that receptacle installed at corner wall that collect rain water from a balcony
9.
a. Downspout b. Bee-hive roof drain c. Roof drain d. Scupper drain Disinfection of drinking water is done to remove
11. The non-soluble materials
which is the end product after biological action of bacteria in waste and what settles at the bottom of the septic tank is called: a. Scum b. Sledge c. Sludge d. smudekne 12. How do you connect pump in series? a. Different RMP b. Same gpm c. Same horsepower d. Different pressure 13. Determine the water nature through acidity or alkalinity is; a. pH value b. color meter c. pH meter d. none of the above
15.
a. Bacteria b. Color c. Odor d. Turbidity
10. A type of valve which
should be used only wide open or fully closed a. Gate valve b. Globe valve c. Reducing valve d. Throttle valve 11. Drinking fountain or bubbler when they are located in the building may be connected to the pipe that terminate into: a. Soil pipe b. Waste pipe c. Wet vent d. Vent tank
14. The volume of a liquid
passing through a cross section of a stream in unit time is called: a. Steady flow b. Uniform flow c. Continuous flow d. discharge 15. Instrument used to measure the water flow a. Venture meter b. Pressure gauge c. Dynamometer d. Pitot tube 16. Pour index horsepower is how many foot lbs per minutes a. 30,000 b. 33,000 c. 33,333 d. 30,333