Академический Документы
Профессиональный Документы
Культура Документы
Rev. No. : 00
Amendment No.: 00
Date : 19.08.2008
Page No. : 1 of 1
_____________________________
_____________________________
_____________________________
_____________________________
_____________________________
_____________________________
_____________________________
______________________________
Calibration Table:
Transmitter Range :
Range Checked
Lower Range Value
Expected O/P
Observed O/P
% Deviation
Accepted
Actual
After taken in line reading at local display and DCS graphics:_______________ mmHgA
Calibration done by technician
_____________________________
Calibration Date:
_____________________________
_____________________________
_____________________________
Remarks if any:
_____________________________
Rev. No. : 00
Amendment No.: 00
Date : 19.08.2008
Page No. : 1 of 1
After completion of the Job on Diaphragm type Pressure Transmitter check the following things
physically.
YES
NO
1) Capillary is properly routed
2) Capillary is properly supported
3) Stanchion is properly supported
4) Stanchion is not corroded
5) Transmitter properly mounted on stanchion
6) Gland is proper
7) Cable is supported properly
8) Tag no. written on stanchion is correct.
9) Tag no. written on cable is correct
10) Flange is properly fixed.
11) Stud and bolts are properly fixed
12) Steam tracing is proper.
13) Area is cleaned
14) Monsoon protection done
15) Canopy health ok
16) There is no vibration
17) Any abnormalities above to be reviewed by concern engineer
Immediately.
Checked by Technician: _ ________________________________
Date:
_____________________
Accepted by Engineer:___________________________________
Note: All above non compliance are attended and made ok
Signature of Engineer:__________________________________
Date:
___________________________________