Академический Документы
Профессиональный Документы
Культура Документы
Removal
1.
2.
Raise and support the vehicle. For additional information, refer to Section 100-02.
NOTE: Both the left side and the right side outer tie-rod ends are removed the same way. Only the left side is shown.
Remove the nut.
3.
4.
1.
2.
Using the special tool, remove the tie-rod end from the front wheel spindle.
NOTE: Count the number of threads on the old tie-rod end from the end of the shaft to the scribe mark. This is the number of threads that the tie-rod end should be installed
into the front wheel spindle tie-rod adjusting sleeve.
Remove the outer tie-rod end from the front wheel spindle tie rod adjusting sleeve (3310).
1.
Scribe a mark into the threads on the tie-rod end where shown.
2.
3.
Installation
1.
NOTE: Do not tighten the clamp on the front wheel spindle tie-rod adjusting sleeve until the front wheel alignment has been checked.
NOTE: Both the left side and the right side outer tie-rod ends are installed the same way. Only the left side is shown.
Install the tie-rod end into the front wheel spindle tie-rod adjusting sleeve.
2.
3.
4.
Check the wheel alignment. Adjust as necessary. For additional information, refer to Section 204-00.