Вы находитесь на странице: 1из 100

CHAPTER TWO:

Sources of Water Supply


DBU, Institute of Technology
College of Engineering
Department of Civil Engineering
Abraham Atnafu
DBU

Chapter two: Sources of Water Supply

Introduction

Nature of water source determines the components of the


water supply system
Factors to be considered to select source:
Quantity
Quality
Reliability
Safety

of source
Water rights
Environmental impacts
DBU

Chapter two: Sources of Water Supply

Hydrologic Cycle:

DBU

Chapter two: Sources of Water Supply

Hydrological Cycle
The water cycle, also known as the hydrologic cycle, describes the continuous
movement of water on,above and below the earth surface. The sun, which
drives the water cycle, radiates solar energy on the oceans and land.
Key Hydrological Processes
Precipitation : Condensed water vapor that falls to the earth surface. Most
precipitation occurs as rain, but also includes snow, hail, fog drip, sleet, etc.
Runoff: The variety of ways by which water moves across the land. This
includes both surface runoff and channel runoff. As it flows, the water may
infiltrate into the ground, evaporate into the air, become stored in lakes or
reservoirs, or be extracted for agricultural or other human uses.
Infiltration: The flow of water from the ground surface into the ground.
Once infiltrated, the water becomes soil moisture or groundwater.

DBU

Chapter two: Sources of Water Supply

DBU

Subsurface Flow: The flow of water underground, in the vadose zone and
aquifers. Subsurface water may return to the surface (e.g. as a spring or by
being pumped) or eventually seep into the oceans. Water returns to the
land surface at lower elevation than where it infiltrated, under the force of
gravity or gravity induced pressures. Groundwater tends to move
slowly, and is replenished slowly, so it can remain in aquifers for thousands
of years.
Evaporation and transpiration: The transformation of water from liquid to
gas phases as it moves from the ground or bodies of water into the
overlying atmosphere. The source of energy for evaporation is primarily
solar radiation. Evaporation often implicitly includes transpiration from
plants, though together they are specifically referred to as
evapotranspiration.
Chapter two: Sources of Water Supply

Types of water supply sources


Surface Water Sources

Ground Water Sources

Rain Water

Spring Water

Lakes and reservoirs


River Water
Sea water
DBU

Wells

Infiltration galleries

Chapter two: Sources of Water Supply

Rain water
Rain water might contain dust, smoke, bacteria, carbon
dioxide as falling from high altitude
RW Harvesting- roofs are most effective and can be integrated
with tanks

DBU

Chapter two: Sources of Water Supply

DBU

Chapter two: Sources of Water Supply

Rain water

Advantages of rainwater collection:

Disadvantages

DBU

Quality of RW is high
Independent
Local materials can be used for collection
No energy costs
Easy to maintain
Time saving and convenient
High initial cost (i.e. for a family)
Quantity of water is dependent on the roof area and rainy seasons
Flat taste

Chapter two: Sources of Water Supply

Lakes and reservoirs


water in wet seasons for usage in dry seasons
It is a standing water; because of this:
AAiT, Zerihun Alemayehu

Store

Quality is very low: turbidity, bacteria and pollutants


Thermal stratification (i.e. for deep lakes/reservoirs)

Lake Tana

River water

Abay river
DBU

Chapter two: Sources of Water Supply

River water
A stream or river is a body of running water on
the surface of the earth, from higher to lower
ground.
Their capacity is dependent on minimum flow per
day
Development of rivers requires :

submerged

intake structure
small diversion dams (i.e. for small streams)
Abay river
DBU

Chapter two: Sources of Water Supply

Groundwater sources

Aquifer

DBU

Chapter two: Sources of Water Supply

Groundwater sources

Advantages :
It

is likely to be free of pathogenic bacteria


free from turbidity and colour
It can be used without further treatment
It can be found in the close vicinity
It is economical to obtain and distribute
The water-bearing stratum provides a natural
storage at the point of intake.
DBU

Chapter two: Sources of Water Supply

Groundwater sources

Disadvantages
often

have high in mineral content;


It usually requires pumping.

DBU

CATIONS: calcium, magnesium, iron and manganese


ANIONS: bicarbonate, carbonate, and chloride

Chapter two: Sources of Water Supply

Springs
Spring water is a groundwater that
outcrops from ground due to impervious
base that prevents percolation.
Mostly found from sand or gravel aquifers

DBU

Chapter two: Sources of Water Supply

Gravity springs

GW flows over an impervious stratum onto the ground


surface
The yield varies with the position of the water table
May dry up during or immediately after a dry season

Gravity overflow spring


DBU

Gravity depression spring


Chapter two: Sources of Water Supply

Artesian springs

High quality water due to confinement


High discharge due to high pressure in the confinement
Yield is likely uniform and nearly constant over the seasons
of the year

Artesian depression spring


DBU

Artesian fissure spring

Chapter two: Sources of Water Supply

Infiltration gallery

DBU

Horizontal wells that collect water over practically their


entire lengths.
Simple means of obtaining naturally filtered water

Chapter two: Sources of Water Supply

Recharge of aquifers

Replenishment (filling) of aquifers is known as recharge


Unconfined

aquifers are recharged by precipitation


percolating down from the lands surface
Confined aquifers are generally recharged where the
aquifer materials are exposed at the lands surface -called
an outcrop.

DBU

Chapter two: Sources of Water Supply

Recharge of aquifers

DBU

Chapter two: Sources of Water Supply

Recharge of aquifers

When surface water loses water to the adjacent


aquifer, the stream is called a losing stream.
water flows from the ground water to the stream, it is
called a gaining stream.
Groundwater
table

Aquifer

Impervious layer

DBU

Chapter two: Sources of Water Supply

Water quality considerations


Water quality considerations of sources are required for the following purposes

To evaluate and classify raw water quality

physical, chemical, and bacteriological parameters


raw water can be classified as having poor, fair, and good quality.

To identify sources of pollution


Surface water: urban runoff, agricultural runoff, industrial
discharge, and leachate from landfills;
Groundwater: infiltration from pit-latrines and septic tanks, landfill
leachate, and infiltration from polluted areas.

To assess the treatment required for beneficial uses

DBU

level of treatment and unit process required are dependent on the


raw water quality
Chapter two: Sources of Water Supply

Treatment types
For groundwater having excellent quality
Well

Aeration

Disinfection

Fluoridation

For groundwater having moderate quality


Well

DBU

Rapid sand
filtration

Aeration

Disinfection

Fluoridation

Chapter two: Sources of Water Supply

Treatment types
Good quality upland reservoir
Reservoir

Microstrainer

Disinfection

Fluoridation

Moderate to poor quality lowland river


Reservoir

Screening

Fluoridation
DBU

Coagulation

Disinfection

Sedimentation

Filtration

Chapter two: Sources of Water Supply

Source selection

Surface water sources

DBU

Safe water yield during the drought years


Urbanization and land development in the watershed
Proposed impoundments on tributaries
Water quality
Assessment of reliability
Requirements for construction of water supply system components
Economics of the project
Environmental impacts of the project
Water rights
Chapter two: Sources of Water Supply

Source selection

Ground water sources


Aquifer

characteristics (depth, geology)


Safe aquifer yield
Permissible drawdown
Water quality
Source of contamination(gasoline, oil, chemicals)
Saltwater intrusion(areas near to seas or oceans)
Type and extent of recharge area
Rate of recharge
Water rights
DBU

Chapter two: Sources of Water Supply

Reservoirs
o Contain dam to hold water
o A spillway to allow excess water to flow
o A gate chamber with valves to regulate flow
An artificial lake formed by the
construction of a dam across a valley

DBU

Chapter two: Sources of Water Supply

Reservoirs
The area of land draining to the dam site is called a
catchment or watershed.

Outlet
DBU

Chapter two: Sources of Water Supply

Reservoirs
The following investigations are required for reservoir
planning:
A. Topographic surveying- to produce a topo-map which will
be used as a base for
preparing

water surface area vs. elevation curve


plotting storage volume vs. elevation
indicating man-made and natural features that may be
affected

DBU

Chapter two: Sources of Water Supply

Reservoirs

B. Geologic investigations
Water

tightness of the reservoir basin


Suitability of foundations for the dam
Geological and structural features, such as faults, fissures, etc
Type and depth of overburden
Location of permeable and soluble rocks if any
Ground water conditions in the region
Location and quantity of materials for the dam construction

DBU

Chapter two: Sources of Water Supply

Reservoirs

C. Hydrological investigations
determination

of rainfall, runoff, seepage, and


evaporation in the reservoir catchment from long
years of data.

These information are essential for estimating the reservoir


capacity and design of spill way.

DBU

Chapter two: Sources of Water Supply

Criteria for Selecting reservoir sites

DBU

Catchment geology- minimum percolation losses and high runoff


potential
Dam site- strong foundation with minimum seepage loss under the
dam.
Narrow valley- sites that resulting lesser dam length
Topography- should be such that large area and valuable
properties are not submerged
Site that creates deep reservoirs- this has the advantages of
minimizing the evaporation loss and submerged area when
compared to shallow reservoirs
Sites that ensure good water quality- avoid sites that are
downstream of waste discharges and tributaries with high silt loads

Chapter two: Sources of Water Supply

Volume of reservoirs

DBU

Yield is the amount of water that can be supplied from a


reservoir within a specified interval of time.
Safe yield or firm yield: is the maximum quantity of
water that can be guarantied during a critical dry
period.
the safe yield from a reservoir > maximum day demand
Methods to determine the storage volume of reservoirs:
mass curve method(Rippl) Method.
analytical method.
Chapter two: Sources of Water Supply

Mass curve method

reservoir capacity is determined from accumulated mass inflow and


accumulated demand curves.
Net Inflow= total Inflow-outflow (evaporation, seepage, d/s flow)

Procedure

DBU

Prepare accumulated mass inflow curve from the stream hydrograph


Prepare the accumulated demand curve on the same scale
Draw tangent lines that are parallel to the accumulated demand curve
at the high points of the accumulated mass curve (P1, P2, P3, etc)
Measure the vertical distances between the tangent lines and the mass
inflow curve (V1, V2, V3, etc.)
Determine the required reservoir storage capacity as the largest of the
vertical distances (V1, V2, V3, etc.)

Chapter two: Sources of Water Supply

Mass curve method


Accumulated inflow

V2

Volume
(m3)

Spill
Accumulated demand
V1

Time, Year (month)


DBU

Chapter two: Sources of Water Supply

Analytic method

Calculate the net inflow from the given hydrological data


Calculate the deficiency (demand net inflow)
Compute the cumulative deficiency. If the cumulative
deficiency is negative, take the cumulative deficiency as zero
Determine the required reservoir capacity as the maximum
cumulative deficiency
(1)

Net inflow
(m3)
I1
I2
I3
DBU

(2)

Demand (m3)
D1
D2
D3

(3)= (2)-(1)

Deficiency
(m3)
F1
F2
F3

(4) if CF is ve, take 0

Cumulative deficiency
(m3)
CF1 = F1
CF2 = CF1 + F2
CF3 = CF2 + F3

Chapter two: Sources of Water Supply

Example 2.1
Compute the storage requirement
needed for an impounding reservoir for
a constant draft of 23 ML/km2/months
of 30.4 days with the given monthly net
river inflow for a critical year.

DBU

Month
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15

Inflow
(ML/km2)
94
122
45
5
5
2
0
2
16
7
72
92
21
55
33

Chapter two: Sources of Water Supply

Analytical Solution
Month
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15

DBU

inflow
94
122
45
5
5
2
0
2
16
7
72
92
21
55
33

draft/
demand
23
23
23
23
23
23
23
23
23
23
23
23
23
23
23

Cummulative
Demand
23
46
69
92
115
138
161
184
207
230
253
276
299
322
345

Cummulative inflow
94
216
261
266
271
273
273
275
291
298
370
462
483
538
571

Defficiency
-71
-99
-22
18
18
21
23
21
7
16
-49
-69
2
-32
-10

cummulative
Deficiency
0
0
0
18
36
57
80
101
108
124
75
6
8
0
0

Chapter two: Sources of Water Supply

Graphical Solution
Res. Draw down period

600

Depletion of Res.

400

Reservoir full

419-294=124

300

Cummulative Q

Res. full

500

Replenishment
of Res.

200

End of
Dry period

Start of
Dry period

Cummulative Demand

100

Cummulative inflow
0

10

12

14

16

Month

DBU

Chapter two: Sources of Water Supply

Exercise

DBU

Chapter two: Sources of Water Supply

Safe yield from a given reservoir capacity

DBU

Prepare the mass inflow curve.


From the apices A1, A2, A3 etc. of the mass curve, draw
tangents in such a way that their maximum departure from
the mass curve does not exceed the specified reservoir
capacity. The ordinates E1D1, E2D2, E3D3, etc. are all equal
to the reservoir capacity (say 1500 ha.m)
Measure the slopes of each of these tangents. The slopes
indicate the yield which can be attained in each year from
the reservoir of given capacity. The slope of the flattest
demand line is the firm yield.
Chapter two: Sources of Water Supply

Safe yield from a given reservoir capacity

DBU

Chapter two: Sources of Water Supply

Cross section of Dam

DBU

Chapter two: Sources of Water Supply

Types of Dams

DBU

Chapter two: Sources of Water Supply

Impoundments: Embankment dams


Embankment dam-A dam constructed from natural materials

excavated or obtained nearby. The natural fill materials are placed


and compacted without the addition of any binding agent. Two typesEarth fill dam (if compacted soil constitutes over 50% of the dam
volume) and
Rock fill dam (over 50% of the material is coarse-grained material or
crushed rock with impervious membrane).

Advantages:

DBU

For sites in wide valleys and steep-sided gorges


Adaptability to a broad range of foundation conditions
Use of locally available natural materials

Chapter two: Sources of Water Supply

Impoundments: Concrete Dam


Disadvantages:

Easily damaged or destructed by overflow


leakage and internal erosion

They are gravity dam, arch dam, buttress dam, etc.


Gravity dam

DBU

Dependent upon its own mass for stability.

For gorges with very steep side slopes

It can be constructed by Masonry(stone or brick)

Shape: straight or curved

Dam height: can be very high for sound foundation


Chapter two: Sources of Water Supply

Impoundments: Concrete Dams...


Arch dam
Functions structurally as a horizontal arch, transmitting the
major portion of the water load to the abutments or
valley sides rather than to the floor of the valley.
structurally more efficient, needs less concrete volume
Buttress dam
consists of a continuous upstream face supported at
regular intervals by downstream buttresses.

DBU

Chapter two: Sources of Water Supply

Catchment protection
Activities that take place within the reservoir catchment have impacts on the quality and quantity
of water stored behind the dam. Catchment protection primarily focuses on maintaining the
water quality and capacity of the reservoir. It involves activities that include

DBU

Minimization of diffuse pollution from urban runoff


Minimization of agricultural diffuse pollution
Controlling discharges from point sources such as
wastewater treatment plant, industries, etc
Limitation of soil erosion through soil conservation
measures, such as afforestation, etc.
Providing corridors along tributary streams, rivers, and the
reservoir
Chapter two: Sources of Water Supply

Ground water
hydraulics
DBU

Chapter two: Sources of Water Supply

Occurrence of Groundwater

DBU

Groundwater takes 0.62% of the total water in the


hydrosphere but 99 % of the fresh water
Of 0.31% of the total water in the hydrosphere has depth less
than 800m.
sand, gravel, and sandstones good aquifers
Limestone and shale that have caverns, fissures or faults can
also be considered as good aquifers.
Clays ability to transmit water is very poor due to the very
small particle sizes (< 0.0004 mm).
Chapter two: Sources of Water Supply

Groundwater

Groundwater is the water beneath the ground surface contained in void spaces (pore spaces between
rock and soil particles, or bedrock fractures).

Basic Terms

Aquifer

An aquifer is an underground layer of water-bearing permeable rock or unconsolidated


materials(gravel, sand, silt, or clay) from which groundwater can be usefully extracted using a water
well.

Water table

The water table is the level at which the groundwater pressure is equal to atmospheric pressure.

Aquitard

An aquitard is a zone within the earth that restricts the flow of groundwater from one aquifer to another.
Aquitards comprise layers of either clay or non-porous rock with low hydraulic conductivity.

DBU

Chapter two: Sources of Water Supply

Unconfined aquifer

It is an aquifer with the water table as its upper boundary. Because the aquifer is not under pressure the
water level in a well is the same as the water table outside the well.

Confined aquifer

It is an aquifer found between two relatively impermeable layers.

Artesian aquifer/well

It is a confined aquifer containing groundwater that will flow upward through a well, called an artesian
well, without the need for pumping. Water may even reach the ground surface if the natural pressure is

high enough, in which case the well is called a flowing artesian well.

Water well

A water well is an excavation or structure created in the ground by digging, driving, boring or drilling
to access groundwater in underground aquifers.

DBU

Chapter two: Sources of Water Supply

Borehole

It is a narrow shaft drilled in the ground as part of a groundwater site assessment.

Piezometric surface

The imaginary surface that everywhere coincides with the piezometric head of the water in the aquifer.In
areas of artesian ground water, it is above the land surface.

Base flow

Base flow is the portion of stream flow that comes from groundwater. It sustains flows in a river
during the dry periods between rainstorms.

Groundwater Recharge

The natural or intentional infiltration (percolation) of surface water into the groundwater system.

Fossil water

Fossil water is groundwater that has remained in an aquifer for thousands or even millions of years.
When geologic changes seal the aquifer off from further recharging, the water becomes trapped inside.
DBU

Chapter two: Sources of Water Supply

Subsurface Distribution of Water


Vertical zones of groundwater distribution

Ground surface
Soil water zone
Unsaturated
zone

-Large fluctuation in water


Content due to plant transpiration

Vadose zone
Capillary zone

Saturated
Zone(It is the water that is

Zone of saturation

GWT
All voids are filled with water
Under hydrostatic pressure

found in the saturation zone


that can be tapped for

different purposes )

Aquifer is a water-bearing formation that is saturated and that


transmits large quantities of water.
DBU

Chapter two: Sources of Water Supply

Aquifer parameters
(The water yield capacity of aquifers depends on different parameters)

DBU

Chapter two: Sources of Water Supply

Aquifer parameters

Storage coefficient (S): the volume of water that an aquifer


releases from or takes into storage per unit surface area of the
aquifer per unit change in head

Hydraulic gradient (dh/dx): the slope of the piezometric surface


or water table line in m/m. The magnitude of the head
determines the pressure on the groundwater to move and its
velocity.

DBU

Chapter two: Sources of Water Supply

Examples

DBU

Chapter two: Sources of Water Supply

Aquifer parameters

Hydraulic conductivity(K): ratio of velocity to hydraulic


gradient, indicating permeability of porous media.
K=

QdL
Adh

Transmissivity: the capacity of an aquifer to transmit water


measure

of how easily water in a confined aquifer can flow through


the porous media.

T = Kb,
DBU

b = saturated thickness
Chapter two: Sources of Water Supply

Aquifer Types
Unconfined and confined aquifers(

An unconfined aquifer does not have confining unit and is defined by water-

table. Confined aquifer is overlain by a confining unit that has a lower hydraulic conductivity.)

DBU

Chapter two: Sources of Water Supply

Groundwater flow
Groundwater flows in the direction of decreasing head.
equipotential lines lines showing points having equal
pressure.
Flow direction is perpendicular to equipotential lines

145 m

150 m

155 m

140 m
135 m
130 m

DBU

Aquifer boundary
Equipotential line
Flow direction
Chapter two: Sources of Water Supply

Velocity of GW

Velocity can be determined by Darcys law V = kS

Darcy law :Q through porous media is proportional to the head loss and inversely
proportional to the length of the flow path.
L

Q
h
V
K
A
L
or

Porous medium

dh
V K dL
; for very small element

Area = A

K = hydraulic conductivity and h is the head loss


DBU

Chapter two: Sources of Water Supply

Determination of K

DBU

Chapter two: Sources of Water Supply

Determination of K
Laboratory methods

Constant head permeameter:

VL
K
Ath

V = volume water flowing in time t through of area A, length L, and with


constant head h.

Variable head permeameter :

r 2 L h1
K 2 ln
rc t h2

r = radius of the column in which the water level drops


rc = radius of the sample
h1, h2 are heads at times t1 and t2, respectively
t = t2 t 1
DBU

Chapter two: Sources of Water Supply

Problems

DBU

Chapter two: Sources of Water Supply

Determination of K...
Field Methods

Pumping test: constant removal of water from a single well


and observations of water level declines at several adjacent
wells.

This is the most accurate way

For anisotropic aquifers, the combined horizontal hydraulic


conductivity:
K Z
K

Where, Ki = K in layer i; Zi = thickness of layer I


DBU

Chapter two: Sources of Water Supply

Example

DBU

Chapter two: Sources of Water Supply

Determination of K...
Field Methods

Slug test or piezometer test: the simplest method

some volume of water is taken out from the piezometer and the
subsequent rise of the water back to its original position is recorded
in time.
ri-inside

radius,
L- the length of the screen section,
ro-the outside radius
to- characteristic time interval
DBU

Chapter two: Sources of Water Supply

Hydraulics of water wells


Well: hydraulic structure utilized to access water-bearing aquifers
Allows estimation of aquifer hydraulic properties
Provides direct access to ground water conditions
1)
2)
3)
4)

DBU

Sampling
Testing
Resource Extraction
Environmental Restoration

Chapter two: Sources of Water Supply

Hydraulics of water wells

Aquifer test: studies involving analyzing the change, with

time, in water levels in an aquifer caused by withdrawals


through wells.
Drawdown/cone of depression: is the difference between the
water level at any time during the test and the original
Ground
position.
Original GWT

Cone of depression

Drawdown
Well

Impervious
stratum
DBU

Chapter two: Sources of Water Supply

Radius of influence of steady state pumping


wells

DBU

Chapter two: Sources of Water Supply

Piezometric head

DBU

Chapter two: Sources of Water Supply

Steady state Radial flow to a well


assumptions:

DBU

Cone of depression remains in equilibrium


The water table is only slightly inclined
Flow direction is horizontal
Slopes of the water table and the hydraulic gradient are equal
Aquifer: isotropic, homogeneous and infinite extent
Well fully penetrating the aquifer

Chapter two: Sources of Water Supply

Steady Radial Flow to a Well-Confined


In a confined aquifer, the drawdown curve or cone of depression varies with distance from a
pumping well

For horizontal flow, Q at any radius r equals, from Darcys law,


dh
dh
Q 2 rbK
2rT
dr
dr

DBU

Chapter two: Sources of Water Supply

Steady Radial Flow to a Well-Confined

Integrating after separation of variables, with h = hw at r = rw


at the well, yields Thiem Equation.
Q 2 T

h hw
r
ln
rw

Near the well, transmissivity, T, may be estimated by observing


heads h1 and h2 at two adjacent observation wells located at r1
and r2, respectively, from the pumping well.
r2
ln
r1
T Q
2 (h2 h1 )

DBU

Chapter two: Sources of Water Supply

Steady Radial Flow to a Well-Unconfined

radial flow in an unconfined, homogeneous, isotropic, and


dH
horizontal aquifer yields:
Q 2 rHK
dr

DBU

Chapter two: Sources of Water Supply

Steady Radial Flow to a Well-Unconfined

Integrating, the flow rate in a unconfined aquifer from 2 to 1


(h2 h1 )
Q K
r
ln 2
r1
2

Solving for K,

Q
r2
K
ln
2
2
(h2 h1 ) r1

DBU

Chapter two: Sources of Water Supply

Example
A 0.5 m well fully penetrates an unconfined aquifer of 30 m
depth. Two observation well located 30 and 70 m from the
pumped well have drawdowns of 7 m and 6.4 m, respectively. If
the flow is steady and K = 74 m/d.
what

would be the discharge


Estimate the drawdown at the well

DBU

Chapter two: Sources of Water Supply

Solution

For unconfined well Q is given as


(h h1 )
Q K 2
r2
ln
r1
2

h1= 30-7 = 23 m, and h2 = 30 6.4 = 23.6 m


r1 = 30 m and r2 = 70 m
(23.6 2 232 )
Q 74
7671.54 m3 / day
70
ln
30
DBU

Chapter two: Sources of Water Supply

Solution

Drawdown at the well,


using

the h1=23 m and rw=0.5m/2=.25 m, we have hw

(h1 hw )
(232 hw )
Q K
74
7671.54 m3 / day
r1
30
ln
ln
rw
0.25
2

Solving for hw, we have hw = 19.26 m


So the drawdown would be 30.0 19.26 = 10.74 m

DBU

Chapter two: Sources of Water Supply

Example

Design a tube well for the following data


required = 0.1 m3/sec
Thickness of confined aquifer = 25 m
Radius of confined aquifer = 250 m
Permeability coefficient = 70 m/day
Drawdown at the well = 6 m
Yield

DBU

Chapter two: Sources of Water Supply

Solution
h hw
Q 2 bK
r
ln
rw

For confined aquifer Q is given by

Taking between the well and at the radius of influence(R) we


have
h

- hw = 6 m
b = 25 m
R = 250 m

70 m / day 6m

Q 0.1m / sec 2 25m


86400sec/ day ln 250
rw
3

Solving for rw, we get rw = 0.12 m or 12 cm


Thus, diameter of the well is 24 cm or 25 cm
DBU

Chapter two: Sources of Water Supply

Exercise

DBU

A well 60cm in diameter in a confined aquifer was pumped at a


steady rate of 0.0311 m3/s.When the well level remained
constant at 85.48 m, the observation well level at a distance of
10.4 m was 86.52 m. Calculate the transmissivity.

Chapter two: Sources of Water Supply

Solution

DBU

Chapter two: Sources of Water Supply

Interference of wells

DBU

The combined drawdown at a point is equal to the sum of the


drawdowns caused by individual wells.
Reduced yield for each of the wells.

Chapter two: Sources of Water Supply

AAiT, Zerihun Alemayehu

Resultant drawdown

Pumping and recharging wells


T

DBU

Chapter two: Sources of Water Supply

Well construction

Well construction depends


on
the

flow rate,
depth to groundwater,
geologic condition,
casing material, and
economic factors

DBU

Shallow and deep well


construction
Chapter two: Sources of Water Supply

Shallow well construction

Shallow wells are less than 30 m deep


constructed by
digging,
boring,
driving,

or
jetting methods.

DBU

Chapter two: Sources of Water Supply

Shallow well construction

Dug wells: excavated by hand and


are vertical wells.
diameter

> 0.5 m and depth < 15 m.


Lining and casing :concrete or brick.

DBU

Chapter two: Sources of Water Supply

Shallow well construction

Driven wells: a series of pipe lengths driven vertically


downward by repeated impacts into the ground.
diameters

25 75 mm
Length below 15 m.

DBU

Chapter two: Sources of Water Supply

Shallow well construction

Bored wells: constructed with


hand-operated or power-driven
augers.
Diameters

of 25 to 900 mm
depths up to 30 m

DBU

Chapter two: Sources of Water Supply

Shallow well construction

Jetted wells: a high-velocity stream


of water directed vertically
downward, while the casing that is
lowered into the hole conducts the
water and cuttings to the surface.
Small-diameter

holes, up to 10
depths up to 15 m
useful for observation wells and wellpoint systems for dewatering
purposes.
DBU

Chapter two: Sources of Water Supply

Deep well construction

Deep wells constructed by percussion (cable tool) drilling or

rotary drilling methods.

Percussion drilling: regular lifting and dropping of a string of


tools, with a sharp bit on the lower end to break rock by
impact.
for

DBU

consolidated rock materials to depths of 600 m.

Chapter two: Sources of Water Supply

Percussion drilling
Pulley

Tripod

Rope

Casing pipe

DBU

Chapter two: Sources of Water Supply

DBU

Chapter two: Sources of Water Supply

Deep well construction

Rotary method: consists of drilling with a hollow, rotating


bit, with drilling mud or water used to increase efficiency. No
casing is required with drilling mud because the mud forms a
clay lining on the wall of the well. Drilling mud consists of a
suspension of water, bentonite clay, and various organic
additives.
A

rapid method for drilling in unconsolidated formations


Air rotary methods use compressed air in place of drilling mud and
are convenient for consolidated formations.
Drilling depths can exceed 150 m
DBU

Chapter two: Sources of Water Supply

Hydraulic rotary drilling

Drilling mud

Tripod

Mud to settling tank

DBU

Chapter two: Sources of Water Supply

DBU

Chapter two: Sources of Water Supply

By:Abraham
END of
Atnafu 2:
chapter
DBU

Chapter two: Sources of Water Supply

Вам также может понравиться