Вы находитесь на странице: 1из 1

Segment Identification

Additional Guidance Overview


1.03 Release Locations and Inspection of Implementation and
Spill Volume Results of Segment Identification
Analysis
Water Crossings
Review
1.02 Direct Intersection Topography 1.04 Overland Spread Ÿ NPMS
Method and Exceptions of Liquid Pool Ÿ HCAs Definitions from Other Sources
1.01 HCA Identification Distance to HCA Ÿ Release Volume Calculations
Ÿ Transport Analysis Calculations
Fixed Spacing Ÿ Justification for Assumptions
Define Intersection Valid Assumptions
Endpoints (Including Buffer Zones)
Facilities Ÿ Spreadsheets or Other Listing of
NPMS
Topography Segment Endpoints
Facilities Failure Size
Ÿ Operator Maps/GIS
Operating Conditions Spill Response
Computer Analysis
Methodology Actions
Local Detection &
Knowledge Response Time
Manual Analysis Local Factors
Methodolgy Drain Down (Ditches, Farm
Tiles, etc.)
Release Rate
Rigorous and Valid (Imp. for HVL) All
Periodic Technical Justification Valid Computer
Updates of Exceptions Design Factors Modeling Techniques Segments
that
Could
Stream Conditions, Flow Applicability (HVL, Applicable Analysis Factors Category 1 Pipe (12/31/01)
Characteristics, Change in Special Cases for per 1.04 through 1.08
Affect
Properties of Commodity in Water Certain non-HVLs) HCAs
Segments Identified by Category 2 Pipe (11/18/02)
Specific Factors to Selection of Specific Endpoints
Consider such as MTBE, Analysis Model and Category 3 Pipe (Before Ops)
Buoyancy, Solubility, Off- Software Tool Buffer Zone Identifies All
gassing (H2S), etc. Locations Within Buffer
Modeling of Physical Distance 1.08 Completion by
Indirect Introduction Into Properties Deadline
Water via Overland Technical Justification for
Spread or Spray Valid Inputs and Exceptions if HCA is
Assumptions Closer than Buffer Zone
Distance Segment Identification
Valid Assumptions Process Inspection
Threshold LOC
Facilities Review
Spill Response Actions
Secondary Effects Ÿ IM Program Documentation
1.07 Identification of Segments Ÿ Policy Documents
1.05 Stream/Water that Could Indirectly Affect an HCA Ÿ Implementing Procedures
Ÿ Software Documentation
Transport Analsysis 1.06 Air Dispersion Analysis

Вам также может понравиться