Академический Документы
Профессиональный Документы
Культура Документы
Experiment
DC-AC Inverter: Single-phase Square Wave Inverter
Part 1: To get acquainted with the simulation environment for Single-phase Square
wave inverter
Graphically model and simulate the single-phase square wave inverter (dc-ac converter) using
ORCAD 10.5 and PSpice. Study the dc source (input) current and ac load (output) voltage and
current waveforms. Compare the same with the results obtained from the analytical expressions.
Objective:
Part 1:
Graphically model the square wave inverter shown in Fig. 1 using the graphical front end of
ORCAD. The nominal values for the inverter are as follows:
Vs = 120 V L= 20 mH R = 5 ohms F= 50 Hz
Figure 1
Part 2:
1. Observe and plot the load voltage and current waveforms from time 0 to 0.1sec
(Output voltage across R & L), (Current through L).
Part 3:
Part 4:
Tools required:
Procedure
Experiment
DC-AC Inverter: Three-phase Square Wave Inverter
Part 1: To get acquainted with the simulation environment for three-phase Square
wave inverter
Graphically model and simulate the three-phase square wave inverter (dc-ac converter) using
ORCAD 10.5 and PSpice. Study the dc source (input) current and ac load (output) voltage and
current waveforms. Compare the same with the results obtained from the analytical expressions.
Objective:
Part 1:
Graphically model the square wave inverter shown in Figure using the graphical front end of
ORCAD. The nominal values for the inverter are as follows:
Vs = 400 V L= 10 mH R = 2 ohms F= 50 Hz
Part 2:
1. Observe and plot the phase voltage and current waveforms from time 20ms to
100ms (Output voltage across R & L), (Current through L).
2. Observe and plot the line to line voltage waveforms from time 20ms to 100ms
3. Observe and plot supply current and voltage for the same duration.
4. Observe and plot the FFT of the input and output voltage and current
waveforms from fundamental frequency to 1000 Hz.
Part 3:
Part 4:
Tools required:
Procedure
• Phase A voltage