Академический Документы
Профессиональный Документы
Культура Документы
Remedial actions:
1.1 Clean or replace stamper
2.1 Check processing
conditions and correct if
Alternative terms: necessary (increase holding
Rad noise pressure, cooling and holding
pressure time, mould/melt
Description: temperature and injection
Physical dimension for the deviation of the reading laser speeds)
from the centre of the track; determined from the electrical 2.2 Increase melt temperature
track following signal (upper limit 30 nm)
2.3 Increase injection speed
2.4 Reduce screw speed,
increase back pressure
CLICK TO CONTINUE CLICK TO PREVIOUS Injection Moulding Guide
Disclaimer: All contents written and images in this collection designed by the author.
Some are from different sources on the Internet and are believed to be in the public domain.
They may be used for non-commercial purposes only.
I am always interested in feedback on my site or details of yourself or your interests.
However I cannot always reply to you personally as there is often just not enough time in the
day.
My E-mail Address
http://www.tanhowsay.com/Program/inject33.html 2010/12/7
Injection Moulding Guide 第 2 頁,共 2 頁
Web www.tanhowsay.com
http://www.tanhowsay.com/Program/inject33.html 2010/12/7