Академический Документы
Профессиональный Документы
Культура Документы
MODEL: FA-3000AWE
DIGITAL HOME
CINEMA SYSTEM
SERVICE MANUAL
POWER
VOLUME INPUT SEL
ON/STANDBYY
MODEL: FA-3000AWE
CONTENTS
SPECIFICATIONS ............................................................................................................................................ 3
TROUBLESHOOTING ...................................................................................................................................... 4
SPEAKER ......................................................................................................................................................... 20
-1-
ESD PRECAUTIONS
Electrostatically Sensitive Devices (ESD)
Some semiconductor (solid state) devices can be damaged easily by static electricity. Such components
commonly are called Electrostatically Sensitive Devices (ESD). Examples of typical ESD devices are integrated
circuits and some field-effect transistors and semiconductor chip components. The following techniques should
be used to help reduce the incidence of component damage caused by static electricity.
1. Immediately before handling any semiconductor component or semiconductor-equipped assembly, drain off
any electrostatic charge on your body by touching a known earth ground. Alternatively, obtain and wear a
commercially available discharging wrist strap device, which should be removed for potential shock reasons
prior to applying power to the unit under test.
2. After removing an electrical assembly equipped with ESD devices, place the assembly on a conductive
surface such as aluminum foil, to prevent electrostatic charge buildup or exposure of the assembly.
3. Use only a grounded-tip soldering iron to solder or unsolder ESD devices.
4. Use only an anti-static solder removal device. Some solder removal devices not classified as "anti-static" can
generate electrical charges sufficient to damage ESD devices.
5. Do not use freon-propelled chemicals. These can generate electrical charges sufficient to damage ESD
devices.
6. Do not remove a replacement ESD device from its protective package until immediately before you are ready
to install it. (Most replacement ESD devices are packaged with leads electrically shorted together by
conductive foam, aluminum foil or comparable conductive materials).
7. Immediately before removing the protective material from the leads of a replacement ESD device, touch the
protective material to the chassis or circuit assembly into which the device will by installed.
CAUTION : BE SURE NO POWER IS APPLIED TO THE CHASSIS OR CIRCUIT, AND OBSERVE ALL OTHER
SAFETY PRECAUTIONS.
8. Minimize bodily motions when handing unpackaged replacement ESD devices. (Otherwise harmless motion
such as the brushing together of your clothes fabric or the lifting of your foot from a carpeted floor can
generate static electricity sufficient to damage an ESD device).
-2-
SPECIFICATIONS
Power supply AC230V, 50/60Hz
Power consumption 150W
Mass 12.4kg
External dimensions (W X H X D) 23.5 X 430 X 483mm
Operating conditions Temperature : 5˚C to 35˚C, Operation status: Horizontal
Frequency response (audio) 150Hz to 20kHz
Signal-to-noise ratio (audio) More than 80dB (1kHz, NOP, JIS FILTER)
Harmonic distortion (audio) 0.5% (1kHz, at 12W position) (30 kHz LPF/A Filter)
Surround Mode Front: 30W + 30W (THD 10%)
Center: 30W
Surround*: 30W + 30W (8Ω at 1kHz, THD 10%)
Subwoofer*: 50W (4Ω at 30 Hz, THD 10%)
Inputs AUX, COAXAL., OPTICAL AUDIO
Satellite Speaker (FE-3000TE) Active Subwoofer (FE-3000AWE)
Type 1 Way 1 Speaker 1 Way 1 Speaker
Impedance 8Ω 4Ω
Frequency Response 110~20,000 Hz 40~2,500Hz
Sound Pressure Level 83dB/W(1m) 82dB/W(1m)
Rated Input Power 30W 50W
Max. Input Power 60W 100W
Net Dimensions (W X H X D) 90 X 125 X 107mm 235 X 430 X 483mm
Net Weight 0.7kg 12.4kg
-3-
TROUBLE SHOOTING
INSERT
POWER CORD
YES
YES
YES
YES
OK
-4-
AUDIO µ-COM Circuit
-5-
IC VOLTAGE SHEET
Power & Micom
1.FA-P3000 (Power & Micom)
-6-
2. FA-P3000 (AMP)
IC320 (STK402-930) IC151 (TDA7294)
PIN NO. Volt(V) PIN NO. Volt(V) PIN NO. Volt(V)
1 -0.12V 16 -0.13V 1 -1.8mv
2 -0.13V 17 -0.13V 2 -0.4mv
3 -0.12V 18 -24.4V 3 -1.5mv
4 -0.12V 19 -0.13V 4 -1.8mv
5 -15.4mv 20 -0.13V 5 -0.3V
6 -13.3mv 21 -0.12V 6 15.55V
7 28.6V 22 -0.13V 7 29.1V
8 -28.7V 23 -11.4mv 8 -29V
9 -28.7V 24 -25.8V 9 4.9V
10 28.7V 10 4.9V
11 12.6mv 11 2.2mv
12 -9.2mv 12 6.8mv
13 25.8V 13 29.2V
14 -2.3mv 14 -0.7mv
15 -25.5V 15 -29.3V
3. FA-P3000 (DSP)
IC201 (CS4228A) IC202 (CS8415)
PIN NO. Volt(V) PIN NO. Volt(V) PIN NO. Volt(V) PIN NO. Volt(V)
1 0.58V 16 2.11V 1 0.12V 16 1.63V
2 34.8mv 17 2.11V 2 88.8mv 17 1.64V
3 0.94V 18 3.56V 3 8mv 18 25.7mv
4 1.23V 19 2.17V 4 7.6mv 19 2.9V
5 1.61V 20 2.17V 5 7.6mv 20 25.3mv
6 1.64V 21 4.92V 6 4.93V 21 1.7V
7 5.5mv 22 4.6mv 7 7.6mv 22 24.6mv
8 3.27V 23 2.28V 8 7.6mv 23 3.28V
9 3.28V 24 2.29V 9 3.27V 24 24.6mv
10 1.51V 25 2.28V 10 1.50V 25 24.6mv
11 13.8mv 26 2.29V 11 26.4mv 26 24.6mv
12 0.12V 27 2.28V 12 0.25V 27 0.11V
13 3.27V 28 2.29V 13 24.5mv 28 13.7mv
14 3.26V 14 24.5mv
15 3.28V 15 24.5mv
-7-
IC201 (CS493264)
PIN NO. Volt(V) PIN NO. Volt(V) PIN NO. Volt(V)
1 2.48V 16 2.58V 31 7.9mv
2 25.2mv 17 2.58V 32 2.07V
3 0.94V 18 2.58V 33 1.3V
4 2.47V 19 0.12V 34 2.59V
5 25.1mv 20 3.29V 35 7.9mv
6 2.58V 21 2.58V 36 3.27V
7 4.2mv 22 9.2mv 37 21.3mv
8 2.58V 23 2.58V 38 2.58V
9 2.58V 24 8.1mv
10 2.58V 25 1.62V
11 2.58V 26 1.65V
12 2.58V 27 1.24V
13 8.0mv 28 1.62V
14 2.58V 29 1.66V
15 2.58V 30 1.7V
IC101 (KIA4558F) IC151 (A4558F) IC301 (KIA4558F) IC401 (KIA4558F) 8)IC501 (KIA4558F)
PIN NO. Volt(V) PIN NO. Volt(V) PIN NO. Volt(V) PIN NO. Volt(V) PIN NO. Volt(V)
1 5.7mv 1 5.7mv 1 14.5mv 1 11.4mv 1 11.2mv
2 6.2mv 2 6.0mv 2 10.1mv 2 8.6mv 2 8.4mv
3 5.4mv 3 5.4mv 3 9.6mv 3 8.5mv 3 8.4mv
4 -5.23V 4 -5.23V 4 -6.07V 4 -6.07V 4 -6.07V
5 5.5mv 5 5.4mv 5 9.6mv 5 8.6mv 5 8.7mv
6 5.9mv 6 5.3mv 6 10.4mv 6 9.2mv 6 9.2mv
7 5.4mv 7 4.2mv 7 15.1mv 7 12.8mv 7 12.7mv
8 5.09V 8 5.08V 8 5.92V 8 5.92V 8 5.92V
4.FA-P3000 (Fornt)
IC800 (UPD16311)
PIN NO. Volt(V) PIN NO. Volt(V) PIN NO. Volt(V) PIN NO. Volt(V)
1 1.72V 16 -25.8V 31 -24V 46 5.0V
2 1.70V 17 -19.5V 32 -23.9V 47 5.0V
3 1.70V 18 -25.8V 33 5.0V 48 5.0V
4 1.70V 19 -23.7V 34 -26.2V 49 5.0V
5 1.70V 20 -25.8V 35 -23.9V 50 5.0V
6 4.58V 21 -12.6V 36 -23.9V 51 1.0mv
7 4.95V 22 -15.2V 37 -23.9V 52 2.72V
8 4.88V 23 -19.4V 38 -23.9V
9 4.58V 24 -21.5V 39 -23.9V
10 1.77V 25 -13.1V 40 -23.9V
11 1.77V 26 -17.3V 41 -23.9V
12 1.76V 27 -26V 42 -23.9V
13 1.72V 28 -23.9V 43 -23.9V
14 4.95V 29 -26V 44 -24.1V
15 -25.5V 30 -17.4V 45 5.0v
-8-
BLOCK DIAGRAM
9
SCHEMATIC DIAGRAMS
• POWER & MICOM SCHEMATIC DIAGRAM
NOTE: Warning NOTE:
Parts that are shaded are critical With respect 1. Shaded(■) parts are critical for safety.Replace only
to risk of fire or electrical shock. with specified part number.
2. Voltages are DC-measured with a digital voltmefer
during Play mode.
10
• DSP SCHEMATIC DIAGRAM
11
• FRONT SCHEMATIC DIAGRAM
12
• AMP SCHEMATIC DIAGRAM
13
WIRING DIAGRAM
14
PRINTED CIRCUIT DIAGRAMS
• MAIN, POWER, FRONT, MICOM P.C. BOARD(SOLDER SIDE)
15
• MAIN, POWER, FRONT, MICOM P.C. BOARD(COMPONENT SIDE)
16
• DSP P.C. BOARD(COMPONENT SIDE)
17
• DSP P.C. BOARD(SOLDER SIDE)
18
EXPLODED VIEWS
• Active Subwoofer
MODEL : FE-3000AWE NOTE) Refer to “REPLACEMENT PARTS LIST”
in order to look for the part number of
each part.
852
851
861
A46
860
865
A43
853
863
854
864
870
A48
858
856
868
A47
855
862
857
866
19
Satellite Speaker
MODEL: FE-3000TE
880
888
881
882
889
887
883
884
885
886
- 20 -
MEMO
- 21 -