nS
Con ‘eee
The Disc Ward 7 z
Oy THE DISC WIZARD INSTRUCTION MANUAL L
The Disc Wizard
Congratulations on purchasing the new Dise Wizard Series 3. This
revolutionary machine is the latest in CD and DVD repair technology.
Ithas been designed to effectively repair all formats of discs by removing
scratches that affect the reading of a CD or DVD. It comes with a full
12-month warranty and is proudly Australian made.5 THE DISC WIZARD INSTRUCTION MANUAL
The Dise Wizard Series 3 is now fitted with a user-friendly microprocessor
controller. To help further understand these features and functions, please
read the following carefully.
SAFETY FEATURES
If the lid is opened during a cycle the motor de-activates, if this occurs a
single beep will be emitted and a ‘LO’ will be displayed on the key pad.
If the start button is pushed without selecting a cycle time, a single beep
will be emitted and ‘OO" will flash twice on the key pad.
If the controller registers a power supply problem or an obstruction in the
repair compartment, the machine will switch into reset mode. A single
beep will then be heard and ‘OL’ will be displayed on the screen. To reset
the Disc Wizard, open and shut the lid, Once ‘OO” is displayed the cycle
time can then be reselected.> THE DISC WIZARD INSTRUCTION MANUAL
GETTING STARTED
Place the Disc Wizard in a position that does not interfere with the air
vents on either the lid or sides of machine.
THE POWER SUPPLY VOLTAGE WARNING
Before connecting the Disc Wizard to a power source, be sure that the
voltage supplied is the same as the rating on the machine (10AMP 230 -
240 Volts). If you are unsure of the voltage rating of your power source,
please contact your nearest licensed electrician.
Please Note:
Using a power source less or more than the recommended rating will
affect the terms and conditions of the warranty.
Plug your Dise Wizard into a power point that is not overloaded with other
electrical appliances.The Oe Wit
Gas THE DISC WIZARD INSTRUCTION MANUAL Ri
emer
Ideally, the Dise Wizard should have a power point all of its own. This
ensures that sufficient power is constantly supplied to the machine.
Overloading the power point may interrupt the power supply causing the
‘machine to malfunction.
If the Dise Wizard overloads, the screen will display OL. To reset the
machine, lift and close the lid and then reselect the time. Possible reasons
{for this to occur can be due to the over application of the polishing
‘compound. This can cause the motor to stall. (For further details see the
Step-by-Step Guide to Polishing Discs)
The connection of the Dust Extraction Unit, Power supply and Vacuum
plug is shown below.
a
The Dust extraction unit will automatically activate only on the 30 second
sanding cycle. It commences 2 seconds after the cycle has started and
automatically turns off when the cycle is complete.
4The Dg Wnt
pas THE DISC WIZARD INSTRUCTION MANUAL Rk
Mastering IoT For Industrial Environments: Unlock the IoT Landscape for Industrial Environments with Industry 4.0, Covering Architecture, Protocols like MQTT, and Advancements with ESP-IDF