Вы находитесь на странице: 1из 2

M500 SHOTGUN WEAPON SAFETY (NKO)-1

1. Match the following Universal Weapons Safety Rules to rationale. Rule 1 - Treat every weapon as if it were loaded Rule 2 - Never point a weapon at anything you do not intend to shoot Rule 3 - Keep your finger straight and off the trigger until ready to fire Rule 4 - Keep weapon on safe until you intend to fire What is the maximum effective range (in yards) of the M500 shotgun? 00 Buck: 50, Slug: 100 What is the maximum range (in yards) of the M500 shotgun? 00 Buck : 660, Slug: 1180 Match the General Weapons Condition Code to appropriate Action. Condition 1 - Magazine tube filled, round in chamber, action closed, weapon on safe Condition 2 - N/A Condition 3 - Magazine tube filled, chamber empty, action closed, weapon on safe Condition 4 - Magazine tube empty, chamber empty, action closed, weapon on safe A cartridge can remain chambered in the M500 shotgun after removal of all cartridges from the magazine tube. True Correctly identify the 4 Major component assemblies of the M500 shotgun. Receiver group/Trigger group/Stock group/Barrel group What is the maximum number of cartridges held by the M500 magazine tube? 5 What is the indication that the last ammunition round has been fired? A new round is not in the elevator Which General Weapon Condition Code DOES NOT apply to the M500 Shotgun? Condition 2

2.

3.

4.

5.

6.

7.

8.

9.

10. Select, from the list below, the six M500 shotgun 'Alert Carry' steps that apply. Firing hand around the small of the stock Non-firing hand on the fore-end Trigger finger straight along the receiver Stock of the shotgun against the firing shoulder Muzzle angled down at near 45 degree angle Muzzle pointed in the direction of the threat 11. Select, from the list below, the six M500 shotgun 'Ready Carry' steps that apply. Shotgun sights just below eye level Firing hand around the small of the stock Non-firing hand on the fore-end Trigger finger straight along the receiver Stock of the shotgun against the firing shoulder Muzzle pointed in the direction of the threat

M500 SHOTGUN WEAPON SAFETY (NKO)-2


12. The shotgun 'Tactical Carry' is used: When there is no immediate threat. 13. Which procedure causes a cartridge to be chambered? Make ready 14. A 'Combat Load,' inserting one round, may be necessary to immediately engage the enemy. True 15. What is the first step performed by the person receiving the weapon in a 'Show Clear' transfer? Ensure the shotgun is on safe 16. What is the first step in the 'Show Clear' transfer for the M500 shotgun? Ensure shotgun is in Condition 4 with fore-end to the rear 17. The M500 will fire each time the fore-end is cycled after pulling and holding the trigger a single time. False 18. If audible pop / reduced recoil is experienced during firing in a training environment you must cease firing immediately. True 19. What condition must be met prior to any shotgun function check? Ensure no live ammunition is in the area 20. What is the correct order of the following UNLOAD, SHOW CLEAR Clearing Barrel procedures? First - Ensure the shotgun is on safe Second - Remove the rounds from the magazine tube Third - Pull the fore-end to the rear Fourth - Visually inspect the magazine and chamber to ensure they are empty Fifth - Allow for a secondary inspection of the magazine tube and chamber Sixth - Push the fore-end forward and observe the bolt going forward on an empty chamber

Вам также может понравиться