Академический Документы
Профессиональный Документы
Культура Документы
by P.ANAND E.ARUN JEFFERSON J.K.DEVA RAMKUMAR S.KUMARAVADIVEL to the FACULTY OF MECHANICAL ENGINEERING in partial fulfilment of the requirements for the award of the degree of BACHELOR OF ENGINEERING in MECHANICAL ENGINEERING (20061208) (20061214) (20061228) (20061250)
COLLEGE OF ENGINEERING GUINDY CAMPUS ANNA UNIVERSITY CHENNAI, CHENNAI-600 025 NOVEMBER 2009
Certified that this project report titled DESIGN AND FABRICATION OF AUTOMATED SYSTEM FOR PLACING DIVIDER CONES is a bona fide work of
Who carried out the work under my guidance, for the partial fulfilment of the requirements for the award of the degree of Bachelor of Mechanical Engineering Certified further that to the best of my knowledge and belief, the work reported herein does not form part of any other project report or dissertation on the basis of which a degree or an award was conferred on an earlier occasion on these or any other candidates.
Dr.S.SAMPATHKUMAR Professor and Head Department of Mechanical Engg. College of Engg. Guindy campus Anna University Chennai Chennai- 600 025
Dr.M.PRADEEP KUMAR Assistant Professor and Guide Department of Mechanical Engg. College of Engg. Guindy campus Anna University Chennai Chennai-600 025