Академический Документы
Профессиональный Документы
Культура Документы
,LTD
www.wacas.com
2Click browse, and find the file of USB_data cable_driver in the disk. Click Confirm and begin to install. After finishing setting, at Port of Device Manager in Attributes System of control panel, USB-to-Serial Comm Port(COM4), as shown in figure 1.
Figure 1 3. Then set up communication port of application software at USB-to-Serial Comm Port, port number is COM4, as shown in figure 1. After finishing setup, software can communicate with mobile phone by USB data cable.
4. When communication port is set in some applicable software, the port number will be found default. That means, software communication port cant be changed, it is fixed by only one port. But when you open My ComputerAttributesHardwareDevice Manager, you will find
USB-to-Serial Comm Port is inconsistent with this fixed port, which will result in software communication operation unavailable. So the port setting must be changed to be consistent with the fixed port before communication. Setting method is as follows:
www.wacas.com
(1)
Enter
into
My
ComputerAttributesHardwareDevice
Manager
Figure 2 (2) Change COM port number to be consistent with default in softwarethen click Confirm, shown as figure 3. So communication with software can proceed.
www.wacas.com
Figure 4
(3) After finishing setting, at Port of Device Manager in Attributes System of
control panel, USB-to-Serial Comm Port(COM4), as shown in figure 4, the same as figure 1.
www.wacas.com