Вы находитесь на странице: 1из 13
toe BESK Systens-Tutorial sheet no.fY Fl Deseribe the required conditions to satisfy the equivalence between the predetection band-pass filter, BPF_ and postaetection low-pass filner Ufa, (ilustrated ia figure below. relatively wideband s(e) A fan | BPE Ler ck i= Ler {=e} co Ce jee s(e) ~S | ae *? LPFR ce) 2. “Sketch the unfiitered pover spectrum of a 8PSK signal if the unsodulated carrier frequency f, = 70 Miz and the bit rate is fy = 6 Mb/s. Assume that (a) the data source 12 periodic 1010... data strean (>) the data source Lean equiprobabie random source. Also, sketch the corresponding transait power spectra of the Nyquist filtered systen sssuning that the transait fileer has.a Nyquist channel response for rectangular pulse transaission with © + <5 roll-off factor. . I Perive an expression for the bit error rate of a BPSK with. correlation receiver in the presence of AWGN. If this systed eaploys a coventional coherent detection with Nyquist shaped filters instead, calculate the systea bit error assuming that the bit energy-to-noise psd of 12 d3 is available. 7 85) Cat, In @ conventional coherent BPSK receiver the incoming signal is multi- plied by a generated carrier and then low-pass filtered to produce the baseband bit stream. If the carrier recovery circuit phase error is c, find an expression for the error probability. If the phase error is constant 45°, find P, if CNR =-10d8. How dogs this compare with the ideal Po? 2? A communication system using a satellite with regenerative transponder uses binary PSK modulation scheme for both the uplink and downlink. Both the uplink end downlink use conventional coherent dexodulation. | 1) Calculate ‘the overall bit error rate of the system at the earth station given the following information: ~ a) the. signal power recetved by the satellite 1s 14 PW and the noise pover * Jat the input of the receiver is 1.1 Pu. D) the earth station receiver receives 1.4 PW of the signal power and the noise power at the input to the receiver is 0.14 pw. 2) What would the overall bit error rate be if the above system employs & Selvttens To Pot of — ° / ee Pt ot catty Bose sya fens : cis peat Se fee Ne Velen Spy YALA Ro OF Tee sppedert loc. BPE ad tllesheeted 1 Fyre belpo ee te alles ye Fal SO “Sey j = AG. PostoePerin LPF, Ca be eo sR emt 7] een AG. — aly $8 Pel eacnu ti Me ALG. ctf a f.= [st x hl] e(¢ ( 4g = 0 4.@)* o@ = SP Hh) BGA) + Gk M Pee) sin OF Y FUT AG 1) 4 by ead] a0 = [se aeJeuy os AW = [8@ x co) UY Ae = (8 G4) + SPA UY. : Ae AR ea ae) ee oO Bits ge Mba , oF, 2 6'Male: CO Em perinckic, dete Sorts (0106. wr os ° ead foe ny FP (Rb) het ih 1% fu Hn te x4 er 5 > \m mt tenn * Benes hy n mt ots p- Fe Ck AAG Me hes Cees os

Вам также может понравиться