Вы находитесь на странице: 1из 101

RAN12 IPRAN Deployment Guide

Keywords: IPRAN, SCTP, IPPATH, VLAN, DSCP Abstract: This document describes the preparations and precautions for the IPRAN deployment, IPRAN networking examples of each interface, data planning, configuration examples, and basic principle and configuration of remote OM channels. It provides operation guides to the IPRAN deployment on site. The information in this document is for the internal use only and cannot be used as the basis for the reply to a customer or Market Dept. Acronyms and Abbreviations Table 1-1 Explanations of acronyms and abbreviations Acronym and Abbreviation SCTP DSCP VLAN DSCP PPP MP Expansion Simple Control Transmission Protocol Differentiated Services Code Point Virtual LAN Differentiated Services Code Point Point-to-Point Protocol Multilink PPP

1
1.1 Introduction

Overview

From V210, the Iub, Iur and IU interfaces can serve the IP transport. Then, operators can implement the transmission capacity expansion by using the existing IP network, thus, saving the network construction expanses. In addition, the IP network provides multiple

access modes as well as sufficient transmission bandwidth for the high-speed data services, including the HSDPA and HSPA+. For the description of the IPRAN feature of V210 and earlier versions, refer to the RAN10 Feature Description and RAN10 V2 IPRAN Deployment Guide. For the description of the IPRAN feature of V211 and V212, refer to the corresponding RAN Feature Description.

1.2 Others
For basic principles and protocols (including TCP, UDP, PPP, ARP, VLAN, TRACERT, SCTP, and M3UA) adopted by the IPRAN feature, refer to the V18 IPRAN Deployment Guide and V210 IPRAN Deployment Guide.

1.3 Availability
1.3.1 Involved NEs
The IP feature requires the cooperation of the NodeB, RNC, and CN. Table 1-1 lists the data configuration requirements of the IP feature on these NEs. indicates that the NE is required. Table 1-1 Hardware support Requirements of the IP Feature Data configuration requirements Hardware requirements NodeB RNC

WMPT/UTRP

PEUa/POUa/UOIa_IP/FG2a/GOUa/POUc/FG2c/GOUc

1.3.2 Version Support


Table 1-2 Supported versions Product RNC NodeB BSC6810 DBS3900 DBS3800/ BTS3812E CME M2000 Supported Versions BSC6900V900R012 V200R012 V100R012 V200R009/V200R10

1.3.3 Other Support


For support capabilities of the boards of the RNC and the NodeB, refer to the related product manuals.

2
2.1 V2 Backup Policy
2.1.1 Backup Mode on the RNC
I. Board Backup

Common Networking

RNC backup consists of board backup and port backup. For detailed description, refer to Parts Reliability of the Product Description. The following brief description is for your reference.

When two boards work in backup mode, one board is active and the other is standby. Services can be processed by either the active board only or both the active and standby boards. If the active board is faulty, the RNC automatically switches over the active and standby boards. During the addition of a board through the ADD BRD command, the backup of the boards is configurable. If Backup is set to YES, the backup mode of boards is board backup.

II. Board Backup+Port Backup


The port backup can be configured on the basis of board backup. In backup mode, one port is active and the other is standby. Services can be transmitted through the active port only. If the active port is faulty, the RNC automatically switches over the active and standby ports.
Backup

of FG2a/GOUa/FG2c/GOUc boards+port backup

If boards work in backup mode, you can run the ADD ETHREDPORT command to configure the backup of FE/GE ports.
Backup

of UOIa_IP/POUa/POUc boards+port backup

When the boards work in backup mode, the corresponding optical ports on the active and standby boards, such as optical ports 0 on the boards, can be configured for MSP 1:1 or MSP 1+1 backup (unidirectional or bidirectional). The SET MSP command is available for setting the attributes for MSP backup. The MSP attributes refer to Revertive type, WTR Time (required only when Revertive type is set to REVERTIVE), K2 Mode, SDSF Priority, and Backup mode. The settings of these parameters must be consistent with those at the peer end through negotiation.

III. Board Backup+Load Sharing Between Ports (No Port Backup)


In this mode, FG2a/GOUa/FG2c/GOUc boards work in backup mode, whereas ports do not work in backup mode. That is, ports on both active and standby boards can be used at the same time.

2.1.2 Backup Mode on the NodeB


I. Board Backup Mode Instead of Port Backup Mode on the NodeB
When boards work in backup mode, the configuration can be performed only on the active board which processes the data, whereas the standby board is monitored. When all used physical links on the active boards are unavailable (for example, the LOS alarm is generated on the E1 cable or the FE interface is down) and there are available physical links on the standby boards, the active/standby switchover is performed. During the switchover, both the active board and standby board are restarted and the configuration on the active board is loaded to the standby board. Then, the standby board becomes active. The switchover may cause service interruptions. You can configure the board backup mode only on the CME rather than MML commands. However, you can run the LST IUBGRP command to query the working mode of boards.

II. Board Backup Constraints on the NodeB


The

following boards support board backup. WMPT/UTRP

V212: V112: Boards If

Either the NUTI or the HBBU supports board backup, whereas the NDTI does not support board backup.

work in cold backup mode on the NodeB. Therefore, the board switchover may cause service interruptions. the boards are set to work in active/standby mode, ensure that transmission cables on the active and standby boards are properly connected, for example, connect cables on the FE ports and connect E1 cables on active and standby boards.

When

boards work in active/standby mode, transmission objects except the objects in the physical layer can only be configured in the logic slot. The smaller slot number in slot backup mode is the logic slot number.

2.2 Common Networking Modes


For detailed networking description, refer to Transport and Networking of the Product Description.

2.2.1 Layer 2 Networking Mode


The RNC connects to the NodeB (Iub interface), SGSN (IU interface), and RNC (Iur interface) through the local area network (LAN). The interface addresses of all NEs are on the same network segment. Layer 2 networking modes are classified into the following types in terms of the transmission media.

I. IP over E1/T1 over PDH/SDH Networking (Iub interface)Connection to the RNC


Through E1/T1 Cables Figure 2-1 IPRAN layer 2 networking based on PDH/SDH transmissionconnection to the RNC through E1/T1 cables

Figure 2-2 IPRAN layer 2 networking based on SDH transmissionchannelized STM-1 access to the RNC

Both

the RNC and NodeB connect to the transport network through E1/T1 cables. Alternatively, the RNC connects to the transport network through the channelized STM-1 on the POUa/POUc and the NodeB connects to the transport network through

the E1/T1 cables. The data is transmitted in IP over MLPPP/PPP over E1/T1 mode.
The

NodeB can obtain the line clock through E1/T1 cables. mode

Backup

PEUas can be set to work in active/standby mode by using the ADD BRD command. The active and standby PEUas are connected to the peer end through Y-shaped E1/T1 cables. The POUa and POUc can be set to work in active/standby mode by using the ADD BRD command. Optical ports on the boards can be set to work in MSP 1:1 or MSP 1+1 mode.
The

RNC and NodeB can enable the IP header compression algorithm to improve the transmission efficiency.

II. IP Layer 2 Network Based on MSTP (Iub Interface)


Figure 2-3 IPRAN layer 2 networking based on MSTP

The

RNC connects to the MSTP network through the FE/GE electrical port or GE optical port on the FG2a/GOUa/FG2c/GOUc interface board. The NodeB connects to the transport network through the FE electrical port or optical port. The data is transmitted in IP over Ethernet mode. NodeB can extract the clock from the MSTP network through additional E1/T1 cables or obtain the clock source from the GPS/IP clock server. mode: Backup of interface boards on the RNC+port backup or board backup+load sharing between ports efficiency: Multiple NodeBs share the VC trunk bandwidth to make full use of transport network resources. To implement the QoS scheduling of various services, the RNC and NodeB support IEEE 802.1p/q and the mapping between the DSCP and VLAN priority, whereas the transport network supports IEEE 802.1p/q.

The

Backup

Transmission QoS:

III. IP Layer 2 Networking (Iub/Iur/IUCS/IUPS) Based on the Data Network


The RNC connects to the NodeB (Iub interface), SGSN (IU interface), and RNC (Iur interface) through the layer 2 data network, including the PTN networking or layer 2 LAN switch networking. Interface addresses of interconnected NEs are on the same network segment.

Figure 2-4 IPRAN layer 2 networking based on the data network

The

RNC connects to the layer 2 data network through the FE/GE electrical port or GE optical port on the FG2a/GOUa/FG2c/GOUc interface board. The NodeB/NRNC/MGW/SGSN connects to the layer 2 data network through the FE electrical port or optical port. The data is transmitted in IP over Ethernet mode. NodeB can extract the clock from the transmission device in the ATM network through additional E1/T1 cables or obtain the clock source from the GPS/IP clock server. mode: Backup of interface boards on the RNC+port backup or board backup+load sharing between ports To implement the QoS scheduling of the data network, the RNC, NodeB, core network (CN) device, and layer 2 supports IEEE 802.1p/q, that is, support the VLAN and VLAN priority. Generally, the data network needs to meet the following conditions:
The

The

Backup QoS:

delay is controlled within 40 ms (unidirectional); the jitter is smaller than 15 packet loss rate is within 0.05%.

ms.
The The

values vary from site to site and they are subject to the bid clarification document of the marketing department.

2.2.2 Layer 3 Networking Modes


I. Direct Connection Between the RNC and A Router
This networking mode is seldom used. The RNC connects to the NodeB (Iub interface), SGSN (IU interface), and RNC (Iur interface) through the layer 3 switching network. Interface addresses of all NEs are on the same network segment. Figure 2-5 Direct connection between the RNC and a router


The

RNC connects to the data network through the FE/GE electrical port or GE optical port on the FG2a/GOUa/FG2c/GOUc interface board. The NodeB/NRNC/MGW/SGSN connects to the data network through the FE electrical port or FE/GE optical port. The data is transmitted in IP over Ethernet mode. NodeB can extract the clock through additional E1/T1 cables or obtain the clock source from the GPS/IP clock server. mode: Backup of interface boards on the RNC+port backup The active and standby ports connect to two ports on the router/layer 3 switch. Two ports on the router/layer 3 switch are configured in an identical VLAN. In addition, the two ports are configured with one VLAN interface address, which serves as the network gateway of the RNC.

The

Backup

QoS:

To implement the QoS scheduling of various services, the RNC, NodeB, and CN device support IEEE 802.1p/q and the mapping between the DSCP and VLAN priority, whereas the data network supports the MPLS TE, MPLS Diffserv, IP Diffserv, and VLAN COS. Generally, the data network needs to meet the following conditions:
The

delay is controlled within 40 ms (unidirectional); the jitter is smaller than 15 packet loss rate is within 0.05%.

ms.
The The

values vary from site to site and they are subject to the bidding document of the marketing department.

II. Direct Connection Between the RNC and Two Routers


Figure 2-6 Direct connection between the RNC and two routers


The

RNC connects to the data network through the FE/GE electrical port or GE optical port on the FG2a/GOUa/FG2c/GOUc interface board. The NodeB/NRNC/MGW/SGSN connects to the data network through the FE electrical port or optical port. The data is transmitted in IP over Ethernet mode. NodeB can extract the clock through additional E1/T1 cables or obtain the clock source from the GPS/IP clock server. mode: Backup of interface boards on the RNC+port backup The active and standby ports on the RNC connect to two ports of the active and standby PEs. The RNC connects to the data transmission network through the PE. The active and standby ports on the RNC share one IP address (IP1-1). Two ports of the active and standby PEs are configured in the same VLAN. In addition, VRRP is configured and the virtual VRRP IP address (IP-0) serves as the network gateway of the RNC.

The

Backup

QoS:

To implement the QoS scheduling of various services, the RNC, NodeB, and CN device support IEEE 802.1p/q and the mapping between the DSCP and VLAN priority, whereas the data network supports the MPLS TE, MPLS Diffserv, IP Diffserv, and VLAN COS. Generally, the data network needs to meet the following conditions: The delay is controlled within 40 ms (unidirectional); the jitter is smaller than 15 ms; the packet loss rate is within 0.05%. The values vary from site to site and they are subject to the bid clarification document of the marketing department.

2.2.3 Load Sharing Networking


The load sharing networking mode can be used during the interconnection between the IUCS and IUPS. Figure 2-7 Layer 3 load sharing networking


The

RNC connects to the data network through the FE/GE electrical port or GE optical port on the FG2a/GOUa/FG2c/GOUc interface board. The NodeB/NRNC/MGW/SGSN connects to the data network through the FE electrical port or optical port. The data is transmitted in IP over Ethernet mode. NodeB can extract the clock through additional E1/T1 cables or obtain the clock source from the GPS/IP clock server. mode: board backup+load sharing between ports Thanks to the double reliability guarantee of the boards and transmission, you can obtain doubled transmission bandwidth. Two ports working in load sharing mode on the active and standby boards connect to two routers/layer 3 switches. Two ports on the active and standby boards on the RNC are configured with two IP addresses (IP1, IP2) and connect to two network gateways (GW1, GW2) on the interconnected routers/layer 3 switches. The traffic on the RNC can use the IP addresses of interfaces or be configured with the logic IP address (DEVIP).

The

Backup

QoS:

To implement the QoS scheduling of various services, the RNC, NodeB, and CN device support IEEE 802.1p/q and the mapping between the DSCP and VLAN priority, whereas the data network supports the MPLS TE, MPLS Diffserv, IP Diffserv, and VLAN COS. Generally, the data network needs to meet the following conditions:
The The The

delay is controlled within 40 ms (unidirectional). jitter is smaller than 15 ms; the packet loss rate is within 0.05%.

values vary from site to site and they are subject to the bid clarification document of the marketing department.

2.2.4 Hybrid Transport Networking


Figure 2-8 IPRAN networking based hybrid transportIub interface


On

the Iub interface, services of different QoS requirements are transmitted on transport networks with two different QoS requirements. High-QoS services are transmitted through dedicated lines, whereas services of lower QoS requirements are transmitted through low-cost transport networks, for example, Ethernet.
Services

on the control plane, real-time services, and OM services are transmitted on high-QoS transport network, for example, the TDM transport network. services are transmitted on the low-QoS data network.

Non-real-time Low-QoS

path: The RNC connects to the data network through the FE/GE electrical port or GE optical port on the FG2a/GOUa/FG2c/GOUc interface board. The NodeB/NRNC/MGW/SGSN connects to the data network through the FE electrical port or optical port. The data is transmitted in IP over Ethernet mode. path: Both the RNC and NodeB connect to the TDM transport network through E1/T1 cables. The data is transmitted in IP over MLPPP/PPP over E1/T1 mode. NodeB can obtain the line clock through E1/T1 cables. mode

High-QoS

The

Backup

Backup Backup

of FG2a/GOUa/FG2c/GOUc boards+port backup or board backup+load sharing between ports of PEUa/POUa/UOIa_IP/POUc boards

2.2.5 ATM/IP Dual Stack-Based Networking


Figure 2-9 IPRAN networking based on dual stack transportIub interface


If

the original ATM networking provides insufficient bandwidth (especially when the HSDPA/HSUAP is used), you can expand the IP transport network to save transmission expanses and obtain high bandwidth. original ATM networking remains unchanged. Both the RNC and NodeB connect to the TDM transport network through E1/T1 cables. the RNC and NodeB connect to the data transmission network through the new IP interface board: The RNC connects to the data network through the FE/GE electrical port or GE optical port on the FG2a/GOUa/FG2c/GOUc interface board, whereas the NodeB/NRNC/MGW/SGSN connects to the data network through the FE electrical port or optical port. The data is transmitted in IP over Ethernet mode. NodeB can obtain the line clock through E1/T1 cables. mode: For details, see layer 2 data networking and layer 3 data networking.

The

Both

The

Backup QoS:

Services on the control plane, real-time services, and OM services are transmitted on the ATM network, whereas the non-real-time services are transmitted on the IP network.

Major Configurations of RAN12 IPRAN

3.1 Description
Configuration For

examples are based on RNC V900R012 and NodeB V200R12.

configuration details, refer to the Initial Configuration Guide and the corresponding MML online help. networking of configuration examples is only for reference. The networking of each site needs to be designed and deployed according to the actual situations. the deployment on site, the data on the NodeB is configured on the CME. For clear configuration description, here only describes the configuration related to MML commands.

The

During

3.2 Setting Attributes of An Ethernet Port


I. RNC
Command: SET ETHPORT Note: Refer to the online help on the LMT, especially the precautions during the attribute setting.
Set

the VLAN tag attribute of an Ethernet port.

This attribute cannot be set. The default value is HYBRID.


Set Set Set

the working mode of the FE/GE port. Ensure that the working modes (auto negotiation or non-auto negotiation) of the two ends are consistent. the maximum transmission unit (MTU). Ensure that the MTU on the RNC is smaller or equal to that of the intermediate transmission device. the ratio of the minimum bandwidth of the OAM flow to the port bandwidth. The default ratio is 0%. The ratio can be adjusted according to the planning of the existing network if the OMCH between M2000 and NodeB pass by RNC.

SET ETHPORT: SRN=0, SN=14, BRDTYPE=FG2a, PTYPE=FE, PN=0, AUTO=ENABLE, MTU=1500, OAMFLOWBW=0, FLOWCTRLSWITCH=ON, FCINDEX=0;

II. NodeB
Command: SET ETHPORT

Set

the VLAN tag attribute of an Ethernet port.

This attribute cannot be set. The default value is HYBRID.


Set Set Set

the working mode of the FE/GE port. Ensure that the working modes (auto negotiation or non-auto negotiation) of the two ends are consistent. the maximum transmission unit (MTU). Ensure that the MTU on the NodeB is smaller or equal to that of the intermediate transmission device. the ARP proxy switch. If the OM IP address and the corresponding interface IP address are on the same network segment, you need to enable the ARP proxy switch.

SET ETHPORT: SRN=0, SN=6, SBT=BASE_BOARD, PN=0, MTU=1500, ARPPROXY=ENABLE;

3.3 VLAN ID Configuration


3.3.1 General Principle of the VLAN Configuration
If

VLAN IDs are carried by the packets from the RNC and NodeB, you need to perform the relevant VLAN configuration on the RNC and NodeB. If the VLAN IDs are not carried by the packets from the RNC and NodeB but can be carried by packets on the intermediate device (for example, the switch), you need not perform the relevant VLAN configuration on the RNC and NodeB. VLAN IDs used by each site need to be planned by the operator and configured on the intermediate transmission device. VLAN ID can be added according to the IP address of the next hop (IP address of the network gateway) on the RNC.

The A

3.3.2 Adding the VLAN ID According to the IP Address of the Next Hop
I. RNC
Command: ADD VLANID 1. Packets destined to the network gateway with this IP address carry the same VLAN ID. 2. IP packets sent from the network gateway with this IP address carry the specified VLAN ID. 3. The ARP request packets to the network gateway with this IP address carry the specified VLAN ID. For example, run the following command to set the IP address of the network gateway to GW1 and set the VLAN ID to 100 for all packets destined to this network gateway. ADD VLANID: IPADDR="GW1", VLANID=100

II. NodeB
Command: ADD VLANMAP This command is only valid for V2. Method 1:

All packets from the NodeB to the network gateway carry the same VLAN ID and have the same VLAN priority. When running the ADD VLANMAP command, select SINGLEVLAN for the VLAN mode. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, VLANPRIO=1; // Set the IP address of the network gateway of the NodeB to GW2. Set the VLAN ID to 100 for all packets destined to the network gateway. Method 2 (recommended)
ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=VLANGROUP, VLANGROUPNO=0;

You can set the VLANID of data flows by MML command SET VLANCLASS and refer to the
following information to get detailed.

3.3.3 Setting the VLAN ID for the Data on the SCTP Link
I. RNC
The VLAN ID is added according to the IP address of the next hop and does not need to be independently configured. In particular, disable the VLAN tag when running the ADD SCTPLNK command.

II. NodeB
1.For V1, run the following command: SET VLANCLASS: TRAFFIC=SIG, INSTAG=ENABLE, VLANID=100, VLANPRIO=6; 2. For V2, add the VLAN ID according to the IP address of the next hop. Additional configurations are unnecessary. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, VLANPRIO=6; // Set the IP address of the network gateway of the NodeB to GW2. Set the VLAN ID to 100 for all packets destined to the network gateway. 3.For V2, if VLANGROUP is selected, run the following command: ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=VLANGROUP, VLANGROUPNO=0; SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=SIG, INSTAG=ENABLE, VLANID=100, VLANPRIO=6; // Set the VLAN ID to 100 for the signaling link data. Note: If different VLAN priorities need to be assigned to different types of services delivered to the network gateway, set the VLAN mode to VLANGROUP. If SINGLEVLAN is selected, all packets destined to the network gateway carry the same VLAN ID and have the same VLAN priority.

3.3.4 Setting the VLAN ID for the Data on the IP Path


I. RNC
The VLAN ID is added according to the IP address of the next hop and does not need to be independently configured. In particular, set VLANID Flag to DISABLE when running the ADD IPPATH command.

II. NodeB
Run the ADD IPPATH command to set the DSCP value for each IP path.

ADD IPPATH: PATHID=1, JNRSCGRP=DISABLE, DSCP=46; // Set the DSCP value of a specific IP path to 46. ADD IPPATH: PATHID=2, JNRSCGRP=DISABLE, DSCP=38; // Set the DSCP value of a specific IP path to 38. ADD IPPATH: PATHID=3, JNRSCGRP=DISABLE, DSCP=22; // Set the DSCP value of a specific IP path to 22. ADD IPPATH: PATHID=4, JNRSCGRP=DISABLE, DSCP=14; // Set the DSCP value of a specific IP path to 14. When running the SET VLANCLASS command, set Traffic Type to USERDATA, which indicates that the UDP protocol is supported, including the voice service, PS, HSPA service, and data on common channels. 1.For V1, run the following command: SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=48, INSTAG=ENABLE, VLANID=100, VLANPRIO=6; // For the data on the IP path whose DSCP value is 46, the VLAN ID is set to 100. Note: Common signaling messages are transmitted on the common channels of the cell through UDP. These packets have higher priorities. The data from the NodeB to the RNC uses the DSCP value specified by Signal Priority in the SET DIFPRI command. Therefore, set Traffic Type to USERDATA and add the corresponding VLAN ID to the data whose DSCP is specified by Signal Priority. SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=46, INSTAG=ENABLE, VLANID=100, VLANPRIO=5; // Set the VLAN ID to 100 for the data on the IP path whose DSCP is 46. SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=38, INSTAG=ENABLE, VLANID=100, VLANPRIO=4; // Set the VLAN ID to 100 for the data on the IP path whose DSCP is 38. SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=22, INSTAG=ENABLE, VLANID=100, VLANPRIO=2; // Set the VLAN ID to 100 for the data on the IP path whose DSCP is 22. SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=14, INSTAG=ENABLE, VLANID=100, VLANPRIO=1; // Set the VLAN ID to 100 for the data on the IP path whose DSCP is 14. 2.For V2, Method 1 Add the VLAN ID according to the IP address of the next hop. Additional configurations are unnecessary. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, VLANPRIO=5; // Set the IP address of the network gateway of the NodeB to GW2. Set the VLAN ID to 100 for all packets destined to the network gateway. 3.For V2 Method 2 (Recommended) ifVLANGROUP is selected, run the following command: ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=VLANGROUP, VLANGROUPNO=0; SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=USERDATA, SRVPRIO=48, INSTAG=ENABLE, VLANID=100, VLANPRIO=6; // Set the VLAN ID to 100 for the

data whose DSCP value is 48. Note: Common signaling messages are transmitted on the common channels of the cell through UDP. These packets have higher priorities. The data from the NodeB to the RNC uses the DSCP value specified by Signal Priority in the SET DIFPRI command. Therefore, set Traffic Type to USERDATA and add the corresponding VLAN ID to the data whose DSCP is specified by Signal Priority. SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=USERDATA, SRVPRIO=46, INSTAG=ENABLE, VLANID=100, VLANPRIO=5; // Set the VLAN ID to 100 for the data on the IP path whose DSCP value is 46. SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=USERDATA, SRVPRIO=38, INSTAG=ENABLE, VLANID=100, VLANPRIO=4; // Set the VLAN ID to 100 for the data on the IP path whose DSCP value is 38. SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=USERDATA, SRVPRIO=22, INSTAG=ENABLE, VLANID=100, VLANPRIO=2; // Set the VLAN ID to 100 for the data on the IP path whose DSCP value is 22. SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=USERDATA, SRVPRIO=14, INSTAG=ENABLE, VLANID=100, VLANPRIO=1; // Set the VLAN ID to 100 for the data on the IP path whose DSCP value is 14.

3.3.5 Setting the VLAN ID of the OAM Flow on the Iub Interface
I. RNC
The VLAN ID is added according to the IP address of the next hop and does not need to be configured independently.

II. NodeB
1.For V1, run the following command: SET VLANCLASS: TRAFFIC=OM, INSTAG=ENABLE, VLANID=100, VLANPRIO=5; 2.For V2 Method 1: Add the VLAN ID according to the IP address of the next hop. Additional configurations are unnecessary. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, VLANPRIO=5; // Set the IP address of the network gateway of the NodeB to GW2. Set the VLAN ID to 100 for all packets destined to the network gateway. 3.For V2 Method 2 IfVLANGROUP is selected, run the following command: ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=VLANGROUP, VLANGROUPNO=0; SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=OM, INSTAG=ENABLE, VLANID=100, VLANPRIO=5; // Set the VLAN ID to 100 for the OAM data, including the TCP maintenance data flow and SNTP data flow.

3.3.6 Setting the VLAN ID of the PTP Clock Packet


I. RNC

Not involved.

II. NodeB
1.For V1, run the following command: SET VLANCLASS: TRAFFIC=OTHER, INSTAG=ENABLE, VLANID=100, VLANPRIO=5; 2.For V2 Method 1 Add the VLAN ID according to the IP address of the next hop. Additional configurations are unnecessary. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, 3.For V2 Mehod 2 If VLANGROUP is selected in the ADD VLANMAP command, run the following command: SET VLANCLASS: TRAFFIC=OTHER, INSTAG=ENABLE, VLANID=100; // Set the VLAN ID to 100 for the PTP data flow.

3.3.7 Setting the VLAN ID of the BFD Packet


I. RNC
The VLAN ID is added according to the IP address of the next hop and does not need to be configured independently.

II. NodeB
1.For V2 Method 1 Add the VLAN ID according to the IP address of the next hop. Additional configurations are unnecessary. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, 2.For V2 Method 2 If VLANGROUP is selected in the ADD VLANMAP command, run the following command: Run the ADD BFDSESSION command to set the DSCP value. The default DSCP is 48. ADD BFDSESSION: BFDSN=0, DSCP=34; // Set the DSCP value of a specific BFD session to 48. SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=34, INSTAG=ENABLE, VLANID=100; // Set the VLAN ID to 100 for the BFD session. Set Traffic Type to USERDATA and set User Data Service Priority to the DSCP value of the ADD BFDSESSION command.

3.3.8 Setting the VLAN ID for the ARP/DHCP/ICMP/Tracert Packet


I. RNC
Set the VLAN ID for the packets destined to the network gateway. For example, the IP address of the network gateway of the RNC is GW1. Run the following command to set the VLAN ID to 100 for all packets, including ARP/DHCP/ICMP/Tracert packets. ADD VLANID: IPADDR="GW1", VLANID=100;

II. NodeB
SET VLANCLASS: TRAFFIC=OTHER, INSTAG=ENABLE, VLANID=100; // Traffic Type is set to OTHER, indicating that ARP/DHCP/ICMP/Tracert is supported. Note: During the initial deployment phase of a new site, DHCP packets from the NodeB carry the VLAN ID learnt by the VLAN.

3.4 DSCP Value Configuration


Note: The DSCP values recommended in the Transmission Configuration Specifications are used in the following example. The DSCP value used by each site needs to be planned by the operator and configured on the intermediate transmission device.

3.4.1 Setting the DSCP Value of the SCTP Link


I. RNC
ADD SCTPLNK: SCTPLNKN=2, DSCP=48; // Set the DSCP value of an SCTP link to 48.

II. NodeB
Command: SET DIFPRI SET DIFPRI: PRIRULE=DSCP, SIGPRI=48; // Set the DSCP value of a signaling link to 48.

3.4.2 Setting the DSCP Value of the IP Path


I. RNC
Command: ADD IPPATH, SET PHBMAP 1.Run the ADD IPPATH command to set IP path type of an IP path to a PHB. ADD IPPATH: ANI=1, PATHID=1, ITFT=IUB, TRANST=IP, PATHT=EF; // Set IP path type of a specific IP path to EF. ADD IPPATH: ANI=1, PATHID=2, ITFT=IUB, TRANST=IP, PATHT=AF43; // Set IP path type of a specific IP path to AF43. ADD IPPATH: ANI=1, PATHID=3, ITFT=IUB, TRANST=IP, PATHT=AF23; // Set IP path type of a specific IP path to AF23. ADD IPPATH: ANI=1, PATHID=4, ITFT=IUB, TRANST=IP, PATHT=AF13; // Set IP path type of a specific IP path to AF13. 2.Run the SET PHBMAP command to set the DSCP value corresponding to the PHB. You can run the LST PHBMAP command to query the default configuration. SET PHBMAP: PHB=EF, DSCP=46; // When the PHB is EF, the DSCP value is 46.

SET PHBMAP: PHB= AF43, DSCP=38; // When the PHB is AF43, the DSCP value is 38. SET PHBMAP: PHB= AF23, DSCP=22; // When the PHB is AF23, the DSCP value is 22. SET PHBMAP: PHB= AF13, DSCP=14; // When the PHB is AF13, the DSCP value is 14.

II. NodeB
ADD IPPATH: PATHID=1, JNRSCGRP=DISABLE, DSCP=46; // Set the DSCP value of an IP path to 46. ADD IPPATH: PATHID=2, JNRSCGRP=DISABLE, DSCP=38; // Set the DSCP value of a specific IP path to 38. ADD IPPATH: PATHID=3, JNRSCGRP=DISABLE, DSCP=22; // Set the DSCP value of a specific IP path to 22. ADD IPPATH: PATHID=4, JNRSCGRP=DISABLE, DSCP=14; // Set the DSCP value of a specific IP path to 14.

3.4.3 Setting the DSCP Value of the OAM Flow on the Iub Interface
I. RNC
SET QUEUEMAP: OAMMINBWKEY=ON, OAMFLOWDSCP=34; // Set the minimum bandwidth switch of the OAM flow to ON and set the DSCP value of the OAM flow to 34.

By

default, the minimum bandwidth switch is disabled. data of the OAM flow enters a dedicated queue for transmission rather than queues 0 to 5.

The If

the minimum bandwidth of the OAM flow is set to ON, the DSCP value of the OAM flow must be different from the DSCP value of any IP path.

II. NodeB
SET DIFPRI: PRIRULE=DSCP, SIGPRI=0, OMDIF=DISABLE, OMPRI=34; //The OM priority is not considered. Set the DSCP value of the OM flow to 34. SET DIFPRI: PRIRULE=DSCP, SIGPRI=0, OMDIF=ENABLE, OMHPRI=34, OMLPRI=10; // The OM priority is considered. Set the DSCP value of the OM flow with the high priority to 43 and that of the OM flow with the low priority to 10.

3.4.4 Setting the DSCP Value of the PTP Clock Packet


I. RNC
Not involved.

II. NodeB
SET DIFPRI: PRIRULE=DSCP, PTPPRI=34; // Set the DSCP value of the PTP clock packet to 34. Generally, the DSCP value of the PTP packet is consistent with that of the OAM flow.

3.4.5 Setting the DSCP Value of the BFD Packet


I. RNC

The RNC does not support the DSCP value configuration of the BFD packet. The default DSCP value is 56.

II. NodeB
Command: ADD BFDSESSION ADD BFDSESSION: BFDSN=1, HT=SINGLE_HOP, DSCP=34; // Set the DSCP value of the BFD session flow to 34. The default DSCP value is 48.

3.4.6 Setting the DSCP Value of the DHCP/ICMP/Tracert Packet


I. RNC
1. The RNC does not support the DSCP value configuration of the DHCP/Tracert packet. The default DSCP value is 0. 2.You can run the PING IP command to set the DSCP value of the ICMP packet. PING IP: CONTPING=NO, DSCP=46; // Set the DSCP value of the ping packet to 46.

II. NodeB
1.DHCP: For a new site, the DSCP value is fixed to 0. 2.Tracert/ICMP: The DHCP value configuration is not supported. If the NodeB initiates an ICMP request, the DSCP value is fixed to 63; if the NodeB initiates a Tracert packet, the DSCP value is fixed to 0; the ICMP response uses the DSCP value of the ICMP request; the DSCP value of the Tracert packet is fixed to 0.

3.5 VLAN Priority Configuration


The VLAN priorities used by each site need to be planned by the operator and configured on the intermediate transmission device.

3.5.1 Setting the VLAN Priority of the SCTP Link


I. RNC
Command: ADD SCTPLNK, SET DSCPMAP 1.Run the ADD SCTPLNK command to set the DSCP value of the SCTP link. ADD SCTPLNK: SCTPLNKN=2, DSCP=48; // Set the DSCP value of an SCTP link to 48. 2.Run the SET DSCPMAP command to set the mapping between the DSCP value and the VLAN priority. SET DSCPMAP: DSCP=48, VLANPRI=6; // The DSCP value 48 maps the VLAN priority 6.

II. NodeB
1.For V1, run the following command: SET VLANCLASS: TRAFFIC=SIG, INSTAG=ENABLE, VLANID=100, VLANPRIO=6; 2. For V2, set the VLAN ID and VLAN priority according to the IP address of the next hop. Additional configurations are unnecessary. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, VLANPRIO=6; // Set the IP address of the network

gateway of the NodeB to GW2. Set the VLAN ID to 100 and VLAN priority to 6 for all packets destined to the network gateway. 3.For V2, if VLANGROUP is selected, run the following command: ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=VLANGROUP, VLANGROUPNO=0; SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=SIG, INSTAG=ENABLE, VLANID=100, VLANPRIO=6; // For the signaling link data, set the VLAN ID to 100 and VLAN priority to 6. Note If different VLAN priorities need to be assigned to different types of services delivered to the network gateway, set the VLAN mode to VLANGROUP. If the VLAN mode is set to SINGLEVLAN, all packets destined to the network gateway carry the same VLAN ID and have the same VLAN priority.

3.5.2 Setting the VLAN Priority of the IP Path


I. RNC
Command: ADD IPPATH, SET PHBMAP, SET DSCPMAP 1.Run the ADD IPPATH command to set IP path type of an IP path to a PHB. ADD IPPATH: ANI=1, PATHID=1, ITFT=IUB, TRANST=IP, PATHT=EF; // Set IP path type of a specific IP path to EF. ADD IPPATH: ANI=1, PATHID=2, ITFT=IUB, TRANST=IP, PATHT=AF43; // Set IP path type of a specific IP path to AF43. ADD IPPATH: ANI=1, PATHID=3, ITFT=IUB, TRANST=IP, PATHT=AF23; // Set IP path type of a specific IP path to AF23. ADD IPPATH: ANI=1, PATHID=4, ITFT=IUB, TRANST=IP, PATHT=AF13; // Set IP path type of a specific IP path to AF13. 2.Run the SET PHBMAP command to set the DSCP value corresponding to the PHB. SET PHBMAP: PHB=EF, DSCP=46; // When the PHB is EF, the DSCP value is 46. SET PHBMAP: PHB= AF43, DSCP=38; // When the PHB is AF43, the DSCP value is 38. SET PHBMAP: PHB= AF23, DSCP=22; // When the PHB is AF23, the DSCP value is 22. SET PHBMAP: PHB= AF13, DSCP=14; // When the PHB is AF13, the DSCP value is 14. 3.Run the SET DSCPMAP command to set the mapping between the DSCP value and the VLAN priority. You can run the LST DSCPMAP command to query the default configuration. SET DSCPMAP: DSCP=46, VLANPRI=5; // The DSCP value 46 maps the VLAN priority 5. SET DSCPMAP: DSCP=38, VLANPRI=4; // The DSCP value 38 maps the VLAN priority 4. SET DSCPMAP: DSCP=22, VLANPRI=2; // The DSCP value 22 maps the VLAN priority 2. SET DSCPMAP: DSCP=14, VLANPRI=1; // The DSCP value 14 maps the VLAN priority 1.

II. NodeB

Run the ADD IPPATH command to set the DSCP value of an IP path. ADD IPPATH: PATHID=1, JNRSCGRP=DISABLE, DSCP=46; // Set the DSCP value of a specific IP path to 46. ADD IPPATH: PATHID=2, JNRSCGRP=DISABLE, DSCP=38; // Set the DSCP value of a specific IP path to 38. ADD IPPATH: PATHID=3, JNRSCGRP=DISABLE, DSCP=22; // Set the DSCP value of a specific IP path to 22. ADD IPPATH: PATHID=4, JNRSCGRP=DISABLE, DSCP=14; // Set the DSCP value of a specific IP path to 14. When running the SET VLANCLASS command, set Traffic Type to USERDATA, which indicates that the UDP protocol is supported, including the voice service, PS, HSPA service, and data on common channels. 1.For V1, run the following command: SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=48, INSTAG=ENABLE, VLANID=100, VLANPRIO=6; // Set the VLAN ID to 100 for the data whose DSCP value is 48. Note: Common signaling messages are transmitted on the common channels of the cell through UDP. These packets have higher priorities. The data from the NodeB to the RNC uses the DSCP value specified by SIG Priority in the SET DIFPRI command. Therefore, set Traffic Type to USERDATA and add the corresponding VLAN ID to the data whose DSCP is specified by Signal Priority. SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=46, INSTAG=ENABLE, VLANID=100, VLANPRIO=5; // Set the VLAN ID to 100 and VLAN priority to 5 for the data on the IP path whose DSCP value is 46. SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=38, INSTAG=ENABLE, VLANID=100, VLANPRIO=4; // Set the VLAN ID to 100 and VLAN priority to 4 for the data on the IP path whose DSCP value is 38. SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=22, INSTAG=ENABLE, VLANID=100, VLANPRIO=2; // Set the VLAN ID to 100 and VLAN priority to 2 for the data on the IP path whose DSCP value is 22. SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=14, INSTAG=ENABLE, VLANID=100, VLANPRIO=1; // Set the VLAN ID to 100 and VLAN priority to 1 for the data on the IP path whose DSCP value is 14. 2. For V2, add the VLAN ID according to the IP address of the next hop. Additional configurations are unnecessary. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, VLANPRIO=5; // Set the IP address of the network gateway of the NodeB to GW2. Set the VLAN ID to 100 for all packets destined to the network gateway. 3.For V2, if VLANGROUP is selected, run the following command: ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=VLANGROUP, VLANGROUPNO=0; SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=USERDATA, SRVPRIO=48, INSTAG=ENABLE, VLANID=100, VLANPRIO=5; // Set the VLAN ID to 100 and VLAN priority to 6 for the data whose DSCP is 48. Note: Common signaling messages are transmitted on the common channels of the cell through UDP. These packets have higher priorities. The data from the NodeB to the RNC uses the DSCP value specified by Signal Priority in the SET DIFPRI

command. Therefore, set Traffic Type to USERDATA and add the corresponding VLAN ID to the data whose DSCP is specified by Signal Priority. SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=USERDATA, SRVPRIO=46, INSTAG=ENABLE, VLANID=100, VLANPRIO=5; // Set the VLAN ID to 100 and VLAN priority to 5 for the data on the IP path whose DSCP is 46. SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=USERDATA, SRVPRIO=38, INSTAG=ENABLE, VLANID=100, VLANPRIO=4; // Set the VLAN ID to 100 and VLAN priority to 4 for the data on the IP path whose DSCP is 38. SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=USERDATA, SRVPRIO=22, INSTAG=ENABLE, VLANID=100, VLANPRIO=2; // Set the VLAN ID to 100 and VLAN priority to 2 for the data on the IP path whose DSCP is 22. SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=USERDATA, SRVPRIO=14, INSTAG=ENABLE, VLANID=100, VLANPRIO=1; // Set the VLAN ID to 100 and VLAN priority to 1 for the data on the IP path whose DSCP is 14.

3.5.3 Setting the VLAN Priority of the OAM Flow on the Iub Interface
I. RNC
Command: SET QUEUEMAP, SET DSCPMAP 1.Run the SET QUEUEMAP command to set the DSCP value of the Iub OAM flow. For details, see section 3.4.3 . 2.Run the SET DSCPMAP command to set the mapping between the DSCP value and the VLAN priority of the Iub OAM flow. SET DSCPMAP: DSCP=34, VLANPRI=4; // The DSCP value 34 maps the VLAN priority 4.

II. NodeB
1.For V1, run the following command: SET VLANCLASS: TRAFFIC=OM, INSTAG=ENABLE, VLANID=100, VLANPRIO=4; 2. For V2, set the VLAN ID and VLAN priority according to the IP address of the next hop. Additional configurations are unnecessary. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, VLANPRIO=4; // Set the IP address of the network gateway of the NodeB to GW2. Set the VLAN ID to 100 and VLAN priority to 6 for all packets destined to the network gateway. 3.For V2, if VLANGROUP is selected, run the following command: ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=VLANGROUP, VLANGROUPNO=0; SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=OM, INSTAG=ENABLE, OMDIF=DISABLE, VLANID=100, VLANPRIO=4; // Set the VLAN ID to 100 and VLAN priority to 4 for the OM data. // The priority of the OM flow is not considered. Set the VLAN priority of the Iub OAM flow to 4. SET VLANCLASS: VLANGROUPNO=0, TRAFFIC=OM, INSTAG=ENABLE, OMDIF=ENABLE, VLANID=100, VLANHPRIO=4, VLANLPRIO=1; // The OM priority is considered. Set the priority of the OM flow with the high priority to 34 and the priority of the OM flow with the low priority to 1.

3.5.4 Setting the VLAN Priority of the PTP Clock Packet

I. RNC
Not involved.

II. NodeB
1. For V2, set the VLAN ID and VLAN priority according to the IP address of the next hop. Additional configurations are unnecessary. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, VLANPRIO=4; // Set the IP address of the network gateway of the NodeB to GW2. Set the VLAN ID to 100 and VLAN priority to 4 for all packets destined to the network gateway. 2.For V2, if VLANGROUP is selected, run the following command: ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=VLANGROUP, VLANGROUPNO=0; SET DIFPRI: PRIRULE=DSCP, PTPPRI=34; // Set the DSCP value of the PTP clock packet to 34. Generally, the DSCP value of the PTP packet is consistent with that of the OAM flow. SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=34, INSTAG=ENABLE, VLANID=100, VLANPRIO=4; // Set VLAN Priority to 4, Traffic Type to USERDATA, and SPVPRIO to the DSCP value of the PTP packet.

3.5.5 Setting the VLAN Priority of the BFD Packet


I. RNC
The RNC does not support the DSCP value configuration of the BFD packet. The default DSCP value is 7.

II. NodeB
1. For V2, set the VLAN ID and VLAN priority according to the IP address of the next hop. Additional configurations are unnecessary. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, VLANPRIO=4; // Set the IP address of the network gateway of the NodeB to GW2. Set the VLAN ID to 100 and VLAN priority to 4 for all packets destined to the network gateway. 2.For V2, if VLANGROUP is selected, run the following command: ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=VLANGROUP, VLANGROUPNO=0; SET DIFPRI: PRIRULE=DSCP, PTPPRI=34; // Set the DSCP value of the PTP clock packet to 34. Generally, the DSCP value of the PTP packet is consistent with that of the OAM flow. SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=34, INSTAG=ENABLE, VLANID=100, ADD BFDSESSION: BFDSN=1, HT=SINGLE_HOP, DSCP=34; // Set the DSCP value of a specific BFD session to 48. SET VLANCLASS: TRAFFIC=USERDATA, SRVPRIO=34, INSTAG=ENABLE, VLANID=100, VLANPRIO=4; // Set VLAN Priority of the BFD session flow to 4 and Traffic Type to USERDATA for the BFD packets are transmitted through UDP. Set the user priority to the DSCP value of the BFD packet.

3.5.6 Setting the VLAN Priority of the ARP/DHCP/ICMP/Tracert

Packet
I. RNC
1.ARP packet The RNC does not support the DSCP value configuration of the ARP packet. The default DSCP value is 0. 2.DHCP/Tracert The RNC does not support the DSCP value configuration of the DHCP/Tracert packet. The default DSCP value is 0. 3.ICMP Run the PING IP command to set the DSCP value of the ping packet and then run the SET DSCPMAP command to set the VLAN priority mapping the DSCP value. PING IP: CONTPING=NO, DSCP=46; // Set the DSCP value of the ping packet to 46. SET DSCPMAP: DSCP=46, VLANPRI=5; // The DSCP value 46 maps the VLAN priority 5.

II. NodeB
1. For V2, set the VLAN ID and VLAN priority according to the IP address of the next hop. Additional configurations are unnecessary. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, VLANPRIO=4; // Set the IP address of the network gateway of the NodeB to GW2. Set the VLAN ID to 100 and VLAN priority to 4 for all packets destined to the network gateway. 2.For V2, if VLANGROUP is selected, run the following command: ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=VLANGROUP, VLANGROUPNO=0; SET VLANCLASS: TRAFFIC=OTHER, INSTAG=ENABLE, VLANID=100, VLANPRIO=5; // Set VLAN Priority of the ARP/DHCP/ICMP/Tracert packet to 5 and Traffic Type to OTHER, which indicates that ARP/DHCP/ICMP/Tracert is supported. Note The VLAN priority of either the ARP/ICMP request or response uses the value set in the preceding command. During the initial deployment phase of a new site, DHCP packets from the NodeB carry the VLAN ID learnt by the VLAN. VLAN Priority of such packets is set to 0.

3.6 Others
3.6.1 Setting the Mapping Between Queues at IP Ports and DSCP Values on the RNC
Command: SET QUEUEMAP The DSCP field in the IP packet indicates the priority of the packet. After the mapping between queues and DSCP values is set, IP packets of different types are assigned to queues of different priorities for transmission. SET QUEUEMAP: Q0MINDSCP=XX, Q1MINDSCP= XX, Q2MINDSCP= XX, Q3MINDSCP= XX, Q4MINDSCP= XX;

You can run the LST QUEUEMAP command to query the default mapping configuration as follows.

The default mapping between DSCP values and queues 0 to 5 is as follows. DSCP 40~63 32~39 24~31 16~23 8~15 0~7 Note IP ports include the Ethernet ports, PPP links, MP groups, and IP logic ports. Each IP port has six traffic queues with different priorities. The queues, from queue 0 to queue 5, are in descending order by priority. (2) Q0MINDSCP to Q4MINDSCP must meet the following conditions: Q0MINDSCP > Q1MINDSCP > Q2MINDSCP > Q3MINDSCP > Q4MINDSCP QUEUE ID 0 1 2 3 4 5

3.6.2 Setting the Mapping Between the DSCP Value and VLAN Priority on the RNC
Command: SET DSCPMAP SET DSCPMAP: DSCP=X, VLANPRI=X; You can run the LST DSCPMAP command to query the default mapping configuration as follows: DSCP 0~7 8~15 16~23 24~31 32~39 40~47 48~55 56~63 VLAN Priority 0 1 2 3 4 5 6 7

3.6.3 Setting the Mapping Between the PHB and DSCP on the RNC
Command: SET PHBMAP SET PHBMAP: SRN=0, SN=18, PHB=BE, DSCP=X; You can run the LST PHBMAP command to query the default mapping configuration as follows: PHB EF AF4 AF43 AF42 AF41 AF3 AF33 AF32 AF31 AF2 AF23 AF22 AF21 AF1 AF13 AF12 AF11 BE DSCP 46 38 36 34 30 28 26 22 20 18 14 12 10 0

Configuration Example of the Iub Interface

4.1 Description
Configuration For

examples are based on RNC V900R012 and NodeB V200R12.

configuration details, refer to the Initial Configuration Guide and the corresponding MML online help. networking of configuration examples is only for reference. The networking of each site needs to be designed and deployed according to the actual situations.

The

4.2 Typical Configuration of IP Layer 2 Networking Based on MSTP


4.2.1 Networking Diagram

4.2.2 Preparations
Cables The

are properly connected and intermediate transmission devices are ready.

data planning is completed.

4.2.3 Networking Data Planning


I. Data Planning in the Physical Layer and Data Link Layer

Data Item Data on the FE port Interface board type IP address of the network gateway Whether to back up/Backup mode Subrack No./slot No./port No. IP address of the FE port/subnet mask Device IP address/subnet mask Data on the IP logic port IP logic port No. Bandwidth of the IP logic port Dynamic bandwidth adjustment switch

RNC GOUa 10.10.10.10/24 Yes/Board backup+port backup 0/18/0 10.10.10.1/24 20.20.20.20/32 10 40000kbps(64k*625) OFF

NodeB WMPT 10.10.10.1/24 No 0/6/0 10.10.10.10/24

Data Source Internal planning Network planning Internal planning

Network planning

II. Data Planning of the Control Plane


Data Item NCP SCTPLNK No. Local SCTP port No. Working mode of the SCTP link Subrack No./slot No. of the SPU DSCP Local IP address 1 Local IP address 2 Whether to bind the IP logic port/slot No. and port No. of the logic port Whether to add the VLAN/VLAN ID CCP SCTPLNK No. Local SCTP port No. Working mode of the SCTP link Port No. Subrack No./slot No. of the SPU DSCP Local IP address 1 Local IP address 2 Whether to bind the IP logic port/slot No. and port No. of the logic port Whether to add the VLAN/VLAN ID RNC 1 58080 Server 0/0 48 20.20.20.20/32 Yes/18/10 NodeB 1 8000 Client 48 10.10.10.10/24 Data Source Data to be negotiated

YES/VLAN100 2 58080 Server 0 0/0 48 20.20.20.20/32 Yes/18/10

YES/VLAN100 2 8001 Client 0 48 10.10.10.10/24

YES/VLAN100

YES/VLAN100

III. Data Planning of the User Plane


Data Item NodeB name Adjacent node ID Transport type of the Iub interface Four IP paths of different types with different DSCP values Port type IP path ID Path type/DSCP value Whether to bind the IP logic port/slot No. and port No. of the logic port Local IP address/subnet mask Whether to enable the VLAN/What the enabled VLAN ID is Path detection flag Detected IP address TX bandwidth (kbps) RX bandwidth (kbps) Whether to enable the FPMUX RNC RNC8-BBU1 10 IP ETH 1/2/3/4 PHB:EF/AF43/AF23/AF13 Yes/18/10 NodeB BBU1 IP ETH 1/2/3/4 DSCP:46/38/22/14 Data to be negotiated Data Source Data to be negotiated

20.20.20.20/32 YES/VLAN100

10.10.10.10/24 YES/VLAN100

Network planning

ENABLE 10.10.10.10/24 40000 40000 NO

DISABLE 40000 40000 NO

Network planning

4.2.4 Data Configuration on the RNC


The following blue data in the MML command needs to be planned or negotiated.

I. Data Configuration in the Physical Layer and Data Link Layer


Configure

the backup information of the interface board according to the networking situation on site. ADD BRD: SRN=0, BRDCLASS=INT, BRDTYPE=GOUa, SN=18, RED=YES, MPUSUBRACK=0, MPUSLOT=0; // Set the GOUa board in slot 18 of subrack 0 and GOUa board in slot 19 to work in active/standby mode.

Configure

the backup information of the ports on the interface board according to the networking situation on site. ADD ETHREDPORT: SRN=0, SN=18, PN=0; // Set port 0 on the GOUa in slot 18 of subrack 0 and port 0 on the GOUa in slot 19 to work in active/standby mode.

Set

the attributes of the Ethernet ports. Ensure that the Ethernet port attributes are consistent on both ends. The MTU value on the NodeB needs to be smaller or equal to that of the intermediate transmission device. See section 3.2 . SET ETHPORT: SRN=0, SN=18, BRDTYPE=GOUa, PN=0, AUTO=ENABLE, MTU=1500, OAMFLOWBW=0, FLOWCTRLSWITCH=ON, FCINDEX=1;

Major parameters are described as follows: AUTO Auto negotiation or not Description: This parameter setting on the RNC must be consistent with that on the peer device through negotiation. That is, if this parameter is set to auto negotiation on the peer device, the parameter on the port of the RNC is also set to auto negotiation; otherwise, it is set to non-auto negotiation. Description: Generally, the transmission rate over the FE port is 100 Mbit/s or 1000 Mbit/s. Description: Half duplex indicates that the data packets cannot be transmitted during the receiving of data packets; full duplex indicates that the data packets can be transmitted and received at the same time. Generally, the working mode is set to full duplex.

SPEED

Transmission rate over the port Working mode

DUPLEX

Add

the IP address of the Ethernet port. The IP address is planned by the operator.

ADD ETHIP: SRN=0, SN=18, PN=0, IPINDEX=0, IPADDR="10.10.10.1", MASK="255.255.255.0"; // The IP address of the interface board on the RNC is 10.10.10.1/24.
Add

the device IP address of the interface board (optional). The IP address is planned by the operator or set ETHIP to service IP. ADD DEVIP: SRN=0, SN=18, DEVTYPE=LOGIC_IP, IPADDR="20.20.20.20"; // Add the logic IP address 20.20.20.20 on the interface board in slot 18. The default subnet mask 255.255.255.255 is adopted.

Add

the IP logic port (optional). Operators need to purchase the corresponding license. ADD IPLOGICPORT: SRN=0, SN=18, BT=GOUa, LPN=10, CARRYT=ETHER, PN=0, RSCMNGMODE=EXCLUSIVE, CNOPINDEX=0, BWADJ=OFF, CIR=625, FLOWCTRLSWITCH=ON; // The logic port is on port 0 in slot 18 and the bandwidth on the port is 625 64 kbps = 40 Mbps,

II. Data Configuration on the Control Plane


Add

SCTP signaling links (the data on the control plane). At least two SCTP links are needed; one is used to transmit the NCP data and the other is used to transmit the CCP data. The RNC acts as a server. The local IP address can be the IP address of an Ethernet port or the device IP address. In this example, the device IP address is used. The peer IP address is the IP address of an FE port of the interface board of the NodeB. The port No. is negotiated by two ends. Both the SCTP links are added to the planned IP logic port. ADD SCTPLNK: SRN=0, SN=0, SCTPLNKN=1, MODE=SERVER, APP=NBAP, DSCP=48, LOCIP1="20.20.20.20", PEERIP1="10.10.10.10", PEERPN=8000, LOGPORTFLAG=YES, LOGPORTSN=18, LOGPORTNO=10, VLANFLAG1=DISABLE, VLANFlAG2=DISABLE, SWITCHBACKFLAG=YES; ADD SCTPLNK: SRN=0, SN=0, SCTPLNKN=2, MODE=SERVER, APP=NBAP, DSCP=48, LOCIP1="20.20.20.20", PEERIP1="10.10.10.10", PEERPN=8001, LOGPORTFLAG=YES, LOGPORTSN=18, LOGPORTNO=10, VLANFLAG1=DISABLE, VLANFlAG2=DISABLE, SWITCHBACKFLAG=YES;

Note: When the RNC acts as an SCTP server, you can run the SET SCTPSRVPORT command to set the local SCTP port No.. Generally, the default No. is used. You can use the LST SCTPSRVPORT command to query the default No..

Add

a NodeB and algorithm parameters (data on the control plane).

ADD UNODEB: NodeBName="RNC8-BBU1", NodeBId=1, SRN=0, SN=0, TnlBearerType=IP_TRANS, IPTRANSAPARTIND=NOT_SUPPORT, HostType=SINGLEHOST, SharingType=DEDICATED, CnOpIndex=0; ADD UNODEBALGOPARA: NodeBName="RNC8-BBU1", NodeBLdcAlgoSwitch=IUB_LDR-1&NODEB_CREDIT_LDR-1; // The algorithm switch is configured based on the data planning of the radio layer. It necessary to set corresponding parameter for the algorithm switch if turn it on.
Add

an adjacent node (data on the control plane).

ADD ADJNODE: ANI=10, NAME=" NODEB1", NODET=IUB, NODEBID=1, TRANST=IP;


Add

links on the NodeB control port (data on the control plane).

ADD UNCP: NodeBName=" RNC8-BBU1", CARRYLNKT=SCTP, SCTPLNKN=1; ADD UCCP: NodeBName=" RNC8-BBU1", PN=0, CARRYLNKT=SCTP, SCTPLNKN=2;

III. Mapping Between Transmission Resources and Configuration of the Activation


Factor Table
Add

the mapping between transmission resources to map services of different QoS requirements to different IP paths. When the IP transport is applied to the Iub port, TRMMP ID is set to 1 by default. If the default mapping cannot meet the requirements, you can use the ADD TRMMAP command to add a TRMMP ID.

You can run the LST TRMMAP command to query the default settings. TRMMAP(Iub IP) Service Type Common channel IMS SRB SRB AMR voice R99 CS conversational R99 CS streaming R99 PS conversational R99 PS streaming R99 PS high PRI interactive R99 PS middle PRI interactive Default Primary EF EF EF EF AF43 AF43 AF43 AF43 AF23 AF23 Secondary NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL

R99 PS low PRI interactive R99 PS background HSDPA Signal HSDPA IMS Signal HSDPA Voice HSDPA conversational HSDPA streaming HSDPA high PRI interactive HSDPA middle PRI interactive HSDPA low PRI interactive HSDPA background HSUPA Signal HSUPA IMS Signal HSUPA Voice HSUPA conversational HSUPA streaming HSUPA high PRI interactive HSUPA middle PRI interactive HSUPA low PRI interactive HSUPA background
Add

AF23 AF23 EF EF AF43 AF43 AF43 AF13 AF13 AF13 AF13 EF EF AF43 AF43 AF43 AF13 AF13 AF13 AF13

NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL

an activation factor table to specify proper factors for each traffic class. Through this task, the transmission resources can be multiplexed. By default, Factor Table Index is set to 0. If the default mapping cannot meet the requirements, you can use the ADD TRMFACTOR command to add an index.

You can run the LST TRMFACTOR command to query the default settings. TRMFACTOR Service Type General common channel service downlink General common channel service uplink IMS SRB service downlink IMS SRB service uplink MBMS common channel service downlink SRB service downlink SRB service uplink AMR voice service downlink AMR voice service uplink R99 CS conversational service downlink R99 CS conversational service uplink R99 CS streaming service downlink R99 CS streaming service uplink Default Factor (%) 70 70 15 15 100 15 15 70 70 100 100 100 100

R99 PS conversational service downlink R99 PS conversational service uplink R99 PS streaming service downlink R99 PS streaming service uplink R99 PS interactive service downlink R99 PS interactive service uplink R99 PS background service downlink R99 PS background service uplink HSDPA signal downlink HSDPA IMS signal downlink HSDPA voice service downlink HSDPA conversational service downlink HSDPA streaming service downlink HSDPA interactive service downlink HSDPA background service downlink HSUPA signal uplink HSUPA IMS signal uplink HSUPA voice service uplink HSUPA conversational service uplink HSUPA streaming service uplink HSUPA interactive service uplink HSUPA background service uplink EFACH channel forward
Configure

70 70 100 100 100 100 100 100 50 15 70 70 100 100 100 50 15 70 70 100 100 100 20

the TRM mapping on the adjacent node. You can run the ADD TRMMAP command to add the TRMMAP ID for the gold, silver, and bronze users. ADD ADJMAP: ANI=10, ITFT=IUB, TRANST=IP, CNMNGMODE=EXCLUSIVE, CNOPINDEX=0, TMIGLD=1, TMISLV=1, TMIBRZ=1, FTI=0; // In this example, both TMI and FTI use default values.

IV. Data Configuration on the User Plane


Configure

the IP route to the interface of the NodeB on the Iub interface board of the

RNC. In layer 2 networking, the IP route is not configured for the interface IP address of the RNC is in the same network segment as that of the NodeB.
Add

IP paths. The traffic unit is kbps. The Transmission Configuration Specifications recommends four IP paths with four priorities. You can run the LST PHBMAP command to query the DSCP value corresponding to the PHB of each IP path. ADD IPPATH: ANI=10, PATHID=1, ITFT=IUB, TRANST=IP, PATHT=EF, IPADDR="20.20.20.20", PEERIPADDR="10.10.10.10", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="10.10.10.10"; // When the PHB is EF, the DSCP value is 46. ADD IPPATH: ANI=10, PATHID=2, ITFT=IUB, TRANST=IP, PATHT=AF43,

IPADDR="20.20.20.20", PEERIPADDR="10.10.10.10", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="10.10.10.10"; // When the PHB is AF43, the DSCP value is 38. ADD IPPATH: ANI=10, PATHID=3, ITFT=IUB, TRANST=IP, PATHT= AF23, IPADDR="20.20.20.20", PEERIPADDR="10.10.10.10", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="10.10.10.10"; // When the PHB is AF23, the DSCP value is 22. ADD IPPATH: ANI=10, PATHID=4, ITFT=IUB, TRANST=IP, PATHT= AF13, IPADDR="20.20.20.20", PEERIPADDR="10.10.10.10", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="10.10.10.10"; // When the PHB is AF13, the DSCP value is 14.

V. VLAN/VLAN Priority/DSCP Configuration


VLAN

Configuration

Generally, the VLAN ID needs to be configured in layer 2 networking. In this example, the VLAN ID is set to 100 between the RNC and NodeB1. ADD VLANID: SRN=0, SN=18, IPADDR="10.10.10.10", VLANID=100; // On the RNC, the VLAN ID is set to 100 for the next hop. In layer 2 networking, the interface IP address of NodeB1 is the next hop of the RNC. Note: The VLAN needs to be configured on the intermediate transmission device. If the VLAN ID can be added on the peer transmission device, the VLAN configuration is unnecessary on the RNC. DSCP Configuration According to the planning of the existing network, see section 3.4 for DSCP values of various services. Note: DSCP values need to be configured on intermediate transmission devices.
VLAN

Priority Configuration

According to the planning of the existing network, see section 3.5 for VLAN priorities of various services. Note: VLAN priorities need to be configured on the intermediate transmission devices.

VI. IP Route Configuration

4.2.5 Data Configuration on the NodeB


Note During the deployment on site, the data on the NodeB is configured by using the CME. For clear configuration description, here only describes the configuration related to MML commands. The contents in blue in the following MML commands need to be planned or negotiated.

I. Data Configuration in the Physical Layer


Set

the attributes of the Ethernet ports. Ensure that Ethernet port attributes are consistent on both ends. The MTU value on the NodeB needs to be smaller or equal to that of the intermediate transmission device. See section 3.2 .

SET ETHPORT: SRN=0, SN=6, SBT=BASE_BOARD, PN=0, MTU=1500, SPEED=100M, DUPLEX=FULL, ARPPROXY=DISABLE; // If the interface IP address on the NodeB is in the same network segment as that of the OM IP address, ARPPROXY is set to Enable.
Add

the IP address of the Ethernet port. The IP address of the FE port on the NodeB is 10.10.10.10/24. ADD DEVIP: SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, PN=0, IP="10.10.10.10", MASK="255.255.255.0";

II. Data Configuration on the Control Plane


At

least add two SCTP links; one is used to transmit the NCP data and the other is used to transmit the CCP data. ADD SCTPLNK: SCTPNO=1, SRN=0, SN=6, LOCIP="10.10.10.10", LOCPORT=8000, PEERIP="20.20.20.20", PEERPORT=58080; ADD SCTPLNK: SCTPNO=2, SRN=0, SN=6, LOCIP="10.10.10.10", LOCPORT=8001, PEERIP="20.20.20.20", PEERPORT=58080;

Add

links on the NodeB control port.

ADD IUBCP: CPPT=NCP, BEAR=IPV4, LN=1; ADD IUBCP: CPPT=CCP, CPPN=0, BEAR=IPV4, LN=2;

III. Data Configuration on the User Plane


Add four IP paths with different priorities. Ensure that the configuration is consistent with that on the RNC. The ping detection switch on the IP path on the NodeB is disabled. ADD IPPATH: PATHID=1, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="10.10.10.10", RNCIP="20.20.20.20", DSCP=46, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=2, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="10.10.10.10", RNCIP="20.20.20.20", DSCP=38, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=3, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="10.10.10.10", RNCIP="20.20.20.20", DSCP=22, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=4, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="10.10.10.10", RNCIP="20.20.20.20", DSCP=14, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE;

IV. VLAN/VLAN Priority/DSCP Configuration


VLAN

Configuration

Generally, the VLAN ID needs to be configured in layer 2 networking. In this example, the VLAN ID is set to 100 between the RNC and NodeB1. Method I: All packets from the NodeB to the network gateway carry the same VLAN ID and have the same VLAN priority. ADD VLANMAP: NEXTHOPIP="GW2", VLANMODE=SINGLEVLAN, INSTAG=ENABLE, VLANID=100, VLANPRIO=1; // Set the VLAN mode to SINGLEVLAN and the IP address of the network gateway on the NodeB to GW2. Set

the VLAN ID to 100 and VLAN priority to 4 for all packets to this network gateway. Method 2: Add the same VLAN ID for all packets from the NodeB to the network gateway. Assign different VLAN priorities to different traffic. ADD VLANMAP: NEXTHOPIP="10.10.10.1", VLANMODE=VLANGROUP, VLANGROUPNO=0; // Set the VLAN mode to VLANGROUP. Set the VLAN ID and VLAN priority of the traffic by using the SET VLANCLASS command. For the specific VLAN ID setting, see sections 3.3.2 3.3.7 . Note: The VLAN needs to be configured on the intermediate transmission device. If the VLAN ID can be added on the peer transmission device, the VLAN configuration is unnecessary on the RNC. The VLAN needs to be configured on the intermediate transmission device.
DSCP

Configuration

According to the planning of the existing network, see section 3.4 for DSCP values of various services. Note: DSCP values need to be configured on the intermediate transmission device.
VLAN

Priority Configuration

According to the planning of the existing network, see section 3.5 for VLAN priorities of various services. Note: VLAN priorities need to be configured on the intermediate transmission devices.

V. IP Route Configuration
Configure

the IP route to the device IP address of the RNC on the WMPT of the

NodeB. ADD IPRT: SRN=0, SN=6, SBT=BASE_BOARD, DSTIP="20.20.20.20", DSTMASK="255.255.255.255", RTTYPE=NEXTHOP, NEXTHOP="10.10.10.1"; // In this case, the device IP address serves the IP address for the traffic on the RNC. Therefore, add this route on the NodeB. The next hop is the interface IP address of the RNC.

4.3 Typical Configuration of IP Layer 3 Networking Based on the Data Network


4.3.1 Networking Diagram

4.3.2 Preparations

Cables The

are properly connected and intermediate transmission devices are ready.

data planning is completed.

4.3.3 Data Planning of Layer 3 Networking


I. Data Planning in the Physical Layer and Data Link Layer
Data Item Data on the FE port Interface board type IP address of the network gateway Whether to back up/Backup mode Subrack No./slot No./port No. IP address of the FE port/subnet mask Device IP address/subnet mask Data on the IP logic port IP logical port No. Bandwidth of the IP logic port Dynamic bandwidth adjustment switch RNC GOUa 10.10.10.2/24 Yes/Board backup+port backup 0/18/0 10.10.10.1/24 20.20.20.20/32 10 40000kbps (64k*625) OFF NodeB WMPT 40.40.40.39/24 No 0/6/0 40.40.40.40/24 Network planning Data Source Internal planning Network planning Internal planning

II. Data Planning of the Control Plane


Data Item SCTKLNK No. Local SCTP port No. Working mode of the SCTP link Subrack No./slot No. of the SPU DSCP NCP Local IP address 1 Local IP address 2 Whether to bind the IP logic port/slot No. and port No. of the logic port Whether to add the VLAN/VLAN ID SCTPLNK No. Local SCTP port No. Working mode of the SCTP link Port No. Subrack No./slot No. of the RNC 1 58080 Server 0/0 48 20.20.20.20/32 Yes/18/10 NodeB 1 8000 Client 48 40.40.40.40/24 Data Source Data to be negotiated

NO 2 58080 Server 0 0/0

YES/VLAN200 2 8001 Client 0

SPU DSCP Local IP address 1 Local IP address 2 CCP Whether to bind the IP logic port/slot No. and port No. of the logic port Whether to add the VLAN/VLAN ID 48 20.20.20.20/32 Yes/18/10 48 40.40.40.40/24

NO

YES/VLAN200

III. Data Planning of the User Plane


Data Item NodeB name Adjacent node ID Transport type of the Iub interface Port type IP path ID Path type/DSCP value Whether to bind the IP logic port/slot No. and port No. of the logic port Local IP address/subnet mask Whether to enable the VLAN/enabled VLAN ID Path detection flag Detected IP address TX bandwidth (kbps) RX bandwidth (kbps) Whether to enable the FPMUX RNC RNC8-BBU1 10 IP ETH 1/2/3/4 PHB:EF/AF43/AF23/AF13 Yes/18/10 NodeB BBU1 IP ETH 1/2/3/4 DSCP:46/38/22/14 Data to be negotiated Data Source Data to be negotiated

Four IP paths of different path types with different DSCP values

20.20.20.20/32 NO

40.40.40.40/24 YES/VLAN200

Network planning

ENABLE 40.40.40.40/24 40000 40000 NO

DISABLE 40000 40000 NO

Network planning

4.3.4 Data Configuration on the RNC


I. Data Configuration on the Physical Layer and Data Link Layer
The configuration on the RNC is the same as that of the layer 2 on the Iub interface. For details, see section 4.2.4 .

II. Data Configuration on the Control Plane


Add

SCTP signaling links (data on the control plane). At least two SCTP links are needed; one is used to transmit the NCP data and the other is used to transmit the

CCP data. The RNC acts as a server. The local IP address can be the IP address of an Ethernet port or the device IP address. In this example, the device IP address is used. The peer IP address is the IP address of an FE port of the interface board of the NodeB. The port No. is negotiated by two ends. Two SCTP links are added to the planned IP logic port. ADD SCTPLNK: SRN=0, SN=0, SCTPLNKN=1, MODE=SERVER, APP=NBAP, DSCP=48, LOCIP1="20.20.20.20", PEERIP1="40.40.40.40", PEERPN=8000, LOGPORTFLAG=YES, LOGPORTSN=18, LOGPORTNO=10, VLANFLAG1=DISABLE, VLANFlAG2=DISABLE, SWITCHBACKFLAG=YES; ADD SCTPLNK: SRN=0, SN=0, SCTPLNKN=2, MODE=SERVER, APP=NBAP, DSCP=48, LOCIP1="20.20.20.20", PEERIP1="40.40.40.40", PEERPN=8001, LOGPORTFLAG=YES, LOGPORTSN=18, LOGPORTNO=10, VLANFLAG1=DISABLE, VLANFlAG2=DISABLE, SWITCHBACKFLAG=YES; Note: When the RNC acts as an SCTP server, you can run the SET SCTPSRVPORT command to set the local SCTP port No.. Generally, the default No. is used. You can use the LST SCTPSRVPORT command to query the default No..

Add

a NodeB and algorithm parameters (data on the control plane).

ADD UNODEB: NodeBName="RNC8-BBU1", NodeBId=1, SRN=0, SN=0, TnlBearerType=IP_TRANS, IPTRANSAPARTIND=NOT_SUPPORT, HostType=SINGLEHOST, SharingType=DEDICATED, CnOpIndex=0; ADD UNODEBALGOPARA: NodeBName="RNC8-BBU1", NodeBLdcAlgoSwitch=IUB_LDR-1&NODEB_CREDIT_LDR-1; // The algorithm switch is configured based on the data planning of the radio layer.
Add

an adjacent node (data on the control plane).

ADD ADJNODE: ANI=10, NAME=" NODEB1", NODET=IUB, NODEBID=1, TRANST=IP;


Add

links on the NodeB control port (data on the control plane).

ADD UNCP: NodeBName=" RNC8-BBU1", CARRYLNKT=SCTP, SCTPLNKN=1; ADD UCCP: NodeBName=" RNC8-BBU1", PN=0, CARRYLNKT=SCTP, SCTPLNKN=2;

III. Mapping Between Transmission Resources and Configuration of the Activation


Factor Table
Add

the mapping between transmission resources to map services of different QoS requirements to different IP paths. When the IP transport is applied to the Iub port, TRMMP ID is set to 1 by default. If the default mapping cannot meet the requirements, you can use the ADD TRMMAP command to add a TRMMP ID. See section 4.2.4 . an activation factor table to specify proper factors for each traffic class. Through this task, the transmission resources can be multiplexed. By default, Factor Table Index is set to 0. If the default mapping cannot meet the requirements, you can use the ADD TRMFACTOR command to add an index. See section 4.2.4 . the TRM mapping on the adjacent node. You can run the ADD TRMMAP

Add

Configure

command to add the TRMMAP ID for the gold, silver, and bronze users. ADD ADJMAP: ANI=10, ITFT=IUB, TRANST=IP, CNMNGMODE=EXCLUSIVE, CNOPINDEX=0, TMIGLD=1, TMISLV=1, TMIBRZ=1, FTI=0; // In this example, both TMI and FTI use default values.

IV. Data Configuration on the User Plane


According

to the planning on site, you can configure either the host route (the subnet mask of the destination IP address is 255.255.255.255) or the network segment route (the destination IP address is the network address and the subnet mask cannot be 255.255.255.255). Configure the IP route to the interface IP address of the NodeB on the Iub interface board of the RNC. ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.40", DSTMASK="255.255.255.255", NEXTHOP="10.10.10.2", PRIORITY=HIGH, REMARK="RNC INT To NodeB1"; // Configure the host route to the interface IP address of NodeB1.

Add

IP paths. The traffic unit is kbps. The Transmission Configuration Specifications recommends four IP paths with four priorities. You can run the LST PHBMAP command to query the DSCP value corresponding to the PHB of each IP path. ADD IPPATH: ANI=10, PATHID=1, ITFT=IUB, TRANST=IP, PATHT=EF, IPADDR="20.20.20.20", PEERIPADDR="40.40.40.40", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.40"; // When the PHB is EF, the DSCP value is 46. ADD IPPATH: ANI=10, PATHID=2, ITFT=IUB, TRANST=IP, PATHT=AF43, IPADDR="20.20.20.20", PEERIPADDR="40.40.40.40", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.40"; // When the PHB is AF43, the DSCP value is 38. ADD IPPATH: ANI=10, PATHID=3, ITFT=IUB, TRANST=IP, PATHT= AF23, IPADDR="20.20.20.20", PEERIPADDR="40.40.40.40", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.40"; // When the PHB is AF23, the DSCP value is 22. ADD IPPATH: ANI=10, PATHID=4, ITFT=IUB, TRANST=IP, PATHT= AF13, IPADDR="20.20.20.20", PEERIPADDR="40.40.40.40", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.40"; // When the PHB is AF13, the DSCP value is 14.

V. VLAN/VLAN Priority/DSCP Configuration


VLAN

Configuration

If the RNC directly connects to the router in layer 3 networking, the VLAN ID is not configured on the RNC. If the VLAN ID needs to be configured on the RNC, run the ADD VLANID command to add the VLAN ID for the next hop (VRRP Virtual IP) of the RNC. Note: The VLAN needs to be configured on the intermediate transmission device.

DSCP

Configuration

According to the planning of the existing network, see section 3.3 for DSCP values of various services. Note: DSCP values need to be configured on the intermediate transmission device.
VLAN

Priority Configuration

If the RNC directly connects to the router in layer 3 networking, the VLAN ID is not configured on the RNC. Then, the VLAN priorities are not configured. If VLAN priorities need to be configured on the RNC, see section 3.4 according to the planning of the existing network. Note: VLAN priorities need to be configured on the intermediate transmission devices.

4.3.5 Data Configuration on the NodeB


Note During the deployment on site, the data on the NodeB is configured by using the CME. For clear configuration description, here only describes the configuration related to MML commands. The contents in blue in the following MML commands need to be planned or negotiated.

I. Data Configuration in the Physical Layer


Set

attributes of Ethernet ports. Ensure that the Ethernet port attributes are consistent on both ends. The MTU value on the NodeB needs to be smaller or equal to that of the intermediate transmission device. See section 3.2 .

SET ETHPORT: SRN=0, SN=6, SBT=BASE_BOARD, PN=0, MTU=1500, SPEED=100M, DUPLEX=FULL, ARPPROXY=DISABLE; // If the interface IP address of the NodeB is on the same network segment as that of the OM IP address, set ARP Proxy to Enable. Add the IP address of the Ethernet port. The IP address of the FE port on the NodeB is 10.10.10.10/24. ADD DEVIP: SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, PN=0, IP="40.40.40.40", MASK="255.255.255.0";

II. Data Configuration on the Control Plane


At

least, add two SCTP links; one is used to transmit the NCP data and the other is used to transmit the CCP data.

ADD SCTPLNK: SCTPNO=1, SRN=0, SN=6, LOCIP="10.10.10.10", LOCPORT=8000, PEERIP="20.20.20.20", PEERPORT=58080; ADD SCTPLNK: SCTPNO=2, SRN=0, SN=6, LOCIP="10.10.10.10", LOCPORT=8001, PEERIP="20.20.20.20", PEERPORT=58080;
Add

links on the NodeB control port.

ADD IUBCP: CPPT=NCP, BEAR=IPV4, LN=1; ADD IUBCP: CPPT=CCP, CPPN=0, BEAR=IPV4, LN=2;

III. Data Configuration on the User Plane


Add

four IP paths with different priorities. Ensure that the configuration is consistent

with that on the RNC. The ping detection switch on the IP path on the NodeB is disabled. ADD IPPATH: PATHID=1, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="40.40.40.40", RNCIP="20.20.20.20", DSCP=46, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=1, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="40.40.40.40", RNCIP="20.20.20.20", DSCP=38, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=1, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="40.40.40.40", RNCIP="20.20.20.20", DSCP=22, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=1, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="40.40.40.40", RNCIP="20.20.20.20", DSCP=14, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE;

IV. VLAN/VLAN Priority/DSCP Configuration


VLAN

Configuration

In layer 3 networking, the NodeB may first connect to a layer 2 network. In this case, a VLAN ID needs to be configured on the NodeB. In this example, the VLAN ID is set to 200 on the NodeB. ADD VLANMAP: NEXTHOPIP="40.40.40.39", VLANMODE=VLANGROUP, VLANGROUPNO=0; // Configure a VLAN group to the network gateway on the NodeB. For the specific VLAN ID setting, see sections 3.3.2 3.3.7 . Note: The VLAN needs to be configured on the intermediate transmission device. If the VLAN ID can be added on the peer transmission device, the VLAN configuration is unnecessary on the RNC.
DSCP

Configuration

According to the planning of the existing network, see section 3.4 for DSCP values of various services. Note: DSCP values need to be configured on the intermediate transmission devices.
VLAN

Priority Configuration

According to the planning of the existing network, see section 3.5 for VLAN priorities of various services. Note: VLAN priorities need to be configured on the intermediate transmission devices.

V. IP Route Configuration
According to the planning on site, you can configure either the host route (the subnet mask of the destination IP address is 255.255.255.255) or the network segment route (the destination IP address is the network address and the subnet mask cannot be 255.255.255.255).
Configure

the IP route to the RNC on the WMPT of the NodeB.

ADD IPRT: SRN=0, SN=6, SBT=BASE_BOARD, DSTIP="20.20.20.20", DSTMASK="255.255.255.255", RTTYPE=NEXTHOP, NEXTHOP="40.40.40.39"; // Configure the host route to the device IP address of the RNC for the device IP

address serve as the IP address for the traffic on the RNC.


Configure

the IP route to the Ethernet port of the RNC on the WMPT of the NodeB. It is optional. To facilitate the commissioning, the route needs to be configured when you need to ping the IP address of the Ethernet port on the RNC from the NodeB. ADD IPRT: SRN=0, SN=6, SBT=BASE_BOARD, DSTIP="10.10.10.1", DSTMASK="255.255.255.255", RTTYPE=NEXTHOP, NEXTHOP="40.40.40.39"; // Configure the host route to the interface IP address of the RNC.

4.4 Typical Configuration of Hybrid Transport Networking


4.4.1 Networking Diagram

The hybrid transport can be planned on site based on the path on which each service is transmitted. For the signaling, real-time service, and R99 PS, the IP over SDH is preferred; for the HSPA BE service, the IP over Ethernet over Iub OMCH is preferred.

4.4.2 Preparations
Cables The

are properly connected and intermediate transmission devices are ready.

data planning is completed.

4.4.3 Data Planning of the Hybrid Transport Networking


I. Data Planning in the Physical Layer and Data Link Layer
Data Item Interface board type IP address of the network gateway Whether to back up/Backup mode RNC GOUa 10.10.10.2/24 Yes/Board backup+port NodeB WMPT 40.40.40.39/24 No Data Source Internal planning Network planning Internal planning

backup Subrack No./slot No./port No. Data on the FE port IP address of the FE port/subnet mask Device IP address/subnet mask IP logical port No. Data on the IP logic port Bandwidth of the IP logic port Dynamic bandwidth adjustment switch Interface board type IP address of the network gateway Subrack No./Slot No./Port No. PPP/MLPPP link data MPGRP group No. MPLNK No. Local IP address/subnet mask Bearer timeslot 0/18/0 10.10.10.1/24 20.20.20.20/32 10 40000kbps (64k*625) OFF POUa 0/14/0,1,2 0 0/1/2 13.13.13.1/24 TS1TS31 0/6/0 40.40.40.40/24 WMPT 0/6/0,1,2 0 0/1/2 13.13.13.2/24 TS1TS31 Network planning Data to be negotiated Internal planning Network planning

II. Data Planning of the Control Plane


Data Item SCTPLNK No. Local SCTP port No. Working mode of the SCTP link Subrack No./slot No. of the SPU NCP DSCP Local IP address 1 Local IP address 2 Whether to add the VLAN/VLAN ID SCTPLNK No. Local SCTP port No. Working mode of the SCTP link CCP Port No. Subrack No./slot No. of the SPU DSCP Local IP address 1 RNC 1 58080 Server 0/0 48 13.13.13.1/24 NO 2 58080 Server 0 0/0 48 13.13.13.1/24 NodeB 1 8000 Client 48 13.13.13.2/24 NO 2 8001 Client 0 48 13.13.13.2/24 Data Source Data to be negotiated

Local IP address 2 Whether to add the VLAN/VLAN ID

NO

NO

III. Data Planning of the User Plane


Data Item NodeB name Adjacent node ID Transport type of the Iub interface Port type IP path ID Path type/DSCP value Four IP paths are carried on MP. Local IP address/subnet mask Whether to enable the VLAN/enabled VLAN ID Path detection flag Detected IP address TX bandwidth (kbps) RX bandwidth (kbps) Whether to enable the FPMUX Port type IP path ID Path type/DSCP value Whether to bind the IP logic port/slot No. and port No. of the logic port Local IP address/subnet mask Whether to enable the VLAN/enabled VLAN ID Path detection flag Detected IP address TX bandwidth (kbps) RX bandwidth (kbps) Whether to enable the FPMUX RNC RNC8-BBU1 10 HYBRID_IP MP 1/2/3/4 PHB:EF/AF43/AF23/AF13 13.13.13.1/24 NO NodeB BBU1 HYBRID_IP MP 1/2/3/4 DSCP:46/38/22/14 13.13.13.2/24 NO Network planning Data to be negotiated Data Source Data to be negotiated

ENABLE 13.13.13.2/24 5952 5952 NO ETH 5/6/7/8 PHB:LQ_EF/ LQ_AF43/ LQ_AF23/ LQ_AF13 Yes/18/10

DISABLE 5952 5952 NO ETH 5/6/7/8 DSCP:46/38/22/14 Data to be negotiated

Four IP paths are carried on the GE.

20.20.20.20/32 NO

40.40.40.40/24 YES/VLAN200

Network planning

ENABLE 40.40.40.40/24 40000 40000 NO

DISABLE 40000 40000 NO

4.4.4 Data Configuration on the RNC


I. Data Configuration on the Physical Layer and Data Link Layer
Configure

the backup information of the interface board according to the networking situation on site.

ADD BRD: SRN=0, BRDCLASS=INT, BRDTYPE=GOUa, SN=18, RED=YES, MPUSUBRACK=0, MPUSLOT=0; // Set the GOUa board in slot 18 of subrack 0 and GOUa board in slot 19 to work in active/standby mode. ADD BRD: SRN=0, BRDCLASS=INT, BRDTYPE=POUa, SN=14, RED=YES, MPUSUBRACK=0, MPUSLOT=0; // Set the POUa board in slot 14 of subrack 0 and POUa board in slot 15 to work in active/standby mode.
Configure

the backup information of the ports on the interface board according to the networking situation on site.

ADD ETHREDPORT: SRN=0, SN=18, PN=0; //Port 0 on the GOUa in slot 18 of subrack 0 and port 0 on the GOUa in slot 19 are configured to work in active/standby mode. SET MSP: SRN=0, SN=14, PN=0, RT=REVERTIVE, K2MODE=NOT-INDICATE-END, SDSFPRI=HIGH, MODE=MODE3; // Port 0 on the POUa in slot 14 of subrack 0 and port 0 on the POUa in slot 15 are configured to work in MSP mode. Ensure that settings of interconnection parameters are consistent on both ends through negotiation.
Set

the attributes of the Ethernet ports. Ensure that the Ethernet port attributes are consistent on both ends. The MTU value on the RNC needs to be smaller or equal to that of the intermediate transmission device. See section 3.2 . SET ETHPORT: SRN=0, SN=18, BRDTYPE=GOUa, PN=0, AUTO=ENABLE, MTU=1500, OAMFLOWBW=0, FLOWCTRLSWITCH=ON, FCINDEX=1;

Major parameters are described as follows: AUTO Auto negotiation or not Description: This parameter setting on the RNC must be consistent with that on the peer device through negotiation. That is, if this parameter is set to auto negotiation on the peer device, the parameter on the port of the RNC is also set to auto negotiation; otherwise, it is set to non-auto negotiation. Description: Generally, the transmission rate over the FE port is 100 Mbit/s or 1000 Mbit/s. Description: Half duplex indicates that the data packets cannot be transmitted during the receiving of data packets; full duplex indicates that the data packets can be transmitted and received at the same time. Generally, the working mode is set to full duplex.

SPEED

Transmission rate over the port Working mode

DUPLEX

Run

the following command to add the IP address of the Ethernet port. The IP address is planned by the operator. ADD ETHIP: SRN=0, SN=18, PN=0, IPINDEX=0, IPADDR="10.10.10.1", MASK="255.255.255.0"; // The IP address of the interface board on the RNC is 10.10.10.1/24.

Add

the device IP address of the interface board (optional) on the GOUa. The IP

address is planned by the operator. ADD DEVIP: SRN=0, SN=18, DEVTYPE=LOGIC_IP, IPADDR="20.20.20.20"; // Add the logic IP address 20.20.20.20 on the interface board in slot 18. The default subnet mask 255.255.255.255 is adopted.
Add

the IP logic port (optional) on the interface board of the GOUa. Operators need to purchase the corresponding license. ADD IPLOGICPORT: SRN=0, SN=18, BT=GOUa, LPN=10, CARRYT=ETHER, PN=0, RSCMNGMODE=EXCLUSIVE, CNOPINDEX=0, BWADJ=OFF, CIR=625, FLOWCTRLSWITCH=ON; // The logic port is on port 0 in slot 18 and the bandwidth on the port is 625 64 kbps = 40 Mbps.

Set

attributes of the optical ports on the POUa. Ensure that the attribute values are consistent on both ends. You can run the LST OPT command to query the default attribute values. If the default values can meet the requirements, additional configuration is unnecessary. SET OPT: SRN=0, SN=14, BT=POUa, PS=SINGLE, PN=0, LNKNUMMODE=HUAWEI_MODE, J0TXT=NULL, J0RXT=NULL, J1TXT=NULL, J1RXT=NULL, S1VALUE=1, JAUTOADD=ZERO;

Set

attributes of the E1 cables on the POUa. Ensure that the attribute values are consistent on both ends. You can run the LST E1T1 command to query the default attribute values. If the default values can meet the requirements, additional configuration is unnecessary. SET E1T1: SRN=0, SN=14, BT=POUa, PS=SINGLE, PN=0, PTTYPE=E1_CRC4_MULTI_FRAME; SET E1T1: SRN=0, SN=14, BT=POUa, PS=SINGLE, PN=1, PTTYPE=E1_CRC4_MULTI_FRAME; SET E1T1: SRN=0, SN=14, BT=POUa, PS=SINGLE, PN=2, PTTYPE=E1_CRC4_MULTI_FRAME;

Add

MP groups and MP links.

ADD MPGRP: SRN=0, SN=14, BRDTYPE=POUa, MPGRPN=0, MPTYPE=MCPPP, BORROWDEVIP=NO, LOCALIP="13.13.13.1", MASK="255.255.255.0", PEERIP="13.13.13.2", MHF=LONG, PPPMUX=Disable, PFC=Enable, ACFC=Enable, FLOWCTRLSWITCH=ON, AUTHTYPE=NO_V, ERRDETECTSW=OFF, ANTIERRFLAG=OFF; ADD MPLNK: SRN=0, SN=14, BRDTYPE=POUa, MPGRPN=0, PPPLNKN=0, DS1=0, TSBITMAP=TS1-1&TS2-1&TS3-1&TS4-1&TS5-1&TS6-1&TS7-1&TS81&TS9-1&TS10-1&TS11-1&TS12-1&TS13-1&TS14-1&TS15-1&TS16-1&TS171&TS18-1&TS19-1&TS20-1&TS21-1&TS22-1&TS23-1&TS24-1&TS25-1&TS261&TS27-1&TS28-1&TS29-1&TS30-1&TS31-1; ADD MPLNK: SRN=0, SN=14, BRDTYPE=POUa, MPGRPN=0, PPPLNKN=1, DS1=1, TSBITMAP=TS1-1&TS2-1&TS3-1&TS4-1&TS5-1&TS6-1&TS7-1&TS81&TS9-1&TS10-1&TS11-1&TS12-1&TS13-1&TS14-1&TS15-1&TS16-1&TS171&TS18-1&TS19-1&TS20-1&TS21-1&TS22-1&TS23-1&TS24-1&TS25-1&TS261&TS27-1&TS28-1&TS29-1&TS30-1&TS31-1; ADD MPLNK: SRN=0, SN=14, BRDTYPE=POUa, MPGRPN=0, PPPLNKN=2, DS1=2, TSBITMAP=TS1-1&TS2-1&TS3-1&TS4-1&TS5-1&TS6-1&TS7-1&TS81&TS9-1&TS10-1&TS11-1&TS12-1&TS13-1&TS14-1&TS15-1&TS16-1&TS171&TS18-1&TS19-1&TS20-1&TS21-1&TS22-1&TS23-1&TS24-1&TS25-1&TS261&TS27-1&TS28-1&TS29-1&TS30-1&TS31-1;

II. Data Configuration on the Control Plane


Add

SCTP signaling links (data on the control plane). At least two SCTP links are needed; one is used to transmit the NCP data and the other is used to transmit the

CCP data. The RNC acts as a server. The local IP address can be the IP address of an Ethernet port or the device IP address. In this example, the device IP address is used. The peer IP address is the IP address of an FE port of the interface board of the NodeB. The port No. is negotiated by two ends. ADD SCTPLNK: SRN=0, SN=0, SCTPLNKN=1, MODE=SERVER, APP=NBAP, DSCP=48, LOCIP1="13.13.13.1", PEERIP1="13.13.13.2", PEERPN=8000, LOGPORTFLAG=NO, VLANFLAG1=DISABLE, VLANFlAG2=DISABLE, SWITCHBACKFLAG=YES; ADD SCTPLNK: SRN=0, SN=0, SCTPLNKN=2, MODE=SERVER, APP=NBAP, DSCP=48, LOCIP1="13.13.13.1", PEERIP1="13.13.13.2", PEERPN=8001, LOGPORTFLAG=NO, VLANFLAG1=DISABLE, VLANFlAG2=DISABLE, SWITCHBACKFLAG=YES; Note: When the RNC acts as an SCTP server, you can run the SET SCTPSRVPORT command to set the local SCTP port No.. Generally, the default No. is used. You can use the LST SCTPSRVPORT command to query the default No..

Add

a NodeB and algorithm parameters (data on the control plane).

ADD UNODEB: NodeBName="RNC8-BBU1", NodeBId=1, SRN=0, SN=0, TnlBearerType=HYBRID_IP_TRANS, IPTRANSAPARTIND=SUPPORT, HostType=SINGLEHOST, SharingType=DEDICATED, CnOpIndex=0; ADD UNODEBALGOPARA: NodeBName="RNC8-BBU1", NodeBLdcAlgoSwitch=IUB_LDR-1&NODEB_CREDIT_LDR-1; // The algorithm switch is configured based on the data planning of the radio layer. Its necessary to configure parameters corresponding to a specific algorithm switch if it is turned on.
Add

an adjacent node (data on the control plane).

ADD ADJNODE: ANI=10, NAME=" NODEB1", NODET=IUB, NODEBID=1, TRANST=HYBRID_IP;


Add

links on the NodeB control port (data on the control plane).

ADD UNCP: NodeBName=" RNC8-BBU1", CARRYLNKT=SCTP, SCTPLNKN=1; ADD UCCP: NodeBName=" RNC8-BBU1", PN=0, CARRYLNKT=SCTP, SCTPLNKN=2;

III. Mapping Between Transmission Resources and Configuration of the Activation


Factor Table
Add

the mapping between transmission resources to map services of different QoS requirements to different IP paths. When the IP transport is applied to the Iub port, TRMMP ID is set to 1 by default. If the default mapping cannot meet the requirements, you can use the ADD TRMMAP command to add a TRMMP ID.

You can run the LST TRMMAP command to query the default settings. TRMMAP(Iub Hybrid IP) Service Type Common channel Default Primary EF Secondary LQEF

IMS SRB SRB AMR voice R99 CS conversational R99 CS streaming R99 PS conversational R99 PS streaming R99 PS high PRI interactive R99 PS middle PRI interactive R99 PS low PRI interactive R99 PS background HSDPA Signal HSDPA IMS Signal HSDPA Voice HSDPA conversational HSDPA streaming HSDPA high PRI interactive HSDPA middle PRI interactive HSDPA low PRI interactive HSDPA background HSUPA Signal HSUPA IMS Signal HSUPA Voice HSUPA conversational HSUPA streaming HSUPA high PRI interactive HSUPA middle PRI interactive HSUPA low PRI interactive HSUPA background
Add

EF EF EF AF43 AF43 AF43 AF43 AF23 AF23 AF23 AF23 EF EF AF43 AF43 AF43 LQAF13 LQAF13 LQAF13 LQAF13 EF EF AF43 AF43 AF43 LQAF13 LQAF13 LQAF13 LQAF13

LQEF LQEF LQEF LQAF43 LQAF43 LQAF43 LQAF43 LQAF23 LQAF23 LQAF23 LQAF23 LQEF LQEF LQAF43 LQAF43 LQAF43 AF13 AF13 AF13 AF13 LQEF LQEF LQAF43 LQAF43 LQAF43 AF13 AF13 AF13 AF13

an activation factor table to specify proper factors for each traffic class. Through this task, the transmission resources can be multiplexed. By default, Factor Table Index is set to 0. If the default mapping cannot meet the requirements, you can use the ADD TRMFACTOR command to add an index. See section 4.2.4 . the threshold table for load balancing between active and standby paths. You can run the LST LOADEQ command (LOADEQ ID = 0) to obtain the default threshold table. If the default mapping cannot meet the requirement, you can run the ADD LOADEQ command to add an index. In this example, the default mapping is used.

Configure

Generally, the active path is preferred to carry the load. If the following conditions are met, the standby path is preferred.

The load on the active path is greater than the load threshold of this path. The load on the active path times the threshold for the ratio of the load on the active path to the load on the standby path is greater than the load on the standby path. Default Service Type Load Threshold of the Active Path (%) 100 100 100 100 100 100 100 100 30 30 30 30 100 100 100 100 100 30 30 30 30 100 100 100 100 100 30 30 30 30 Threshold for the Ratio of the Load on the Active Path to the Load on the Standby Path (%) 0 0 0 0 0 0 0 0 100 100 100 100 0 0 0 0 0 100 100 100 100 0 0 0 0 0 100 100 100 100

Common channel IMS SRB SRB AMR voice R99 CS conversational R99 CS streaming R99 PS conversational R99 PS streaming R99 PS high PRI interactive R99 PS middle PRI interactive R99 PS low PRI interactive R99 PS background HSDPA Signal HSDPA IMS Signal HSDPA Voice HSDPA conversational HSDPA streaming HSDPA high PRI interactive HSDPA middle PRI interactive HSDPA low PRI interactive HSDPA background HSUPA Signal HSUPA IMS Signal HSUPA Voice HSUPA conversational HSUPA streaming HSUPA high PRI interactive HSUPA middle PRI interactive HSUPA low PRI interactive HSUPA background
Configure

the TRM mapping on the adjacent node. You can run the ADD TRMMAP command to add the TRMMAP ID for the gold, silver, and bronze users.

ADD ADJMAP: ANI=10, ITFT=IUB, TRANST=HYBRID_IP, CNMNGMODE=EXCLUSIVE, CNOPINDEX=0, TMIGLD=3, TMISLV=3, TMIBRZ=3, FTI=0, LEIGLD=0, LEISLV=0, LEIBRZ=0;

IV. Data Configuration on the User Plane


Configure

the IP route to the interface IP address of the NodeB on the Iub interface board of the RNC. According to the planning on site, you can configure either the host route (the subnet mask of the destination IP address is 255.255.255.255) or the network segment route (the destination IP address is the network address and the subnet mask cannot be 255.255.255.255). ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.40", DSTMASK="255.255.255.255", NEXTHOP="10.10.10.2", PRIORITY=HIGH, REMARK="RNC INT To NodeB1"; // Configure the host route to the interface IP address of NodeB1. The route does not need to be configured on the Iub interface board of the POUa on the RNC for IP addresses of both MP ends are on the same network segment.

Add

IP paths. The traffic unit is kbps. The Transmission Configuration Specifications recommends four IP paths with four priorities. You can run the LST PHBMAP command to query the DSCP value corresponding to the PHB of each IP path. ADD IPPATH: ANI=10, PATHID=1, ITFT=IUB, TRANST=HYBRID_IP, PATHT=EF, IPADDR="13.13.13.1", PEERIPADDR="13.13.13.2", PEERMASK="255.255.255.255", TXBW=5952, RXBW=5952, CARRYFLAG=NULL, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="13.13.13.2"; // When the PHB is EF, the DSCP value is 46. The data is transmitted in IP over SDH mode. ADD IPPATH: NI=10, PATHID=2, ITFT=IUB, TRANST=HYBRID_IP, PATHT=AF43, IPADDR="13.13.13.1", PEERIPADDR="13.13.13.2", PEERMASK="255.255.255.255", TXBW=5952, RXBW=5952, CARRYFLAG= NULL, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="13.13.13.2"; // When the PHB is AF43, the DSCP value is 38. The data is transmitted in IP over SDH mode. ADD IPPATH: ANI=10, PATHID=3, ITFT=IUB, TRANST=HYBRID_IP, PATHT=AF23, IPADDR="13.13.13.1", PEERIPADDR="13.13.13.2", PEERMASK="255.255.255.255", TXBW=5952, RXBW=5952, CARRYFLAG= NULL, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="13.13.13.2"; // When the PHB is AF23, the DSCP value is 22. The data is transmitted in IP over SDH mode. ADD IPPATH: ANI=10, PATHID=4, ITFT=IUB, TRANST=HYBRID_IP, PATHT=AF13, IPADDR="13.13.13.1", PEERIPADDR="13.13.13.2", PEERMASK="255.255.255.255", TXBW=5952, RXBW=5952, CARRYFLAG= NULL, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="13.13.13.2"; // When the PHB is AF13, the DSCP value is 14. The data is transmitted in IP over SDH mode. ADD IPPATH: ANI=10, PATHID=5, ITFT=IUB, TRANST=HYBRID_IP, PATHT= LQ_EF, IPADDR="20.20.20.20", PEERIPADDR="40.40.40.40", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.40"; // When PATH Type is set to LQ_EF, the DSCP value is 46. The data is transmitted in IP over Ethernet mode. ADD IPPATH: ANI=10, PATHID=6, ITFT=IUB, TRANST=HYBRID_IP, PATHT= LQ_AF43, IPADDR="20.20.20.20", PEERIPADDR="40.40.40.40", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.40"; // When PATH Type is set to LQ_AF13, the DSCP value is 38. The data is transmitted in IP over Ethernet mode. ADD IPPATH: ANI=10, PATHID=7, ITFT=IUB, TRANST=HYBRID_IP, PATHT=

LQ_AF23, IPADDR="20.20.20.20", PEERIPADDR="40.40.40.40", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.40"; // When PATH Type is set to LQ_AF23, the DSCP value is 22. The data is transmitted in IP over Ethernet mode. ADD IPPATH: ANI=10, PATHID=8, ITFT=IUB, TRANST=HYBRID_IP, PATHT= LQ_AF13, IPADDR="20.20.20.20", PEERIPADDR="40.40.40.40", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.40"; // When PATH Type is set to LQ_AF13, the DSCP value is 14. The data is transmitted in IP over Ethernet mode.

V. VLAN/VLAN Priority/DSCP Configuration


VLAN IP

Configuration

over Ethernet: If the RNC directly connects to the router in layer 3 networking, the VLAN ID is not configured on the RNC. If the VLAN ID needs to be configured on the RNC, run the ADD VLANID command to add the VLAN ID for the next hop (VRRP Virtual IP) of the RNC. over SDH: The VLAN is not configured. Configuration

IP

Note: The VLAN needs to be configured on the intermediate transmission device.


DSCP

According to the planning of the existing network, see section 3.3 for DSCP values of various services. Note: DSCP values need to be configured on the intermediate transmission device. VLAN Priority Configuration
IP

Over Ethernet: If the RNC directly connects to the router in layer 3 networking, the VLAN ID is not configured on the RNC. Then, the VLAN priorities are not configured. If VLAN priorities need to be configured on the RNC, see section 3.4 according to the planning of the existing network. over SDH: The VLAN is not configured.

IP

Note: VLAN priorities need to be configured on the intermediate transmission devices.

4.4.5 Data Configuration on the NodeB


Note During the deployment on site, the data on the NodeB is configured by using the CME. For clear configuration description, here only describes the configuration related to MML commands. The contents in blue in the following MML commands need to be planned or negotiated.

I. Data Configuration on the Physical Layer and Data Link Layer


Set

the attributes of the Ethernet ports. Ensure that the Ethernet port attributes are consistent on both ends. The MTU value on the NodeB needs to be smaller or equal to that of the intermediate transmission device. See section 3.2 . SET ETHPORT: SRN=0, SN=6, SBT=BASE_BOARD, PN=0, MTU=1500, SPEED=100M, DUPLEX=FULL, ARPPROXY=DISABLE; // If the interface IP address of the NodeB is on the same network segment as that of the OM IP address, set ARP Proxy to Enable.

Add

the IP address of the Ethernet port. The IP address of the FE port on the NodeB is 40.40.40.40/24. ADD DEVIP: SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, PN=0, IP="40.40.40.40", MASK="255.255.255.0";

Set

the bearer mode of the E1/T1 cables to IPV4. Then, reset the transmission interface board. SET E1T1BEAR: SRN=0, SN=6, MODE=IPV4; attributes of the E1 cables on the WMPT. Ensure that the attribute values are consistent on both ends. You can run the DSP E1T1WORKMODE command to query the attribute values. SET E1T1WORKMODE: SRN=0, SN=6, SBT=BASE_BOARD, FRAME=E1_CRC4_MULTI_FRAME, LNCODE=HDB3, CLKM=MASTER;

Set

Add

MP groups and MP links.

ADD MPGRP: SRN=0, SN=6, SBT=BASE_BOARD, MPGRPN=0, AUTH=NONAUTH, LOCALIP="13.13.13.2", IPMASK="255.255.255.0", PEERIP="13.13.13.1", IPHC=ENABLE;

ADD MPLNK: CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PPPLNKN=0, MPGRPSBT=BASE_BOARD, MPGRPN=0, E1T1SRN=0, E1T1SN=6, E1T1SBT=BASE_BOARD, E1T1PN=0, TSN=TS1&TS2&TS3&TS4&TS5&TS6&TS7&TS8&TS9&TS10&TS11&TS12&TS13&TS14&TS15& PFC=ENABLE, ACFC=ENABLE;

ADD MPLNK: CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PPPLNKN=1, MPGRPSBT=BASE_BOARD, MPGRPN=0, E1T1SRN=0, E1T1SN=6, E1T1SBT=BASE_BOARD, E1T1PN=1, TSN=TS1&TS2&TS3&TS4&TS5&TS6&TS7&TS8&TS9&TS10&TS11&TS12&TS13&TS14&TS15& PFC=ENABLE, ACFC=ENABLE;

ADD MPLNK: CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PPPLNKN=2, MPGRPSBT=BASE_BOARD, MPGRPN=0, E1T1SRN=0, E1T1SN=6, E1T1SBT=BASE_BOARD, E1T1PN=1, TSN=TS1&TS2&TS3&TS4&TS5&TS6&TS7&TS8&TS9&TS10&TS11&TS12&TS13&TS14&TS15& PFC=ENABLE, ACFC=ENABLE;

II. Data Configuration on the Control Plane


At

least, add two SCTP links; one is used to transmit the NCP data and the other is used to transmit the CCP data. ADD SCTPLNK: SCTPNO=1, SRN=0, SN=6, LOCIP="13.13.13.2", LOCPORT=8000, PEERIP="13.13.13.1", PEERPORT=58080; ADD SCTPLNK: SCTPNO=2, SRN=0, SN=6, LOCIP="13.13.13.2", LOCPORT=8001, PEERIP="13.13.13.1", PEERPORT=58080;

Add

links on the NodeB control port.

ADD IUBCP: CPPT=NCP, BEAR=IPV4, LN=1; ADD IUBCP: CPPT=CCP, CPPN=0, BEAR=IPV4, LN=2;

III. Data Configuration on the User Plane


Add

IP paths. Configure four IP paths with different priorities in IP over SDH mode; configure four IP paths with different priorities in IP over Ethernet mode. The configuration must be consistent with that on the RNC. The ping detection switch on the IP path on the NodeB is disabled. ADD IPPATH: PATHID=1, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT= MPGRP, PN=0, JNRSCGRP=DISABLE, NODEBIP="13.13.13.2",

RNCIP="13.13.13.1", DSCP=46, RXBW=5952, TXBW=5952, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=2, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT= MPGRP, PN=0, JNRSCGRP=DISABLE, NODEBIP="13.13.13.2", RNCIP="13.13.13.1", DSCP=38, RXBW=5952, TXBW=5952, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=3, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT= MPGRP, PN=0, JNRSCGRP=DISABLE, NODEBIP="13.13.13.2", RNCIP="13.13.13.1", DSCP=22, RXBW=5952, TXBW=5952, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=4, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT= MPGRP, PN=0, JNRSCGRP=DISABLE, NODEBIP="13.13.13.2", RNCIP="13.13.13.1", DSCP=14, RXBW=5952, TXBW=5952, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=5, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="40.40.40.40", RNCIP="20.20.20.20", DSCP=46, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=6, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="40.40.40.40", RNCIP="20.20.20.20", DSCP=38, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=7, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="40.40.40.40", RNCIP="20.20.20.20", DSCP=22, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=8, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="40.40.40.40", RNCIP="20.20.20.20", DSCP=14, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE;

IV. VLAN/VLAN Priority/DSCP Configuration


VLAN IP

Configuration

Over Ethernet

In layer 3 networking, the NodeB may first connect to a layer 2 network. In this case, the VLAN ID is configured on the NodeB. In this example, set the VLAN ID to 200 on the NodeB. ADD VLANMAP: NEXTHOPIP="40.40.40.39", VLANMODE=VLANGROUP, VLANGROUPNO=0; // Configure a VLAN group to the network gateway on the NodeB. For the specific VLAN ID setting, see sections 3.3.2 3.3.7 .
IP

over SDH: The VLAN is not configured. Configuration

Note: The VLAN needs to be configured on the intermediate transmission device.


DSCP

According to the planning of the existing network, see section 3.3 for DSCP values of various services. Note: DSCP values need to be configured on the intermediate transmission device.
VLAN IP

Priority Configuration

Over Ethernet

For VLAN priorities of various services, see section 3.4 according to the planning

of the existing network.


IP

over SDH: The VLAN is not configured.

Note: VLAN priorities need to be configured on the intermediate transmission devices.

V. IP Route Configuration
According to the planning on site, you can configure either the host route (the subnet mask of the destination IP address is 255.255.255.255) or the network segment route (the destination IP address is the network address and the subnet mask cannot be 255.255.255.255).
Configure

the IP route to the device IP address of the RNC on the WMPT of the

NodeB. ADD IPRT: SRN=0, SN=6, SBT=BASE_BOARD, DSTIP="20.20.20.20", DSTMASK="255.255.255.255", RTTYPE=NEXTHOP, NEXTHOP="40.40.40.39"; // Configure the host route to the device IP address of the RNC for the device IP address serve as the IP address for the traffic on the RNC in this example.
Configure

the IP route to the Ethernet port of the RNC on the WMPT of the NodeB. It is optional. To facilitate the commissioning, the route needs to be configured when you need to ping the IP address of the Ethernet port on the RNC from the NodeB. ADD IPRT: SRN=0, SN=6, SBT=BASE_BOARD, DSTIP="10.10.10.1", DSTMASK="255.255.255.255", RTTYPE=NEXTHOP, NEXTHOP="40.40.40.39"; // Configure the host route to the interface IP address of RNC.

The

route does not need to be configured on the interface board of the NodeB for IP addresses of both MP ends are on the same network segment.

4.5 Typical Configuration of the Dual-Stack-Based Networking


4.5.1 Networking Diagram

The dual stack transport can be planned on site based on the path on which each service is transmitted. For the signaling, real-time service, and R99 PS, the ATM networking is preferred; for the

HSPA BE service, the Iub OMCH over IP over Ethernet is preferred.

4.5.2 Preparations
Cables The

are properly connected and intermediate transmission devices are ready.

data planning is completed.

4.5.3 Data Planning of the Dual Stack Transport Networking


I. Data Planning in the Physical Layer and Data Link Layer
Data Item Data on the FE port Interface board type IP address of the network gateway Whether to back up/Backup mode Subrack No./Slot No./Port No. IP address of the FE port/subnet mask Device IP address/subnet mask Data on the IP logic port IP logic port No. Bandwidth of the IP logic port Dynamic bandwidth adjustment switch Interface board type Subrack No./slot No./optical port No. IMA group No. IMA link No. Data of the ATM logic port ATM logic port No. Bandwidth of the ATM logic port RNC GOUa 10.10.10.2/24 Yes/Board backup+port backup 0/18/0 10.10.10.1/24 NodeB WMPT 40.40.40.39/24 No Data Source Internal planning Network planning Internal planning

0/6/0 40.40.40.40/24 Network planning

20.20.20.20/32

10 40000kbps (64k*625) OFF

IMA link data

UOIa 0/14/0

WMPT 0/6/0,1,2

Internal planning

20 5712kbps

0 0/1/2

II. Data Planning of the Control Plane


Data Item RNC NodeB Data Source

NCP

Subrack No./slot No. of the SPU Carried VPI/VCI TX traffic type TR traffic type Bearer link type

0/0 10/34 CBR CBR SAAL 0/0 10/35 CBR CBR SAAL 0/0 10/36 CBR CBR SAAL

1/34 CBR CBR SAAL 1/35 CBR CBR SAAL 1/36 CBR CBR SAAL

CCP

Subrack No./slot No. of the SPU Carried VPI/VCI TX traffic type TR traffic type Bearer link type

ALCAP

Subrack No./slot No. of the SPU Carried VPI/VCI TX traffic type TR traffic type Bearer link type

III. Data Planning of the User Plane


Data Item NodeB name Adjacent node ID Transport type of the Iub interface Five AAL2 paths Port type AAL2 path identifier Path type RNC RNC8-BBU1 10 ATM_IP NCOPT 1/2/3/4/5 Three RT_VBRs, one NRT_VBR, and one UBR Yes/14/20 NodeB BBU1 10 ATM_IP IMA 1/2/3/4/5 Three RT_VBRs, one NRT_VBR, and one UBR Network planning Data to be negotiated Data Source Data to be negotiated

Whether to bind the ATM logic port/slot No. and port No. of the logic port Subrack No./slot No. VPI/VCI Four IP paths are carried on the GE. Port type IP path ID Path type/DSCP value Whether to bind the IP logic port/slot No. and port No. of the logic port

0/14/0 10/40,10/41,10/42, 10/43,10/44 ETH 1/2/3/4 PHB:EF/ AF43/ AF23/ AF13 Yes/18/10

0/7/0 1/40,1/41,1/42,1/43,1/44 ETH 1/2/3/4 DSCP:46/38/22/14 Data to be negotiated

Local IP address/subnet mask Whether to enable the VLAN/enabled VLAN ID Path detection flag Detected IP address TX bandwidth (kbps) RX bandwidth (kbps) Whether to enable the FPMUX

20.20.20.20/32 NO ENABLE 40.40.40.40/24 40000 40000 NO

40.40.40.40/24 YES/VLAN200 DISABLE 40000 40000 NO

Network planning

4.5.4 Data Configuration on the RNC


I. Data Configuration on the Physical Layer and Data Link Layer
Configure

the backup information of the interface board according to the networking situation on site. ADD BRD: SRN=0, BRDCLASS=INT, BRDTYPE=GOUa, SN=18, RED=YES, MPUSUBRACK=0, MPUSLOT=0; // Set the GOUa board in slot 18 of subrack 0 and GOUa board in slot 19 to work in active/standby mode. ADD BRD: SRN=0, BRDCLASS=INT, BRDTYPE=UOIa, LGCAPPTYPE=ATM, SN=14, RED=YES, MPUSUBRACK=0, MPUSLOT=0; // Set the UOIa board in slot 14 of subrack 0 and UOIa board in slot 15 to work in active/standby mode.

Configure

the backup information of the ports on the interface board according to the networking situation on site. ADD ETHREDPORT: SRN=0, SN=18, PN=0; //Set port 0 on the GOUa in slot 18 of subrack 0 and port 0 on the GOUa in slot 19 to work in active/standby mode. SET MSP: SRN=0, SN=14, PN=0, RT=REVERTIVE, K2MODE=NOT-INDICATEEND, SDSFPRI=HIGH, MODE=MODE3; // Port 0 on the UOIa in slot 14 of subrack 0 and port 0 on the UOIa in slot 15 are configured to work in MSP mode. Ensure that settings of interconnection parameters are consistent on both ends through negotiation.

Set

the attributes of the Ethernet ports. Ensure that the Ethernet port attributes are consistent on both ends. The MTU value on the RNC needs to be smaller or equal to that of the intermediate transmission device. See section 3.2 . SET ETHPORT: SRN=0, SN=18, BRDTYPE=GOUa, PN=0, AUTO=ENABLE, MTU=1500, OAMFLOWBW=0, FLOWCTRLSWITCH=ON, FCINDEX=1;

Major parameters are described as follows: AUTO Auto negotiation or not Description: This parameter setting on the RNC must be consistent with that on the peer device through negotiation. That is, if this parameter is set to auto negotiation on the peer device, the parameter on the port of the RNC is also set to auto negotiation; otherwise, it is set to non-auto negotiation. Description: Generally, the transmission rate over the FE port is 100 Mbit/s or 1000 Mbit/s.

SPEED

Transmission rate over the port

DUPLEX

Working mode

Description: Half duplex indicates that the data packets cannot be transmitted during the receiving of data packets; full duplex indicates that the data packets can be transmitted and received at the same time. Generally, the working mode is set to full duplex.

Add

the IP address of the Ethernet port. The IP address is planned by the operator.

ADD ETHIP: SRN=0, SN=18, PN=0, IPINDEX=0, IPADDR="10.10.10.1", MASK="255.255.255.0"; // The IP address of the interface board on the RNC is 10.10.10.1/24.
Add

the device IP address of the interface board (optional) on the GOUa. The IP address is planned by the operator. ADD DEVIP: SRN=0, SN=18, DEVTYPE=LOGIC_IP, IPADDR="20.20.20.20"; // Add the logic IP address 20.20.20.20 on the interface board in slot 18. The default subnet mask 255.255.255.255 is adopted.

Add

the IP logic port (optional) on the interface board of the GOUa. The operator needs to purchase the corresponding license. ADD IPLOGICPORT: SRN=0, SN=18, BT=GOUa, LPN=10, CARRYT=ETHER, PN=0, RSCMNGMODE=EXCLUSIVE, CNOPINDEX=0, BWADJ=OFF, CIR=625, FLOWCTRLSWITCH=ON; // The logic port is on port 0 in slot 18 and the bandwidth on the port is 625 64 kbps = 40 Mbps.

Set

attributes of the optical ports on the UOIa. Ensure that the attribute values are consistent on both ends. You can run the LST OPT command to query the default attribute values. If the default values can meet the requirements, additional configuration is unnecessary. SET OPT: SRN=0, SN=14, BT=UOIa, PS=SINGLE, PN=0, LNKNUMMODE=HUAWEI_MODE, J0TXT=NULL, J0RXT=NULL, J1TXT=NULL, J1RXT=NULL, S1VALUE=1, JAUTOADD=ZERO;

Add

the ATM logic port (optional) on the interface board of the GOUa. The operator needs to purchase the corresponding license. ADD ATMLOGICPORT: SRN=0, SN=14, LPNTYPE=Leaf, BT=UOIa, LPN=20, CARRYT=NCOPT, CARRYPN=0, TXBW=5712, RXBW=5712, RSCMNGMODE=EXCLUSIVE, CNOPINDEX=0, FLOWCTRLSWITCH=ON, FCINDEX=1, TRMLOADTHINDEX=0;

Add

ATM traffic records.

ADD ATMTRF: TRFX=100, ST= CBR, UT=KBIT/S, PCR=240, CDVT=1024, REMARK="for Iub NCP "; ADD ATMTRF: TRFX=101, ST= CBR, UT=KBIT/S, PCR=680, CDVT=1024, REMARK="for Iub CCP "; ADD ATMTRF: TRFX=102, ST= CBR, UT=KBIT/S, PCR=104, CDVT=1024, REMARK="for Iub ALCAP "; ADD ATMTRF: TRFX=120, ST=RTVBR, UT=KBIT/S, PCR=1915, SCR=1741, MBS=1000, CDVT=1024, REMARK="for Iub R99 RT"; ADD ATMTRF: TRFX=121, ST=NRTVBR, UT=KBIT/S, PCR=5712, SCR=5288, MBS=1000, CDVT=1024, REMARK="for Iub R99 NRT"; ADD ATMTRF: TRFX=122, ST=UBR, UT=KBIT/S, PCR=5712, CDVT=1024, REMARK="for Iub H_NRT";

II. Data Configuration on the Control Plane

At

least, add three SAAL links; one is used to transmit the NCP data; one is used to transmit the CCP data; the last one is used to transmit the ALCAP data. ADD SAALLNK: SRN=0, SN=0, SAALLNKN=1, CARRYT=NCOPT, CARRYSRN=0, CARRYSN=14, CARRYNCOPTN=0, CARRYVPI=10, CARRYVCI=34, TXTRFX=100, RXTRFX=100, SAALLNKT=UNI; // This link is used to transmit the NCP data. ADD SAALLNK: SRN=0, SN=0, SAALLNKN=2, CARRYT=NCOPT, CARRYSRN=0, CARRYSN=14, CARRYNCOPTN=0, CARRYVPI=10, CARRYVCI=35, TXTRFX=101, RXTRFX=101, SAALLNKT=UNI; // This link is used to transmit the CCP data. ADD SAALLNK: SRN=0, SN=0, SAALLNKN=3, CARRYT=NCOPT, CARRYSRN=0, CARRYSN=14, CARRYNCOPTN=0, CARRYVPI=10, CARRYVCI=36, TXTRFX=102, RXTRFX=102, SAALLNKT=UNI; // This link is used to transmit the ALCAP data.

Add

a NodeB and algorithm parameters (data on the control plane).

ADD UNODEB: NodeBName="RNC8-BBU1", NodeBId=1, SRN=0, SN=0, TnlBearerType=ATMANDIP_TRANS, IPTRANSAPARTIND=NOT_SUPPORT, HostType=SINGLEHOST, SharingType=DEDICATED, CnOpIndex=0; // Note that the ATM address of the NodeB is not configured on the RAN12. ADD UNODEBALGOPARA: NodeBName="RNC8-BBU1", NodeBLdcAlgoSwitch=IUB_LDR-1&NODEB_CREDIT_LDR-1; // The algorithm switch is configured based on the data planning of the radio layer. Its necessary to configure the corresponding parameter to the algorithm switch if turn it on.
Add

an adjacent node (data on the control plane).

ADD ADJNODE: ANI=10, NAME=" NODEB1", NODET=IUB, NODEBID=1, TRANST=ATM_IP, IsROOTNODE=YES, SAALLNKN=3;
Add

links on the NodeB control port (data on the control plane).

ADD UNCP: NodeBName=" RNC8-BBU1", CARRYLNKT=SAAL, SAALLNKN=1; ADD UCCP: NodeBName=" RNC8-BBU1", PN=0, CARRYLNKT= SAAL, SAALLNKN=2;

III. Mapping Between Transmission Resources and Configuration of the Activation


Factor Table
Add

the mapping between transmission resources to map services of different QoS requirements to different AAL2 paths or IP paths. When the dual stack transport is applied to the Iub interface, TRMMP ID is set to 2 by default. If the default mapping cannot meet the requirements, you can use the ADD TRMMAP command to add a TRMMP ID. In this example, the default mapping is used.

You can run the LST TRMMAP command to query the default settings. TRMMAP(Iub) Service Type Common channel IMS SRB SRB AMR voice R99 CS conversational R99 CS streaming R99 PS conversational R99 PS streaming Default Primary RT_VBR RT_VBR RT_VBR RT_VBR RT_VBR RT_VBR RT_VBR RT_VBR Secondary EF EF EF EF AF43 AF43 AF43 AF43

R99 PS high PRI interactive R99 PS middle PRI interactive R99 PS low PRI interactive R99 PS background HSDPA Signal HSDPA IMS Signal HSDPA Voice HSDPA conversational HSDPA streaming HSDPA high PRI interactive HSDPA middle PRI interactive HSDPA low PRI interactive HSDPA background HSUPA Signal HSUPA IMS Signal HSUPA Voice HSUPA conversational HSUPA streaming HSUPA high PRI interactive HSUPA middle PRI interactive HSUPA low PRI interactive HSUPA background
Add

NRT_VBR NRT_VBR NRT_VBR NRT_VBR RT_VBR RT_VBR RT_VBR RT_VBR RT_VBR AF13 AF13 AF13 AF13 RT_VBR RT_VBR RT_VBR RT_VBR RT_VBR AF13 AF13 AF13 AF13

AF23 AF23 AF23 AF23 EF EF AF43 AF43 AF43 UBR UBR UBR UBR EF EF AF43 AF43 AF43 UBR UBR UBR UBR

an activation factor table to specify proper factors for each traffic class. Through this task, the transmission resources can be multiplexed. By default, Factor Table Index is set to 0. If the default mapping cannot meet the requirements, you can use the ADD TRMFACTOR command to add an index. See section 4.2.4 . the threshold table for load balancing between active and standby paths. You can run the LST LOADEQ command (LOADEQ ID = 0) to obtain the default threshold table. If the default mapping cannot meet the requirement, you can run the ADD LOADEQ command to add an index.

Configure

In this example, the default mapping is used. Generally, the active path is preferred to carry the load. If the following conditions are met, the standby path is recommended. The load on the active path is greater than the load threshold of this path. The load on the active path times the threshold for the ratio of the load on the active path to the load on the standby path is greater than the load on the standby path. Default Threshold for the Ratio of

Service Type Common channel IMS SRB SRB AMR voice R99 CS conversational R99 CS streaming R99 PS conversational R99 PS streaming R99 PS high PRI interactive R99 PS middle PRI interactive R99 PS low PRI interactive R99 PS background HSDPA Signal HSDPA IMS Signal HSDPA Voice HSDPA conversational HSDPA streaming HSDPA high PRI interactive HSDPA middle PRI interactive HSDPA low PRI interactive HSDPA background HSUPA Signal HSUPA IMS Signal HSUPA Voice HSUPA conversational HSUPA streaming HSUPA high PRI interactive HSUPA middle PRI interactive HSUPA low PRI interactive HSUPA background
Configure

Load Threshold of the Active Path (%) 100 100 100 100 100 100 100 100 30 30 30 30 100 100 100 100 100 30 30 30 30 100 100 100 100 100 30 30 30 30

the Load on the Active Path to the Load on the Standby Path (%) 0 0 0 0 0 0 0 0 100 100 100 100 0 0 0 0 0 100 100 100 100 0 0 0 0 0 100 100 100 100

the TRM mapping on the adjacent node. You can run the ADD TRMMAP command to add the TRMMAP ID for the gold, silver, and bronze users. ADD ADJMAP: ANI=10, ITFT=IUB, TRANST=ATM_IP, CNMNGMODE=EXCLUSIVE, CNOPINDEX=0, TMIGLD=2, TMISLV=2, TMIBRZ=2, FTI=0, LEIGLD=0, LEISLV=0, LEIBRZ=0;

IV. Data Configuration on the User Plane


Configure

the IP route to the interface IP address of the NodeB on the Iub interface of the GOUa of the RNC.

According to the planning on site, you can configure either the host route (the subnet mask of the destination IP address is 255.255.255.255) or the network segment route (the destination IP address is the network address and the subnet mask cannot be 255.255.255.255). ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.40", DSTMASK="255.255.255.255", NEXTHOP="10.10.10.2", PRIORITY=HIGH, REMARK="RNC INT To NodeB1"; // Configure the host route to the interface IP address of NodeB1.
Add

the AAL2 path to the NodeB.

ADD AAL2PATH: ANI=10, PATHID=1, CARRYT=ATMLOGICPORT, CARRYF=0, CARRYSN=14, CARRYVPN=20, VPI=10, VCI=40, TXTRFX=120, RXTRFX=120, AAL2PATHT=SHARE; ADD AAL2PATH: ANI=10, PATHID=2, CARRYT=ATMLOGICPORT, CARRYF=0, CARRYSN=14, CARRYVPN=20, VPI=10, VCI=41, TXTRFX=120, RXTRFX=120, AAL2PATHT=SHARE; ADD AAL2PATH: ANI=10, PATHID=3, CARRYT=ATMLOGICPORT, CARRYF=0, CARRYSN=14, CARRYVPN=20, VPI=10, VCI=42, TXTRFX=120, RXTRFX=120, AAL2PATHT=SHARE; ADD AAL2PATH: ANI=10, PATHID=4, CARRYT=ATMLOGICPORT, CARRYF=0, CARRYSN=14, CARRYVPN=20, VPI=10, VCI=43, TXTRFX=121, RXTRFX=121, AAL2PATHT=SHARE; ADD AAL2PATH: ANI=10, PATHID=5, CARRYT=ATMLOGICPORT, CARRYF=0, CARRYSN=14, CARRYVPN=20, VPI=10, VCI=44, TXTRFX=122, RXTRFX=122, AAL2PATHT=SHARE;
Add

the IP path to the NodeB.

ADD IPPATH: ANI=10, PATHID=1, ITFT=IUB, TRANST=ATM_IP, PATHT=EF, IPADDR="20.20.20.20", PEERIPADDR="40.40.40.40", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.40"; // When the path type is EF, the DSCP value is 46. ADD IPPATH: ANI=10, PATHID=2, ITFT=IUB, TRANST=ATM_IP, PATHT=AF43, IPADDR="20.20.20.20", PEERIPADDR="40.40.40.40", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.40"; // When the path type is AF43, the DSCP value is 38. ADD IPPATH: ANI=10, PATHID=3, ITFT=IUB, TRANST=ATM_IP, PATHT=AF23, IPADDR="20.20.20.20", PEERIPADDR="40.40.40.40", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.40"; // When the path type is AF23, the DSCP value is 22. ADD IPPATH: ANI=10, PATHID=4, ITFT=IUB, TRANST=ATM_IP, PATHT=AF13, IPADDR="20.20.20.20", PEERIPADDR="40.40.40.40", PEERMASK="255.255.255.255", TXBW=40000, RXBW=40000, CARRYFLAG=IPLGCPORT, LPNSN=18, LPN=10, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.40"; // When the path type is AF13, the DSCP value is 14.

V. VLAN/VLAN Priority/DSCP Configuration


VLAN

Configuration

IP

over Ethernet: If the RNC directly connects to the router in layer 3 networking, the VLAN ID is not configured on the RNC. If the VLAN ID needs to be configured on the RNC, run the ADD VLANID command to add the VLAN ID for the next hop (VRRP Virtual IP) of the RNC. over SDH: The VLAN is not configured. Configuration

IP

Note: The VLAN needs to be configured on the intermediate transmission device.


DSCP

According to the planning of the existing network, see section 3.4 for DSCP values of various services. Note: DSCP values need to be configured on the intermediate transmission device.
VLAN

Priority Configuration

IP Over Ethernet: If the RNC directly connects to the router in layer 3 networking, the VLAN ID is not configured on the RNC. Then, the VLAN priorities are not configured. If VLAN priorities need to be configured on the RNC, see section 3.5 according to the planning of the existing network. Note: VLAN priorities need to be configured on the intermediate transmission devices.

4.5.5 Data Configuration on the NodeB


Note During the deployment on site, the data on the NodeB is configured by using the CME. For clear configuration description, here only describes the configuration related to MML commands. The contents in blue in the following MML commands need to be planned or negotiated.

I. Data Configuration on the Physical Layer and Data Link Layer


Set

the attributes of the Ethernet ports. Ensure that the Ethernet port attributes are consistent on both ends. The MTU value on the NodeB needs to be smaller or equal to that of the intermediate transmission device. See section 3.2 .

SET ETHPORT: SRN=0, SN=6, SBT=BASE_BOARD, PN=0, MTU=1500, SPEED=100M, DUPLEX=FULL, ARPPROXY=DISABLE; // If the interface IP address of the NodeB is on the same network segment as that of the OM IP address, set ARP Proxy to Enable. Add the IP address of the Ethernet port. The IP address of the FE port on the NodeB is 40.40.40.40/24. ADD DEVIP: SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, PN=0, IP="40.40.40.40", MASK="255.255.255.0";
Set

the bearer mode of the E1/T1 cables to IPV4. Then, reset the transmission interface board. SET E1T1BEAR: SRN=0, SN=6, MODE=ATM, IMPEDANCE=75; attributes of the E1 cables on the WMPT. Ensure that the attribute values are consistent on both ends. You can run the DSP E1T1WORKMODE command to query the attribute values. SET E1T1WORKMODE: SRN=0, SN=6, SBT=BASE_BOARD, FRAME=E1_CRC4_MULTI_FRAME, LNCODE=HDB3, CLKM=MASTER;

Set

Add

IMA groups and IMA links. Ensure that the settings are consistent on both ends.

ADD IMAGRP: SRN=0, SN=6, SBT=BASE_BOARD, VER=V1.1, CLKM=ITC, FRMLEN=D128, SCRAM=ENABLE; ADD IMALNK: CN=0, SRN=0, SN=6, SBT=BASE_BOARD, IMALNKN=0, IMAGRPSBT=BASE_BOARD, IMAGRPN=0; ADD IMALNK: CN=0, SRN=0, SN=6, SBT=BASE_BOARD, IMALNKN=1, IMAGRPSBT=BASE_BOARD, IMAGRPN=0; ADD IMALNK: CN=0, SRN=0, SN=6, SBT=BASE_BOARD, IMALNKN=2, IMAGRPSBT=BASE_BOARD, IMAGRPN=0;

II. Data Configuration on the Control Plane


At

least, add three SAAL links; one is used to transmit the NCP data; one is used to transmit the CCP data; the last one is used to transmit the ALCAP data. ADD SAALLNK: SAALNO=0, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=IMA, PN=0, JNRSCGRP=DISABLE, VPI=1, VCI=34, RU=KBPS, ST=CBR, PCR=240; // This link is used to transmit the NCP data. ADD SAALLNK: SAALNO=1, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=IMA, PN=0, JNRSCGRP=DISABLE, VPI=1, VCI=35, RU=KBPS, ST=CBR, PCR=680; // This link is used to transmit the CCP data. ADD SAALLNK: SAALNO=2, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=IMA, PN=0, JNRSCGRP=DISABLE, VPI=1, VCI=36, RU=KBPS, ST=CBR, PCR=104; // This link is used to transmit the ALCAP data.

Add

links on the NodeB control port.

ADD IUBCP: CPPT=NCP, BEAR=ATM, LN=1; ADD IUBCP: CPPT=CCP, CPPN=0, BEAR=ATM, LN=2;

III. Data Configuration on the User Plane


Add

AAL2 paths.

ADD AAL2PATH: NT=LOCAL, PATHID=1, SRN=0, SN=6, SBT=BASE_BOARD, PT=IMA, PN=0, JNRSCGRP=DISABLE, VPI=1, VCI=40, RU=KBPS, ST=RTVBR, PCR=1915, SCR=1741, MBS=1000, CDVT=10240, RCR=1741; ADD AAL2PATH: NT=LOCAL, PATHID=2, SRN=0, SN=6, SBT=BASE_BOARD, PT=IMA, PN=0, JNRSCGRP=DISABLE, VPI=1, VCI=41, RU=KBPS, ST=RTVBR, PCR=1915, SCR=1741, MBS=1000, CDVT=10240, RCR=1741; ADD AAL2PATH: NT=LOCAL, PATHID=3, SRN=0, SN=6, SBT=BASE_BOARD, PT=IMA, PN=0, JNRSCGRP=DISABLE, VPI=1, VCI=42, RU=KBPS, ST=RTVBR, PCR=1915, SCR=1741, MBS=1000, CDVT=10240, RCR=1741; ADD AAL2PATH: NT=LOCAL, PATHID=4, SRN=0, SN=6, SBT=BASE_BOARD, PT=IMA, PN=0, JNRSCGRP=DISABLE, VPI=1, VCI=43, RU=KBPS, ST=NRTVBR, PCR=5712, SCR=5288, MBS=1000, CDVT=10240, RCR=5288; ADD AAL2PATH: NT=LOCAL, PATHID=5, SRN=0, SN=6, SBT=BASE_BOARD, PT=IMA, PN=0, JNRSCGRP=DISABLE, VPI=1, VCI=44, RU=KBPS, ST=UBR, PCR=5712, RCR=5508;
Add

four IP paths with different priorities. Ensure that the configuration is consistent with that on the RNC. The ping detection switch on the IP path on the NodeB is disabled. ADD IPPATH: PATHID=1, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="40.40.40.40", RNCIP="20.20.20.20", DSCP=46, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=2, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH,

JNRSCGRP=DISABLE, NODEBIP="40.40.40.40", RNCIP="20.20.20.20", DSCP=38, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=3, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="40.40.40.40", RNCIP="20.20.20.20", DSCP=22, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE; ADD IPPATH: PATHID=4, CN=0, SRN=0, SN=6, SBT=BASE_BOARD, PT=ETH, JNRSCGRP=DISABLE, NODEBIP="40.40.40.40", RNCIP="20.20.20.20", DSCP=14, RXBW=40000, TXBW=40000, TXCBS=10000000, TXEBS=0, FPMUXSWITCH=DISABLE;

IV. VLAN/VLAN Priority/DSCP Configuration


VLAN IP

Configuration

path

In layer 3 networking, the NodeB may first connect to a layer 2 network. In this case, the VLAN ID is configured on the NodeB. In this example, set the VLAN ID to 200 on the NodeB. ADD VLANMAP: NEXTHOPIP="40.40.40.39", VLANMODE=VLANGROUP, VLANGROUPNO=0; // Configure a VLAN group to the network gateway on the NodeB. For the specific VLAN ID setting, see section 3.3.2 3.3.7 . Note: The VLAN needs to be configured on the intermediate transmission device. DSCP Configuration According to the planning of the existing network, see section 3.4 for DSCP values of various services. Note: DSCP values need to be configured on the intermediate transmission device. VLAN Priority Configuration 1.IP path According to the planning of the existing network, see section 3.5 for VLAN priorities of various services. Note: VLAN priorities need to be configured on the intermediate transmission devices.

V. IP Route Configuration
According to the planning on site, you can configure either the host route (the subnet mask of the destination IP address is 255.255.255.255) or the network segment route (the destination IP address is the network address and the subnet mask cannot be 255.255.255.255).
Configure

the IP route to the device IP address of the RNC on the WMPT of the

NodeB. ADD IPRT: SRN=0, SN=6, SBT=BASE_BOARD, DSTIP="20.20.20.20", DSTMASK="255.255.255.255", RTTYPE=NEXTHOP, NEXTHOP="40.40.40.39"; // Configure the host route to the device IP address of the RNC for the device IP address serve as the IP address for the traffic on the RNC in this example.
Configure

the IP route to the Ethernet port of the RNC on the WMPT of the NodeB. It is optional. To facilitate the commissioning, the route needs to be configured when you need to ping the IP address of the Ethernet port on the RNC from the NodeB.

ADD IPRT: SRN=0, SN=6, SBT=BASE_BOARD, DSTIP="10.10.10.1", DSTMASK="255.255.255.255", RTTYPE=NEXTHOP, NEXTHOP="40.40.40.39"; // Configure the host route to the interface IP address of RNC.

5
5.1 Description
Configuration For The

IUPS Configuration Example

examples are based on RNC V900R012 and NodeB V200R12.

configuration details, refer to the Initial Configuration Guide and the corresponding MML online help. networking of configuration examples is only for reference. The networking of each site needs to be designed and deployed according to the actual situations.

5.2 Typical Configuration of IP Layer 3 Networking Based on the Data Network


5.2.1 Networking Diagram

5.2.2 Preparations
Cables

are properly connected and intermediate transmission devices are ready.

The

data planning is completed.

5.2.3 Data Planning of IP Layer 3 Networking 5.2.4 Data Planning of Layer 3 Networking
I. Data Planning in the Physical Layer and Data Link Layer
Data Item Data on the FE port Interface board type IP address of the network gateway Whether to back up/Backup mode Subrack No./slot No./port No. IP address of the FE port/subnet mask IP address for the traffic Data on the IP logic port CP_IP1 CP_IP2 UP_IP1 IP logic port No. Bandwidth of the IP logic port Dynamic bandwidth adjustment switch RNC GOUa 10.10.10.2/24 Yes/Board backup+port backup 0/18/0 10.10.10.1/24 20.20.20.20/32 20.20.20.30/32 20.20.20.40/32 OFF SGSN Data Source Internal planning Network planning Internal planning

40.40.40.40/32 40.40.40.50/32 40.40.40.60/32 Network planning

II. Data Planning of the Control Plane


Data Item SCTP0 Local SCTP port No. Working mode of the SCTP link Subrack No./slot No. of the SPU DSCP Local IP address 1 Local IP address 2 Whether to bind the IP logic port/slot No. and port No. of the logic port Whether to add the VLAN/VLAN ID SCTP1 Local SCTP port No. Working mode of the SCTP link Subrack No./slot No. of the SPU DSCP RNC 8525 Client 0/2 48 20.20.20.20/32 20.20.20.30/32 NO SGSN 8625 Server 48 40.40.40.40/32 40.40.40.50/32 Data Source Data to be negotiated

NO 8526 Client 0/4 48

8626 Server 48

Local IP address 1 Local IP address 2 Whether to bind the IP logic port/slot No. and port No. of the logic port Whether to add the VLAN/VLAN ID M3UA Type of the local entity Context of the local entity route Working mode Working mode

20.20.20.20/32 20.20.20.30/32 NO

40.40.40.40/32 40.40.40.50/32

NO M3UA_IPSP 4294967295 Load sharing M3UA_IPSP

M3UA_IPSP 4294967295 Load sharing M3UA_IPSP Data to be negotiated

III. Data Planning of the User Plane


Data Item Adjacent node ID Transport type of the IUPS interface One IP path Port type IP path ID Path type Whether to bind the IP logic port/slot No. and port No. of the logic port Local IP address/subnet mask Whether to enable the VLAN/enabled VLAN ID Path detection flag Detected IP address TX bandwidth (kbps) RX bandwidth (kbps) Whether to enable the FPMUX RNC 10 IP ETH 0 QoS NO SGSN ETH Data Source Internal planning Data to be negotiated

20.20.20.40/32 NO ENABLE 40.40.40.60/24 1000000 1000000 NO

40.40.40.60/24 1000000 1000000 NO

Network planning Network planning

5.2.5 Data Configuration on the RNC


I. Data Configuration on the Physical Layer and Data Link Layer
Configure

the backup information of the interface board according to the networking situation on site. ADD BRD: SRN=0, BRDCLASS=INT, BRDTYPE=GOUa, SN=18, RED=YES, MPUSUBRACK=0, MPUSLOT=0; // Set the GOUa board in slot 18 of subrack 0 and GOUa board in slot 19 to work in active/standby mode.

Configure

the backup information of the ports on the interface board according to the networking situation on site. ADD ETHREDPORT: SRN=0, SN=18, PN=0; // Set Port 0 on the GOUa in slot 18 of subrack 0 and port 0 on the GOUa in slot 19 to work in active/standby mode.

Set

the attributes of the Ethernet ports. Ensure that the Ethernet port attributes are consistent on both ends. The MTU value on the RNC needs to be smaller or equal to that of the intermediate transmission device. See section 3.2 . SET ETHPORT: SRN=0, SN=18, BRDTYPE=GOUa, PN=0, AUTO=ENABLE, MTU=1500, OAMFLOWBW=0, FLOWCTRLSWITCH=ON, FCINDEX=1;

Major parameters are described as follows: AUTO Auto negotiation or not Description: This parameter setting on the RNC must be consistent with that on the peer device through negotiation. That is, if this parameter is set to auto negotiation on the peer device, the parameter on the port of the RNC is also set to auto negotiation; otherwise, it is set to non-auto negotiation. Description: Generally, the transmission rate over the FE port is 100 Mbit/s or 1000 Mbit/s. Description: Half duplex indicates that the data packets cannot be transmitted during the receiving of data packets; full duplex indicates that the data packets can be transmitted and received at the same time. Generally, the working mode is set to full duplex.

SPEED

Transmission rate over the port Working mode

DUPLEX

Run

the following command to add the IP address of the Ethernet port. The IP address is planned by the operator. ADD ETHIP: SRN=0, SN=18, PN=0, IPINDEX=0, IPADDR="10.10.10.1", MASK="255.255.255.0"; // The IP address of the interface board on the RNC is 10.10.10.1/24.

Add

the device IP address of the interface board (optional). The IP address is planned by the operator. ADD DEVIP: SRN=0, SN=18, DEVTYPE=LOGIC_IP, IPADDR="20.20.20.20"; // Add logic IP address 1 20.20.20.20 on the interface board in slot 18 to be local IP address 1 of SCTP. The default subnet mask 255.255.255.255 is adopted. ADD DEVIP: SRN=0, SN=18, DEVTYPE=LOGIC_IP, IPADDR="20.20.20.30"; // Add logic IP address 1 20.20.20.30 on the interface board in slot 18 to be local IP address 2 of SCTP. The default subnet mask 255.255.255.255 is adopted. ADD DEVIP: SRN=0, SN=18, DEVTYPE=LOGIC_IP, IPADDR="20.20.20.40"; // Add logic IP address 1 20.20.20.40 on the interface board in slot 18 to be local IP address 1 of the GTPU. The default subnet mask 255.255.255.255 is adopted.

II. Data Configuration on the Control Plane


The general configuration procedure is as follows: (OPC --> N7DPC )--> M3LE --> M3DE --> M3LKS --> M3RT --> M3LNK
Add

SCTP signaling links. Set Signaling link mode to CLIENT or SERVER. Generally, the SGSN serves as the server, whereas the RNC acts as the client. Set Application type to M3UA. The port No. must be consistent on both ends. In this example, configure the SCTP dual homing. ADD SCTPLNK: SRN=0, SN=2, SCTPLNKN=0, MODE=CLIENT, APP=M3UA,

DSCP=48, LOCPN=8525, LOCIP1="20.20.20.20", LOCIP2="20.20.20.30", PEERIP1="40.40.40.40", PEERIP2="40.40.40.50", PEERPN=8625, LOGPORTFLAG=NO, MTU=800, VLANFLAG1=DISABLE, VLANFlAG2=DISABLE, SWITCHBACKFLAG=YES; ADD SCTPLNK: SRN=0, SN=4, SCTPLNKN=1, MODE=CLIENT, APP=M3UA, DSCP=48, LOCPN=8526, LOCIP1="20.20.20.20", LOCIP2="20.20.20.30", PEERIP1="40.40.40.40", PEERIP2="40.40.40.50", PEERPN=8626, LOGPORTFLAG=NO, MTU=800, VLANFLAG1=DISABLE, VLANFlAG2=DISABLE, SWITCHBACKFLAG=YES;
According

to the planning on site, you can configure either the host route (the subnet mask of the destination IP address is 255.255.255.255) or the network segment route (the destination IP address is the network address and the subnet mask cannot be 255.255.255.255). ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.40", DSTMASK="255.255.255.255", NEXTHOP=""10.10.10.2", PRIORITY=HIGH, REMARK=" To SGSN1_CP1"; ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.50", DSTMASK="255.255.255.255", NEXTHOP=""10.10.10.2", PRIORITY=HIGH, REMARK=" To SGSN1_CP2";

Add

a destination signaling point.

ADD N7DPC: NAME="SGSN1", DPX=3, SPX=0, SPDF=WNF, DPC= H'000515, DPCT=IUPS, SLSMASK=B0000, NEIGHBOR=YES, STP=OFF, BEARTYPE=M3UA, PROT=ITUT;
Add

a local M3UA entity.

ADD M3LE: LENO=0, SPX=0, ENTITYT=M3UA_IPSP, RTCONTEXT=4294967295, NAME=" RNC12";


Add

an M3UA destination entity. If the negotiation is required by the peer end, set the route context of the destination entity according to the route context provided by the peer end. ADD M3DE: DENO=3, LENO=0, DPX=3, ENTITYT=M3UA_IPSP, RTCONTEXT=4294967295, NAME=" SGSN1";

Add

an M3UA link set. To implement load sharing among M3UA links, it is recommended to set Signaling link mask to B0111. Settings of Work mode and Traffic mode need to be consistent on both ends. ADD M3LKS: SIGLKSX=3, DENO=3, LNKSLSMASK=B1111, TRAMODE=M3UA_LOADSHARE_MOD, WKMODE=M3UA_IPSP, NAME=" SGSN1"; Note: If signaling routes need to work in load sharing mode, set Signaling route mask to B1000 in the ADD N7DPC command and set Signaling link mask to B0111 in the ADD M3LKS command because the result of the AND operation of the two settings must be 0.

Add

an M3UA route. M3UA links.

ADD M3RT: DENO=3, SIGLKSX=3, PRIORITY=0, NAME=" to SGSN1";


Add

ADD M3LNK: SIGLKSX=3, SIGLNKID=0, SRN=0, SN=2, SCTPLNKN=0, PRIORITY=0, LNKREDFLAG=M3UA_MASTER_MOD, NAME=" to SGSN1_0"; ADD M3LNK: SIGLKSX=3, SIGLNKID=1, SRN=0, SN=4, SCTPLNKN=1, PRIORITY=0, LNKREDFLAG=M3UA_MASTER_MOD, NAME=" to SGSN1_1";
Add

a transport adjacent node. Set Adjacent Node Type to IUPS and Transport Type to IP. ADD ADJNODE: ANI=3, NAME=" SGSN1", NODET=IUPS, SGSNFLG=YES, TRANST=IP, DPX=3;

Add

a CN domain. Set CN domain ID to PS_DOMAIN (PS domain).

ADD UCNDOMAIN: CNDomainId=PS_DOMAIN, NMO=MODE2, DRXCycleLenCoef=6;


Add

a CN node. Set CN domain ID to PS_DOMAIN (PS domain) and Iu transfers bearer type to IP_TRANS (IP transport). ADD UCNNODE: CnOpIndex=0, CNId=1, CNDomainId=PS_DOMAIN, Dpx=3, CNProtclVer=R6, CNLoadStatus=NORMAL, AvailCap=65535, TnlBearerType=IP_TRANS;

III. Mapping Between Transmission Resources and Configuration of the Activation


Factor Table
Add

the mapping between transmission resources to map services of different QoS requirements to different IP paths. For the IUPS transport, TRMMP ID is set to 8 by default. If the default mapping cannot meet the requirements, you can use the ADD TRMMAP command to add a TRMMP ID.

You can run the LST TRMMAP command to query the default settings. TRMMAP(IuPS) Service Type Common channel IMS SRB SRB AMR voice R99 CS conversational R99 CS streaming R99 PS conversational R99 PS streaming R99 PS high PRI interactive R99 PS middle PRI interactive R99 PS low PRI interactive R99 PS background
Add

Default Primary NULL EF NULL NULL NULL NULL AF43 AF43 AF23 AF23 AF23 AF23 Secondary NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL

an activation factor table to specify proper factors for each traffic class. Through this task, the transmission resources can be multiplexed. By default, Factor Table Index is set to 0. If the default mapping cannot meet the requirements, you can use the ADD TRMFACTOR command to add an index. See section 4.2.4 . the TRM mapping on the adjacent node. You can run the ADD TRMMAP command to add the TRMMAP ID for the gold, silver, and bronze users. ADD ADJMAP: ANI=3, ITFT=IUPS, TMIGLD=8, TMISLV=8, TMIBRZ=8, FTI= 0; // In this example, both TMI and FTI use default values.

Configure

IV. Data Configuration on the User Plane


Add

an IP path. The traffic unit is kbps. PHBs corresponding to various services on the IUPS can be obtained by using the LST TRMMAP command. DSCP values

corresponding to PHBs can be obtained by using the LST PHBMAP command. ADD IPPATH: ANI=3, PATHID=0, ITFT=IUPS, PATHT=QoS, IPADDR="20.20.20.40", PEERIPADDR="40.40.40.60", PEERMASK="255.255.255.255", TXBW=1000000, RXBW=1000000, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.60"; // If more than one GTPU address is available on the peer end, you need to configure multiple IP addresses.
Configure

routes on the user plane. It is optional. According to the planning on site, you can configure either the host route (the subnet mask of the destination IP address is 255.255.255.255) or the network segment route (the destination IP address is the network address and the subnet mask cannot be 255.255.255.255). ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.60", DSTMASK="255.255.255.255", NEXTHOP=""10.10.10.2", PRIORITY=HIGH, REMARK=" To SGSN1_UP";

V. VLAN/VLAN Priority/DSCP Configuration


VLAN

Configuration

If the RNC directly connects to the router in layer 3 networking, the VLAN ID is not configured on the RNC. If the VLAN ID needs to be configured on the RNC, run the ADD VLANID command to add the VLAN ID on the next hop (VRRP Virtual IP) of the RNC. Note: The VLAN needs to be configured on the intermediate transmission device.
DSCP

Configuration

According to the planning of the existing network, see section 3.4.1 for DSCP values on the signaling plane. According to the planning of the existing network, run the ADD TRMMAP command to set the PHB of the IUPS to QoS during the setting of DSCP values. Then, run the SET PHBMAP command to set the mapping between the PHB and the DSCP value. Note: DSCP values need to be configured on the intermediate transmission device.
VLAN

Priority Configuration

If the RNC directly connects to the router in layer 3 networking, the VLAN ID is not configured on the RNC. Then, the VLAN priorities are not configured. After DSCP values are set for various services on the user plane, run the SET DSCPMAP command to set the mapping between DSCP values and VLAN priorities. For the detailed configuration of VLAN priorities of other services, see section 3.5 . Note: VLAN priorities need to be configured on the intermediate transmission devices.

6
6.1 Description
Configuration For The

IUCS Configuration Example

examples are based on RNC V900R012 and NodeB V200R12.

configuration details, refer to the Initial Configuration Guide and the corresponding MML online help. networking of configuration examples is only for reference. The networking of each site needs to be designed and deployed according to the actual situations.

6.2 Typical Configuration of IP Layer 3 Networking Based on the Data Network


6.2.1 Networking Diagram

6.2.2 Preparations
Cables The

are properly connected and intermediate transmission devices are ready.

data planning is completed.

6.2.3 Data Planning of IP Layer 3 Networking


I. Data Planning in the Physical Layer and Data Link Layer
Data Item Data on the FE port Interface board type IP address of the network gateway Whether to back up/Backup mode Subrack No./slot No./port No. IP address of the FE port/subnet mask IP address for the traffic Data on the IP logic port CP_IP1 CP_IP2 UP_IP1 IP logic port No. Bandwidth of the IP logic port Dynamic bandwidth adjustment switch RNC GOUa 10.10.10.2/24 Yes/Board backup+port backup 0/18/0 10.10.10.1/24 20.20.20.20/32 20.20.20.30/32 20.20.20.40/32 OFF MGW/MSC Server Data Source Internal planning Network planning Internal planning

40.40.40.40/32 40.40.40.50/32 40.40.40.60/32 Network planning

II. Data Planning of the Control Plane


Data Item SCTP0 Local SCTP port No. Working mode of the SCTP link Subrack No./slot No. of the SPU DSCP Local IP address 1 Local IP address 2 Whether to bind the IP logic port/slot No. and port No. of the logic port Whether to add the VLAN/VALN ID SCTP1 Local SCTP port No. Working mode of the SCTP link Subrack No./slot No. of the RNC 5000 Client 0/2 48 20.20.20.20/32 20.20.20.30/32 NO MSC Server 5100 Server 48 40.40.40.40/32 40.40.40.50/32 Data Source Data to be negotiated

NO 5002 Client 0/4

5102 Server

SPU DSCP Local IP address 1 Local IP address 2 Whether to bind the IP logic port/slot No. and port No. of the logic port Whether to add the VLAN/VALN ID M3UA Type of the local entity Context of the local entity route Working mode Working mode 48 20.20.20.20/32 20.20.20.30/32 NO 48 40.40.40.40/32 40.40.40.50/32

NO M3UA_IPSP 4294967295 Load sharing M3UA_IPSP

M3UA_IPSP 4294967295 Load sharing M3UA_IPSP Data to be negotiated

III. Data Planning of the User Plane


Data Item Adjacent node ID Transport type of the IUCS interface Two IP paths Port type IP path ID PATH type Whether to bind the IP logic port/slot No. and port No. of the logic port Local IP address/subnet mask Whether to enable the VLAN/enabled VLAN ID Path detection flag Detected IP address TX bandwidth (kbps) RX bandwidth (kbps) Whether to enable the FPMUX RNC 10 IP ETH 0/1 EF/AF43 NO MGW ETH Data Source Internal planning Data to be negotiated

20.20.20.40/32 NO ENABLE 40.40.40.60/24 1000000 1000000 NO

40.40.40.60/24 1000000 1000000 NO

Network planning

Network planning

6.2.4 Data Configuration on the RNC


I. Data Configuration on the Physical Layer and Data Link Layer
Configure

the backup information of the interface board according to the networking situation on site. ADD BRD: SRN=0, BRDCLASS=INT, BRDTYPE=GOUa, SN=18, RED=YES, MPUSUBRACK=0, MPUSLOT=0; // Set the GOUa board in slot 18 of subrack 0 and

GOUa board in slot 19 to work in active/standby mode.


Configure

the backup information of the ports on the interface board according to the networking situation on site. ADD ETHREDPORT: SRN=0, SN=18, PN=0; // Set port 0 on the GOUa in slot 18 of subrack 0 and port 0 on the GOUa in slot 19 to work in active/standby mode.

Set

the attributes of the Ethernet ports. Ensure that the Ethernet port attributes are consistent on both ends. The MTU value on the RNC needs to be smaller or equal to that of the intermediate transmission device. See section 3.2 . SET ETHPORT: SRN=0, SN=18, BRDTYPE=GOUa, PN=0, AUTO=ENABLE, MTU=1500, OAMFLOWBW=0, FLOWCTRLSWITCH=ON, FCINDEX=1;

Major parameters are described as follows: AUTO Auto negotiation or not Description: This parameter setting on the RNC must be consistent with that on the peer device through negotiation. That is, if this parameter is set to auto negotiation on the peer device, the parameter on the port of the RNC is also set to auto negotiation; otherwise, it is set to non-auto negotiation. Description: Generally, the transmission rate over the FE port is 100 Mbit/s or 1000 Mbit/s. Description: Half duplex indicates that the data packets cannot be transmitted during the receiving of data packets; full duplex indicates that the data packets can be transmitted and received at the same time. Generally, the working mode is set to full duplex.

SPEED

Transmission rate over the port Working mode

DUPLEX

Run

the following command to add the IP address of the Ethernet port. The IP address is planned by the operator. ADD ETHIP: SRN=0, SN=18, PN=0, IPINDEX=0, IPADDR="10.10.10.1", MASK="255.255.255.0"; // The IP address of the interface board on the RNC is 10.10.10.1/24.

Add

the device IP address of the interface board (optional). The IP address is planned by the operator. ADD DEVIP: SRN=0, SN=18, DEVTYPE=LOGIC_IP, IPADDR="20.20.20.20"; // Add logic IP address 1 20.20.20.20 on the interface board in slot 18 to be local IP address 1 of SCTP. The default subnet mask 255.255.255.255 is adopted. ADD DEVIP: SRN=0, SN=18, DEVTYPE=LOGIC_IP, IPADDR="20.20.20.30"; // Add logic IP address 1 20.20.20.30 on the interface board in slot 18 to be local IP address 2 of SCTP. The default subnet mask 255.255.255.255 is adopted. ADD DEVIP: SRN=0, SN=18, DEVTYPE=LOGIC_IP, IPADDR="20.20.20.40"; // Add logic IP address 1 20.20.20.40 on the interface board in slot 18 to be local IP address 1 of the GTPU. The default subnet mask 255.255.255.255 is adopted.

II. Data Configuration on the Control Plane


The general configuration procedure is as follows: (OPC --> N7DPC )--> M3LE --> M3DE --> M3LKS --> M3RT --> M3LNK

Add

SCTP signaling links. Set Signaling link mode to CLIENT or SERVER. Generally, the SGSN serves as the server, whereas the RNC acts as the client. Set Application type to M3UA. The port No. must be consistent on both ends. ADD SCTPLNK: SRN=0, SN=2, SCTPLNKN=0, MODE=CLIENT, APP=M3UA, DSCP=48, LOCPN=5000, LOCIP1="20.20.20.20", LOCIP2="20.20.20.30", PEERIP1="40.40.40.40", PEERIP2="40.40.40.50", PEERPN=5100, LOGPORTFLAG=NO, MTU=800, VLANFLAG1=DISABLE, VLANFlAG2=DISABLE, SWITCHBACKFLAG=YES; ADD SCTPLNK: SRN=0, SN=4, SCTPLNKN=1, MODE=CLIENT, APP=M3UA, DSCP=48, LOCPN=5002, LOCIP1="20.20.20.20", LOCIP2="20.20.20.30", PEERIP1="40.40.40.40", PEERIP2="40.40.40.50", PEERPN=5102, LOGPORTFLAG=NO, MTU=800, VLANFLAG1=DISABLE, VLANFlAG2=DISABLE, SWITCHBACKFLAG=YES;

According

to the planning on site, you can configure either the host route (the subnet mask of the destination IP address is 255.255.255.255) or the network segment route (the destination IP address is the network address and the subnet mask cannot be 255.255.255.255). ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.40", DSTMASK="255.255.255.255", NEXTHOP=""10.10.10.2", PRIORITY=HIGH, REMARK=" To MSC1_CP1"; ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.50", DSTMASK="255.255.255.255", NEXTHOP=""10.10.10.2", PRIORITY=HIGH, REMARK=" To MSC1_CP2";

Add

two destination signaling point.

ADD N7DPC: NAME="MSC1", DPX=0, SPX=0, SPDF=WNF, DPC=H'000972, DPCT= IUCS_RANAP, SLSMASK=B0000, NEIGHBOR=YES, STP=OFF, BEARTYPE=M3UA, PROT=ITUT; ADD N7DPC: NAME="MGW1", DPX=1, SPX=0, SPDF=WNF, DPC=H'000973, DPCT= IUCS_ALCAP, SLSMASK=B0000, NEIGHBOR=YES, STP=OFF, BEARTYPE=M3UA, PROT=ITUT;
Add

a local M3UA entity.

ADD M3LE: LENO=0, SPX=0, ENTITYT=M3UA_IPSP, RTCONTEXT=4294967295, NAME=" RNC12";


Add

an M3UA destination entity. If the negotiation is required by the peer end, set the route context of the destination entity according to the route context provided by the peer end. ADD M3DE: DENO=0, LENO=0, DPX=0, ENTITYT=M3UA_IPSP, RTCONTEXT=4294967295, NAME=" MSC1";

Add

an M3UA link set. To implement load sharing among M3UA links, it is recommended to set Signaling link mask to B0111. Ensure that settings of Work mode and Traffic mode are consistent on both ends. ADD M3LKS: SIGLKSX=0, DENO=0, LNKSLSMASK=B1111, TRAMODE=M3UA_LOADSHARE_MOD, WKMODE=M3UA_IPSP, NAME=" MSC1"; Note: If signaling routes need to work in load sharing mode, set Signaling route mask to B1000 in the ADD N7DPC command and set Signaling link mask to B0111 in the ADD M3LKS command because the result of the AND operation of the two settings must be 0.

Add

an M3UA route. M3UA links.

ADD M3RT: DENO=0, SIGLKSX=0, PRIORITY=0, NAME=" to MSC1";


Add

ADD M3LNK: SIGLKSX=0, SIGLNKID=0, SRN=0, SN=2, SCTPLNKN=0, PRIORITY=0, LNKREDFLAG=M3UA_MASTER_MOD, NAME=" to MSC1_0";

ADD M3LNK: SIGLKSX=0, SIGLNKID=1, SRN=0, SN=4, SCTPLNKN=1, PRIORITY=0, LNKREDFLAG=M3UA_MASTER_MOD, NAME=" to MSC1_1";
Add

an adjacent node. Set Adjacent Node Type to IUCS and Transport Type to IP. ADD ADJNODE: ANI=1700, NAME=" MGW1", NODET=IUCS, TRANST=IP, DPX=1; a CN domain. Set CN domain ID to CS_DOMAIN. ADD UCNDOMAIN: CNDomainId=CS_DOMAIN, T3212=10, ATT=ALLOWED, DRXCycleLenCoef=6;

Add

Add

a CN node. Set CN domain ID to PS_DOMAIN (PS domain) and Iu transfers bearer type to IP_TRANS (IP transport). ADD UCNNODE: CnOpIndex=0, CNId=0, CNDomainId=CS_DOMAIN, Dpx=0, CNProtclVer=R6, CNLoadStatus=NORMAL, AvailCap=65535, TnlBearerType=IP_TRANS, RTCPSwitch=OFF, Switch3GPP25415CR0125=OFF;

III. Mapping Between Transmission Resources and Configuration of the Activation


Factor Table
Add

the mapping between transmission resources to map services of different QoS requirements to different IP paths. For the IUCS transport, TRMMP ID is set to 7 by default. If the default mapping cannot meet the requirements, you can use the ADD TRMMAP command to add a TRMMP ID.

You can run the LST TRMMAP command to query the default settings. TRMMAP(Iub) Service Type Common channel IMS SRB SRB AMR voice R99 CS conversational R99 CS streaming
Add

Default Primary NULL NULL NULL EF AF43 AF43 Secondary NULL NULL NULL NULL NULL NULL

an activation factor table to specify proper factors for each traffic class. Through this task, the transmission resources can be multiplexed. By default, Factor Table Index is set to 0. If the default mapping cannot meet the requirements, you can use the ADD TRMFACTOR command to add an index. See section 4.2.4 . the TRM mapping on the adjacent node. You can run the ADD TRMMAP command to add the TRMMAP ID for the gold, silver, and bronze users. ADD ADJMAP: ANI=1700, ITFT=IUCS, TRANST=IP, TMIGLD=7, TMISLV=7, TMIBRZ=7, FTI=0; // In this example, both TMI and FTI use default values.

Configure

IV. Data Configuration on the User Plane


Add

IP paths. The traffic unit is kbps. You can run the LST PHBMAP command to query the DSCP value corresponding to the PHB of each IP path. ADD IPPATH: ANI=1700, PATHID=0, ITFT=IUCS, PATHT=EF, IPADDR="20.20.20.40", PEERIPADDR="40.40.40.60",

PEERMASK="255.255.255.255", TXBW=1000000, RXBW=1000000, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.60"; // When the path type is EF, the DSCP value is 46. ADD IPPATH: ANI=1700, PATHID=1, ITFT=IUCS, PATHT=AF43, IPADDR="20.20.20.40", PEERIPADDR="40.40.40.60", PEERMASK="255.255.255.255", TXBW=1000000, RXBW=1000000, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.60"; // When the path type is AF43, the DSCP value is 38.
Configure

the route on the user plane. It is optional. According to the planning on site, you can configure either the host route (the subnet mask of the destination IP address is 255.255.255.255) or the network segment route (the destination IP address is the network address and the subnet mask cannot be 255.255.255.255). ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.60", DSTMASK="255.255.255.255", NEXTHOP=""10.10.10.2", PRIORITY=HIGH, REMARK=" To MGW1_UP";

V. VLAN/VLAN Priority/DSCP Configuration


VLAN

Configuration

If the RNC directly connects to the router in layer 3 networking, the VLAN ID is not configured on the RNC. If the VLAN ID needs to be configured on the RNC, run the ADD VLANID command to add the VLAN ID on the next hop (VRRP Virtual IP) of the RNC. ADD VLANID: IPADDR="10.10.10.2", VLANID=100; ADD VLANID: IPADDR="10.10.10.3", VLANID=100; ADD VLANID: IPADDR="10.10.10.4", VLANID=100; Note: The VLAN needs to be configured on the intermediate transmission device.
DSCP

Configuration

According to the planning of the existing network, see section 3.3 for the DSCP configuration. Note: DSCP values need to be configured on the intermediate transmission device.
VLAN

Priority Configuration

If the RNC directly connects to the router in layer 3 networking, the VLAN ID is not configured on the RNC. Then, the VLAN priorities are not configured. If VLAN priorities need to be configured on the RNC, see section 3.4 . Note: VLAN priorities need to be configured on the intermediate transmission devices.

7
7.1 Description
Configuration For The

Iur Configuration Example

examples are based on RNC V900R012 and NodeB V200R12.

configuration details, refer to the Initial Configuration Guide and the corresponding MML online help. networking of configuration examples is only for reference. The networking of each site needs to be designed and deployed according to the actual situations.

7.2 Typical Configuration of IP Layer 3 Networking Based on the Data Network


7.2.1 Networking Diagram

7.2.2 Preparations
Cables The

are properly connected and intermediate transmission devices are ready.

data planning is completed.

7.2.3 Data Planning of IP Layer 3 Networking


I. Data Planning in the Physical Layer and Data Link Layer

Data Item Data on the FE port Interface board type IP address of the network gateway Whether to back up/Backup mode Subrack No./slot No./port No. IP address of the FE port/subnet mask IP address for the traffic Data on the IP logic port CP_IP1 CP_IP2 UP_IP1 IP logic port No. Bandwidth of the IP logic port Dynamic bandwidth adjustment switch

RNC GOUa 10.10.10.2/24 Yes/Board backup+port backup 0/18/0 10.10.10.1/24 20.20.20.20/32 20.20.20.30/32 20.20.20.40/32 OFF

HW NRNC GOUa 30.30.30.2/24 Yes/Board backup+port backup 0/24/0 30.30.30.1/24 40.40.40.40/32 40.40.40.50/32 40.40.40.60/32

Data Source Internal planning Network planning Internal planning

Network planning

II. Data Planning of the Control Plane


Data Item SCTP0 Local SCTP port No. Working mode of the SCTP link Subrack No./slot No. of the SPU DSCP Local IP address 1 Local IP address 2 Whether to bind the IP logic port/slot No. and port No. of the logic port Whether to add the VLAN/VLAN ID SCTP1 Local SCTP port No. Working mode of the SCTP link Subrack No./slot No. of the SPU DSCP Local IP address 1 Local IP address 2 Whether to bind the IP RNC 2905 Server 0/2 48 20.20.20.20/32 20.20.20.30/32 NO HW NRNC 9000 Client 48 40.40.40.40/32 40.40.40.50/32 Data Source Data to be negotiated

NO 2905 Server 0/4 48 20.20.20.20/32 20.20.20.30/32 NO

9001 Client 48 40.40.40.40/32 40.40.40.50/32

logic port/slot No. and port No. of the logic port Whether to add the VLAN/VLAN ID M3UA Type of the local entity Context of the local entity route Working mode Working mode NO M3UA_IPSP 4294967295 Load sharing M3UA_IPSP M3UA_IPSP 4294967295 Load sharing M3UA_IPSP Data to be negotiated

III. Data Planning of the User Plane


Data Item Adjacent node ID Transport type of the Iur interface One IP path Port type IP path ID PATH type Whether to bind the IP logic port/slot No. and port No. of the logic port Local IP address/subnet mask Whether to enable the VLAN/enabled VLAN ID Path detection flag Detected IP address TX bandwidth (kbps) RX bandwidth (kbps) Whether to enable the FPMUX RNC 10 IP ETH 0 QoS NO HW NRNC ETH 0 QoS NO Data Source Internal planning Data to be negotiated

20.20.20.40/32 NO

40.40.40.60/32 NO

Network planning

ENABLE 40.40.40.60/32 1000000 1000000 NO

ENABLE 20.20.20.40/32 1000000 1000000 NO

Network planning

7.2.4 Data Configuration on the RNC


I. Data Configuration on the Physical Layer and Data Link Layer
Configure

the backup information of the interface board according to the networking situation on site.

ADD BRD: SRN=0, BRDCLASS=INT, BRDTYPE=GOUa, SN=18, RED=YES, MPUSUBRACK=0, MPUSLOT=0; // Set the GOUa board in slot 18 of subrack 0 and GOUa board in slot 19 to work in active/standby mode.
Configure

the backup information of the ports on the interface board according to the networking situation on site.

ADD ETHREDPORT: SRN=0, SN=18, PN=0; //Set port 0 on the GOUa in slot 18 of subrack 0 and port 0 on the GOUa in slot 19 to work in active/standby mode.
Set

the attributes of the Ethernet ports. Ensure that the Ethernet port attributes are consistent on both ends. The MTU value on the RNC needs to be smaller or equal to that of the intermediate transmission device. See section 3.2 .

SET ETHPORT: SRN=0, SN=18, BRDTYPE=GOUa, PN=0, AUTO=ENABLE, MTU=1500, OAMFLOWBW=0, FLOWCTRLSWITCH=ON, FCINDEX=1; Major parameters are described as follows: AUTO Auto negotiation or not Description: This parameter setting on the RNC must be consistent with that on the peer device through negotiation. That is, if this parameter is set to auto negotiation on the peer device, the parameter on the port of the RNC is also set to auto negotiation; otherwise, it is set to non-auto negotiation. Description: Generally, the transmission rate over the FE port is 100 Mbit/s or 1000 Mbit/s. Description: Half duplex indicates that the data packets cannot be transmitted during the receiving of data packets; full duplex indicates that the data packets can be transmitted and received at the same time. Generally, the working mode is set to full duplex.

SPEED

Transmission rate over the port Working mode

DUPLEX

Run

the following command to add the IP address of the Ethernet port. The IP address is planned by the operator. ADD ETHIP: SRN=0, SN=18, PN=0, IPINDEX=0, IPADDR="10.10.10.1", MASK="255.255.255.0"; // The IP address of the interface board on the RNC is 10.10.10.1/24.

Add

the device IP address of the interface board (optional). The IP address is planned by the operator.

ADD DEVIP: SRN=0, SN=18, DEVTYPE=LOGIC_IP, IPADDR="20.20.20.20"; // Add logic IP address 1 20.20.20.20 on the interface board in slot 18 to be local IP address 1 of SCTP. The default subnet mask 255.255.255.255 is adopted. ADD DEVIP: SRN=0, SN=18, DEVTYPE=LOGIC_IP, IPADDR="20.20.20.30"; // Add logic IP address 1 20.20.20.30 on the interface board in slot 18 to be local IP address 2 of SCTP. The default subnet mask 255.255.255.255 is adopted. ADD DEVIP: SRN=0, SN=18, DEVTYPE=LOGIC_IP, IPADDR="20.20.20.40"; // Add logic IP address 1 20.20.20.40 on the interface board in slot 18 to be the local IP address of the user plane. The default subnet mask 255.255.255.255 is adopted.

II. Data Configuration on the Control Plane


The general configuration procedure is as follows:
(OPC --> N7DPC )-->SCTPLNK--> M3LE --> M3DE --> M3LKS --> M3RT --> M3LNK
Add

SCTP signaling links. Set Signaling link mode to CLIENT or SERVER. In this

example, the SGSN serves as the server, whereas the RNC acts as the client. Set Application type to M3UA. The port No. must be consistent on both ends. ADD SCTPLNK: SRN=0, SN=2, SCTPLNKN=0, MODE= SERVER, APP=M3UA, DSCP=48, LOCIP1="20.20.20.20", LOCIP2="20.20.20.30", PEERIP1="40.40.40.40", PEERIP2="40.40.40.50", PEERPN=9000, LOGPORTFLAG=NO, MTU=800, VLANFLAG1=DISABLE, VLANFlAG2=DISABLE, SWITCHBACKFLAG=YES; ADD SCTPLNK: SRN=0, SN=2, SCTPLNKN=1, MODE= SERVER, APP=M3UA, DSCP=48, LOCIP1="20.20.20.20", LOCIP2="20.20.20.30", PEERIP1="40.40.40.40", PEERIP2="40.40.40.50", PEERPN=9001, LOGPORTFLAG=NO, MTU=800, VLANFLAG1=DISABLE, VLANFlAG2=DISABLE, SWITCHBACKFLAG=YES; Note: When the RNC acts as an SCTP server, you can run the SET SCTPSRVPORT command to set the local SCTP port No.. Generally, the default No. is used. You can use the LST SCTPSRVPORT command to query the default No..

Configure

the route on the control plane. It is optional. According to the planning on site, you can configure either the host route (the subnet mask of the destination IP address is 255.255.255.255) or the network segment route (the destination IP address is the network address and the subnet mask cannot be 255.255.255.255). ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.40", DSTMASK="255.255.255.255", NEXTHOP=""10.10.10.2", PRIORITY=HIGH, REMARK=" To NRNC1_CP1"; ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.50", DSTMASK="255.255.255.255", NEXTHOP=""10.10.10.2", PRIORITY=HIGH, REMARK=" To NRNC1_CP2";

Add

a destination signaling point.

ADD N7DPC: NAME="NRNC1", DPX=11, SPX=0, SPDF=WNF, DPC= H'000579, DPCT= IUR, SLSMASK=B0000, NEIGHBOR=YES, STP=OFF, BEARTYPE=M3UA, PROT=ITUT;
Add

an adjacent RNC. Set the switch in the radio layer according to the planning of the existing network. ADD UNRNC: NRncId=11, HHOTRIG=OFF, ServiceInd=SUPPORT_CS_AND_PS, IurExistInd=TRUE, Dpx=11, RncProtclVer=R6, TnlBearerType=IP_TRANS;

Add

a local M3UA entity.

ADD M3LE: LENO=0, SPX=0, ENTITYT=M3UA_IPSP, RTCONTEXT=4294967295, NAME=" RNC12";


Add

an M3UA destination entity. If the negotiation is required by the peer end, set the route context of the destination entity according to the route context provided by the peer end. ADD M3DE: DENO=11, LENO=0, DPX=11, ENTITYT=M3UA_IPSP, RTCONTEXT=4294967295, NAME=" NRNC1";

Add

an M3UA link set. To implement load sharing among M3UA links, it is recommended to set Signaling link mask to B0111. Ensure that settings of Work mode and Traffic mode are consistent on both ends. ADD M3LKS: SIGLKSX=11, DENO=11, LNKSLSMASK=B1111, TRAMODE=M3UA_LOADSHARE_MOD, WKMODE=M3UA_IPSP, NAME=" To NRNC1"; Note: If signaling routes need to work in load sharing mode, set Signaling route mask to B1000 in the ADD N7DPC command and set Signaling link mask to

B0111 in the ADD M3LKS command because the result of the AND operation of the two settings must be 0.
Add

an M3UA route. M3UA links.

ADD M3RT: DENO=11, SIGLKSX=11, PRIORITY=0, NAME=" To NRNC1";


Add

ADD M3LNK: SIGLKSX=11, SIGLNKID=0, SRN=0, SN=2, SCTPLNKN=0, PRIORITY=0, LNKREDFLAG=M3UA_MASTER_MOD, NAME=" to MSC1_0"; ADD M3LNK: SIGLKSX=11, SIGLNKID=1, SRN=0, SN=4, SCTPLNKN=1, PRIORITY=0, LNKREDFLAG=M3UA_MASTER_MOD, NAME=" to MSC1_1";
Add

an adjacent node. Set Adjacent Node Type to Iur and Transport Type to IP.

ADD ADJNODE: ANI=5, NAME=" NRNC1", NODET=Iur, TRANST=IP, DPX=11;

III. Mapping Between Transmission Resources and Configuration of the Activation


Factor Table
Add

the mapping between transmission resources to map services of different QoS requirements to different IP paths. For the IP transport on the Iur interface, TRMMP ID is set to 5 by default. If the default mapping cannot meet the requirements, you can use the ADD TRMMAP command to add a TRMMP ID.

You can run the LST TRMMAP command to query the default settings. TRMMAP(Iub IP) Service Type Common channel IMS SRB SRB AMR voice R99 CS conversational R99 CS streaming R99 PS conversational R99 PS streaming R99 PS high PRI interactive R99 PS middle PRI interactive R99 PS low PRI interactive R99 PS background HSDPA Signal HSDPA IMS Signal HSDPA Voice HSDPA conversational HSDPA streaming HSDPA high PRI interactive HSDPA middle PRI interactive HSDPA low PRI interactive HSDPA background Default Primary EF EF EF EF AF43 AF43 AF43 AF43 AF23 AF23 AF23 AF23 EF EF AF43 AF43 AF43 AF13 AF13 AF13 AF13 Secondary NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL NULL

HSUPA Signal HSUPA IMS Signal HSUPA Voice HSUPA conversational HSUPA streaming HSUPA high PRI interactive HSUPA middle PRI interactive HSUPA low PRI interactive HSUPA background
Add

EF EF AF43 AF43 AF43 AF13 AF13 AF13 AF13

NULL NULL NULL NULL NULL NULL NULL NULL NULL

an activation factor table to specify proper factors for each traffic class. Through this task, the transmission resources can be multiplexed. By default, Factor Table Index is set to 0. If the default mapping cannot meet the requirements, you can use the ADD TRMFACTOR command to add an index. See section 4.2.4 . the TRM mapping on the adjacent node. You can run the ADD TRMMAP command to add the TRMMAP ID for the gold, silver, and bronze users. ADD ADJMAP: ANI=5, ITFT=Iur, TRANST=IP, TMIGLD=5, TMISLV=5, TMIBRZ=5, FTI=0; // In this example, both TMI and FTI use default values.

Configure

IV. Data Configuration on the User Plane


Add

IP paths. The traffic unit is kbps. PHBs corresponding to various services on the Iur interface can be obtained by using the LST TRMMAP command. DSCP values corresponding to PHBs can be obtained by using the LST PHBMAP command. In this example, the HW RNC connects to each other. Therefore, the PATH type can be set to QoS. ADD IPPATH: ANI=5, PATHID=0, ITFT=Iur, PATHT=QoS, IPADDR="20.20.20.40", PEERIPADDR="40.40.40.60", PEERMASK="255.255.255.255", TXBW=1000000, RXBW=1000000, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.60"; If the HW RNC connects to the RNCs provided by other competitors, configure four IP paths of the EF, AF43, AF 23, and AF13 types according to the Transmission Configuration Specifications.

Configure

the route on the user plane. It is optional. According to the planning on site, you can configure either the host route (the subnet mask of the destination IP address is 255.255.255.255) or the network segment route (the destination IP address is the network address and the subnet mask cannot be 255.255.255.255). ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.60", DSTMASK="255.255.255.255", NEXTHOP=""10.10.10.2", PRIORITY=HIGH, REMARK=" To NRNC_UP1";

V. VLAN/VLAN Priority/DSCP Configuration


VLAN

Configuration

If the RNC directly connects to the router in layer 3 networking, the VLAN ID is not configured on the RNC. If the VLAN ID needs to be configured on the RNC, run the ADD VLANID command to add the VLAN ID on the next hop (VRRP Virtual IP) of the RNC. ADD VLANID: IPADDR="10.10.10.2", VLANID=100;

ADD VLANID: IPADDR="10.10.10.3", VLANID=100; ADD VLANID: IPADDR="10.10.10.4", VLANID=100; Note: The VLAN needs to be configured on the intermediate transmission device. Configuration According to the planning of the existing network, see section 3.3 for the DSCP configuration. Note: DSCP values need to be configured on the intermediate transmission device. VLAN Priority Configuration If the RNC directly connects to the router in layer 3 networking, the VLAN ID is not configured on the RNC. Then, the VLAN priorities are not configured. If VLAN priorities need to be configured on the RNC, see section 3.4 . Note: VLAN priorities need to be configured on the intermediate transmission devices.

DSCP

VI. Data Configuration for Static Relocation


To reduce the bandwidth occupied by the Iur interface and the transmission delay on the user plane, you can configure static SRNC relocation from a Serving RNC (SRNC) to a Drift RNC (DRNC).
Add

an IP route to the DRNC by running the following command:

ADD IPRT: SRN=0, SN=18, DSTIP="40.40.40.60", DSTMASK="255.255.255.255", NEXTHOP="GW1", PRIORITY=HIGH, REMARK="Static Relocation"; \\ Set Destination IP address (DSTIP) to the user plane IP address of the DRNC and Forward route address (NEXTHOP) to the SGSN gateway (GW1) IP address for the forward route from the RNC.
Add

an IP path used for static relocation by running the following command:

ADD IPPATH: ANI=3, PATHID=0, ITFT=IUPS, PATHT=QoS, IPADDR="20.20.20.40", PEERIPADDR="40.40.40.60", PEERMASK="255.255.255.255", TXBW=1000000, RXBW=1000000, VLANFlAG=DISABLE, PATHCHK=ENABLED, ECHOIP="40.40.40.60"; \\ Set Adjacent Node ID (ANI) to the adjacent node ID of the SGSN. Set Local IP address (IPADDR) to the user plane IP address of the SRNC. Set Peer IP address (PEERIPADDR) to the user plane IP address of the DRNC. Set Peer subnet mask (PEERMASK) to the subnet mask of the DRNC user plane IP address and the recommended value is 255.255.255.0.

It is recommended that an IP route and IP path to the DRNC be configured for each IP interface board configured with Iu-PS user plane data. If there exist multiple destination IP network segments at the DRNC, an IP route and IP path to each network segment need to be configured for each IP interface board. This facilitates load sharing between Iu-PS and Iur interfaces.

Remote OM Channel

8.1 IPRAN O&M Networking Diagram

8.2 Interworking Between the M2000 and the OMU on the RNC
8.2.1 Networking Diagram

8.2.2 Data Planning


Data Item External virtual IP address of the OMU IP address of the external network gateway of the OMU IP address of the EMS IP address of the network gateway of the M2000 server RNC 10.161.215.242/24 10.161.215.1/24

M2000 Server 10.30.30.30/24 10.30.30.1/24

Data Source Network planning

8.2.3 Data Configuration


I. Data Configuration on the RNC
Add

an IP address of the EMS.

ADD EMSIP: EMSIP="10.30.30.30", MASK="255.255.255.0", OMUIP="10.161.215.242", OMUMASK="255.255.255.0";


Add

the route to the IP address of the EMS on the OMU. Before the configuration, you can use the LST OMUIPRT command to check whether the route to the IP address of the EMS exists in the route table. If yes, the route addition is unnecessary. Generally, when the network gateway is configured for the OMU, a route to the network gateway (that is, the next hop) is automatically generated. ADD OMUIPRT: RTDEST="10.30.30.30", RTDESTMASK="255.255.255.0", NEXTHOP="10.161.215.1";

II. Route Configuration Requirements on the M2000


Add

the route to the external virtual IP address of the OMU. Before the configuration, you can check whether the route exists in the route table. If yes, the route addition is unnecessary.

Generally, a route to the network gateway (that is, the next hop) is automatically generated. Destination Gateway

10.161.215.0/24

10.161.215.1

III. Configuration Requirements of Devices Between the M2000 and OMU


Configure routes (for example, host routes, network segment routes, and default routes) to the IP address of the EMS and the external virtual IP address of the OMU on layer 3 routers between the M2000 and OMU.

8.3 OM Channels Between the M2000 and NodeB Not Through the RNC
8.3.1 Networking Diagram

OM packets from the M2000 to the NodeB do not pass through the internal devices of the RNC. This networking is recommended in IP over Ethernet mode for it uses fewer transport resources of the Iub interface and reduces the traffic between boards of the RNC.

8.3.2 Data Planning


Data Item OM IP address on the NodeB Interface IP address on the NodeB IP address of the network gateway on the NodeB Extern virtual IP address of OMU IP Address/Mask 30.30.30.30/30 20.20.20.20/24 20.20.20.2/24 10.161.215.242/24 Data Source Network planning

IP address of the EMS IP address of the network gateway of the M2000 server

10.30.30.30/24 10.30.30.1/24

8.3.3 Data Configuration on the RNC


I. AddanOMIPaddressontheNodeB,whichisusedfortheOMchannelofthe
NodeB.
ADD UNODEBIP: NODEBID=1, NBTRANTP=IPTRANS_IP, NBIPOAMIP="30.30.30.30", NBIPOAMMASK="255.255.255.252", IPSRN=0, IPSN=18, IPLOGPORTFLAG=YES, IPLPN=10, VLANFLAG=ENABLE, VLANID=100, VLANPRI=4; // The VLAN ID and VLAN priority is

configured for the OM channel on the NodeB. If the VLAN ID is not added on the OM channel, the configuration is unnecessary.

II. Add the IP attribute for the NE management system. The IP address of the EMS
serves as the IP address of the M2000. ADD EMSIP: EMSIP="10.30.30.30", MASK="255.255.255.0", OMUIP="10.161.215.242", OMUMASK="255.255.255.0";

III. IP Route Configuration


IP routes are not configured on the RNC for the OM packets from the M2000 to the NodeB does not pass through the RNC.

8.3.4 Data Configuration on the NodeB


I. Add the OM IP address for the NodeB to operate and maintain channels.
ADD OMCH: IP="30.30.30.30", MASK="255.255.255.252", PEERIP="10.30.30.30", PEERMASK="255.255.255.0", BEAR=IPV4, SRN=0, SN=6, SBT=BASE_BOARD, BRT=NO;

If If

the OM IP address and the interface IP address on the NodeB are on the same network segment, run the SET ETHPORT command to set ARP Proxy to ENABLE. the M2000 works in two-node cluster mode, the IP address of the EMS is fixed and Peer IP is set to EMSIP. If the M2000 works in a remote two-node cluster mode, the IP address of the EMS is float and it is recommended to set Peer IP to the IP address of the gateway IP address on the NodeB.

II. IP Route Configuration


Add

the route to the IP address of the EMS. Before the configuration, you can run the LST IPRT command to check whether the route exists in the route table on the corresponding transmission interface board. If yes, the route addition is unnecessary. ADD IPRT: CN=0, SRN=0, SN=6, SBT=BASE_BOARD, DSTIP="10.30.30.30", DSTMASK="255.255.255.0", RTTYPE=NEXTHOP, NEXTHOP="20.20.20.2";

III. VLAN/VLAN Priority/DSCP Configuration


According to the planning of the existing network, see Chapter 3 for the configuration.

8.3.5 Route Configuration Requirements on the M2000


I. IP Route Configuration

Add

the route to the OM IP address of the NodeB. Before the configuration, you can check whether the route exists in the route table on the M2000. If yes, the route addition is unnecessary.

Generally, a route to the network gateway (that is, the next hop) exists on the M2000. Destination 30.30.30.30/32 Gateway 10.161.215.1

8.3.6 Configuration Requirements of Devices Between the M2000 and OMU


I. Route Configuration Requirements
Configure routes (for example, host routes, network segment routes, and default routes) to the IP address of the EMS and the OM IP address of the NodeB on layer 3 routers between the M2000 and NodeB.

II. VLAN/VLAN Priority/DSCP Configuration Requirements


You need to configure the VLAN, VLAN priorities, and DSCP values used during the planning.

8.4 OM Channels Between the M2000 and NodeB Through the RNC
8.4.1 Networking Diagram

OM packets from the M2000 are transmitted on the route to the RNC and pass through the OMU, SCU, and Iub interface board in the RNC. This networking mode is applicable to the ATM networking and IP over PPP/MP networking. In IP over Ethernet networking, if the Iub interface requires the VLAN but the VLAN ID is not carried on any intermediate transmission device, you can consider to adopt this networking mode.

8.4.2 Data Planning


Data Item OM IP address on the NodeB Interface IP address on the NodeB IP address of the network gateway on the NodeB IP address of the network gateway on the RNC Interface IP address on the RNC External virtual IP address of the OMU IP address of the EMS IP address of the network gateway of the M2000 server IP Address/Mask 30.30.30.30/30 20.20.20.20/24 20.20.20.2/24 10.10.10.2/24 10.10.10.1/24 10.161.215.242/24 10.30.30.30/24 10.30.30.1/24 Data Source Network planning

8.4.3 Data Configuration on the RNC


I. Add an OM IP address on the NodeB, which is used for the OM channel of the
NodeB. ADD NODEBIP: NODEBID=1, NBTRANTP=IPTRANS_IP, NBIPOAMIP="30.30.30.30", NBIPOAMMASK="255.255.255.252", IPSRN=0, IPSN=18, IPLOGPORTFLAG=YES, IPLPN=10, VLANFLAG=ENABLE, VLANID=100, VLANPRI=4; // The VLAN ID and VLAN priority is configured for the OM channel on the NodeB. If the VLAN ID is not added on the OM channel, the configuration is unnecessary.

II. Add the IP attribute for the NE management system. The IP address of the EMS
serves as the IP address of the M2000. ADD EMSIP: EMSIP="10.30.30.30", MASK="255.255.255.0", OMUIP="10.161.215.242", OMUMASK="255.255.255.0";

III. IP Route Configuration


Configure

the route to the OM IP address of the NodeB on the Iub interface board. That is, you can configure the host route or network segment route according to the network planning. ADD IPRT: SRN=0, SN=18, DSTIP="30.30.30.30", DSTMASK="255.255.255.255", NEXTHOP="10.10.10.2", PRIORITY=HIGH, REMARK="to NodeB OMIP";

Configure

the route to the IP address of the EMS on the Iub interface board.

After the ADD EMSIP command is run, a network segment route is automatically generated. The size of the route is the result of the AND operation of the added IP

address of the EMS and the mask.


Configure

the route to the OM IP address of the NodeB on the OMU.

After the ADD NODEBIP command is run, a host route is automatically generated.
Configure

the route to the IP address of the EMS on the OMU. Before the configuration, you can run the LST OMUIPRT command to check whether the route to the IP address of the EMS exists in the route table. If yes, the route addition is unnecessary. Generally, when the network gateway is configured on the OMU, a route whose next hop is the IP address of the gateway is automatically generated. ADD OMUIPRT: RTDEST="10.30.30.30", RTDESTMASK="255.255.255.0", NEXTHOP="10.161.215.1";

IV. VLAN/VLAN Priority/DSCP Configuration


According to the planning of the existing network, see Chapter 3 for the configuration.

8.4.4 Data Configuration on the NodeB


I. Add an OM IP address on the NodeB, which is used for the OM channel of the
NodeB. ADD OMCH: IP="30.30.30.30", MASK="255.255.255.252", PEERIP="10.30.30.30", PEERMASK="255.255.255.0", BEAR=IPV4, SRN=0, SN=6, SBT=BASE_BOARD, BRT=NO;

If If

the OM IP address and the interface IP address on the NodeB are on the same network segment, run the SET ETHPORT command to set ARP Proxy to ENABLE. the M2000 works in local two-node cluster mode and the IP address of the EMS is fixed, set Peer IP to EMSIP. If the M2000 works in remote two-node cluster mode and the IP address of the EMS is float, it is recommended to set Peer IP to the gateway IP address on the NodeB.

II. IP Route Configuration


Add

the route to the IP address of the EMS. Before the configuration, you can run the LST IPRT command to check whether the route exists in the route table on the corresponding transmission interface board. If yes, the route addition is unnecessary. ADD IPRT: CN=0, SRN=0, SN=6, SBT=BASE_BOARD, DSTIP="10.30.30.30", DSTMASK="255.255.255.0", RTTYPE=NEXTHOP, NEXTHOP="20.20.20.2";

III. VLAN/VLAN Priority/DSCP Configuration


According to the planning of the existing network, see Chapter 3 for the configuration.

8.4.5 Route Configuration Requirements of Devices Between the M2000 and OMU
Configure routes (for example, host routes, network segment routes, and default routes) to the IP address of the EMS and the OM IP address of the NodeB on layer 3 routers between the M2000 and NodeB.

8.5 Active/Standby OMCH Configuration on the NodeB


8.5.1 Application Scenario

Presently, active/standby OMCH configuration is supported only when the NodeB uses an ATM_IP dual-stack network structure. The NodeB selects the active OMCH as the activated OMCH after being started. If no active OMCH is available, the standby OMCH does not work as the activated OMCH automatically. The result of the DSP OMCH command shows NULL under the activated OMCH. Therefore, one active OMCH must be configured during initial configuration.

8.5.2 Configuration on the RNC


Configure two OM channels. One OM channel is carried on IP over Ethernet; the other is carried on ATM. The configuration in the existing network is based on the planning.
ADD UNODEBIP: NODEBID=100, NBTRANTP=ATMANDIPTRANS_IP, NBIPOAMIP="30.30.30.30", NBIPOAMMASK="255.255.255.252", IPSRN=0, IPSN=18, IPLOGPORTFLAG=YES, IPLPN=10, NBATMOAMIP="40.40.40.40", NBATMOAMMASK="255.255.255.252", ATMSRN=0, ATMSN=14, VLANFLAG=DISABLE;

8.5.3 Configuration on the NodeB


ADD OMCH: FLAG=MASTER, IP="30.30.30.30", MASK="255.255.255.252", PEERIP="10.30.30.30", PEERMASK="255.255.255.0", BEAR=IPV4, SRN=0, SN=7, SBT=BASE_BOARD, BRT=NO; // The primary OM channel is carried on IP over Ethernet; ADD OMCH: FLAG=SLAVE, IP="40.40.40.40", MASK="255.255.255.252", PEERIP="10.30.30.30", PEERMASK="255.255.255.0", BEAR=ATM, SRN=0, SN=7, JNRSCGRP=DISABLE, SBT=BASE_BOARD, PT=IMA, PN=0, VPI=1, VCI=33, RU=KBPS, ST=UBR+, MCR=64, PCR=512; // The spare OM channel is carried on ATM.

9
Product RAN

Reference List

manuals, such as the Initial Configuration Guide and Product Description Specification in the Transmission Layer

Feature V2 IPRAN Deployment Guide

Configuration RAN10

Вам также может понравиться