Вы находитесь на странице: 1из 2

Metal Casting Techniques - Ceramic Molding (Shaw Process)

Ceramic molding can be accomplished through two diverse techniques:

1. True ceramic molding. 2. Ethyl silicate slurry molding (also known as the Shaw process, Avnet-Shaw, Osborn-Shaw and the
Dean process ). Ceramics are materials which are made from a clay base and contain various oxides and ingredients other than sand. The raw clays are calcined or fired at high temperatures and are then blended, mixed with water, formed into mold components, and then fired. In true ceramic molding, the refractory grain can be bonded with calcium or ammonium phosphates. The preferred methods for producing ceramic molds is the dry pressing method in which molds are made by pressing the clay mixture containing 4-9% moisture in dies under a pressure of 1-10 ton/sq in. After pressing, molds are stripped from the dies and then fired at temperatures between 1650-2400F (899C and 1316C). The ethyl silicate variation is accomplished in the following manner: a mixture of a graded refractory filler, hydrolyzed ethyl silicate, and a liquid catalyst are blended together to form a slurry consistency. The slurry is then poured over a pattern and allowed to jell. After gelation, the mold is stripped and torched with a high pressure gas torch. The mold can then be cooled, assembled and fired prior to pouring. The best known of these process variations is a development from the United Kingdom called the Shaw process. The chief difference between the Shaw and other investment molding processes is that a jelling agent is added to the refractory slurry-like mixture before it is poured over the pattern. When this mixture forms a somewhat flexible gel, the mold can be stripped off the pattern. Patterns can be made of various materials such as plaster, wood or metal and can be reused. In this manner, this process differs from the expendable (wax or plastic) process. Molds are torched, then brought to a red heat in a furnace. The molds are allowed to cool prior to assembly for pouring. Occasionally the Shaw process and the lost wax process are combined to gain the advantages of each. The complex pattern configurations which are difficult or impossible to remove from the mold can be made of wax and placed into the regular pattern. This provides for the regular pattern to be stripped off and the wax to be melted and burned out later. When compared to investment castings the following apply:

Ceramic Mold Process Compared with Investment Casting


Casting Requirements Surface smoothness Investment Casting 40- 125 microinch Ceramic Mold Casting 80-125 microinch Excellent, approaching but not equalling precision castings Excellent

Intricacy

Excellent

Thinness of metal sections

Excellent

Tolerances

Excellent

Good to excellent

Machining costs

Machining greatly Minimum machining reduced, sometimes required but not always eliminated Longest lead time Restricted to small castings Very short lead time Casting size not restricted except above 100 lb for the top size of the casting No limitations Very low cost; jobbin wood or metal patterns may be used

Lead time Adaptability to various sizes Adaptability to various metals and alloys Pattern costs Prototype adaptability

No limitations

Very high cost High cost

Вам также может понравиться