Академический Документы
Профессиональный Документы
Культура Документы
The authors apologize for any inconvenience caused by errors in the first printing of the ninth
edition of Shigleys Mechanical Engineering Design. We had made every attempt to avoid these
problems. However, with a text of over 1000 pages and a solutions manual of over 760 pages
there were bound to be errors, typographical and otherwise. In this edition, there were over 600
new and revised problems. Many of the errors in Appendix B, Answers to Selected Problems,
were due to improper rounding and thus are only off by a small percentage. However small these
errors need to be corrected and reported.
Richard G. Budynas
J. Keith Nisbett
R
i =1
handle is made of cold-drawn AISI 1006 steel. The screw is 4 in-10 UNC and is 8 in
long, overall. The maximum possible length of screw in the clamping region is 6 in.
1
In the figure, delete the dimensions for A and B. Add the horizontal dimension of 3 2 in
from the left ball on the handle to the centerline of the screw.
Page 512. Prob 9-42. Fourth line. Change bending moment of 100 kip in in to 10 kip
bending load 10 in from.
Page 513. Prob. 9-48. Left figure. The upper arrow of the 5 in vertical dimension should intersect
the top of the top plate.
Page 564. Prob. 10-28. Third line. Change music to oil tempered.
Page 566. Prob. 10-41(c). Change Estimate to For part (b), estimate.
Page 610. Prob. 11-26. Fourth column. Change 109 rev to 108 rev.
Page 670. Prob. 12-13. Last line. Change hp to h0.
Prob. 12-15. First line. Change bearing has to bearing with l / d = 1 has. Fourth
line. Change 70F to 70F with = 1.
Page 721. Prob. 13-14. Third line. Change t to .
Page 761. Heading for Sec. 14-12. Change CH to CH (ZW).
Page 927. Prob. 17-13. Change Use Eq. (17-8) to to Use Eq. (17-8) with negligible
centrifugal force to.
Prob. 17-13. Last line. Change F1a to (F1)a.
Page 929. Prob. 17-34. First line. Change 9000-lbf to 7000-lbf. Second line. Change cage
to cage which weighs 1000 lbf. Change Prob. 4-6 to Prob. 4-7.