Вы находитесь на странице: 1из 2

Technical Data Sheet

LANKEM REPEL H2O A solvent-borne water compatible two component (Epoxy-Polyamide) new generation water compatible product has been successfully used to prepare membranes which are impermeable to water; this helps to prevent leaks in cement, concrete water tanks. AVAILABILITY Colour Range Packaging PROPERTIES Drying Time Grey 1 kg packs Under normal drying conditions surface dry in 6-8 hours, apply second coat after 24 hours allow to dry 6-8 hours, Allow for adequate ventilation during the drying period. Matt Pigment: Titanium Dioxide Resin: Epoxy ester/Polyamide. Solvent: Xylene/ Alcohol First Coat Second Coat 80 % 40 0C (closed cup) EU limits value for this product (cat. A/i): 600 g/l (2007) / 500 g/l (2010). This product contains max. 95 g/l VOC For interior use only and Do not apply when air or substrate temperatures are likely to fall below 5C or when the relative humidity is above 80% during application or the drying period. Bitumen tar wax, oil, rubber and Paints should be removed before Lankem Repel H2O to be applied. All surfaces must be sound, clean, suitably dry and free from anything that will interfere with the adhesion of the materials to be applied. Remove any site debris and sweep floor clean. Any oil or grease from site plant/ works must be removed with a detergent Use Lankem Tepol. Allow to dry. 6 m per kg 4 m per kg

Finish Composition

Spreading Rate Volume Solids Flash Point VOC Content Limitations

PREPARATION New Surfaces

Previously Decorated Surfaces

All surfaces must be clean, dry and free from anything that will interfere with the adhesion of the materials to be applied. Remove loose and failing material by scraping or brushing with a stiff bristle brush to a sound edge. Any oil, grease, polish etc must be removed with a detergent Use Lankem Tepol. For surface dirt, wash with hot water and liquid detergent solution to remove any contaminants, frequently changing the water. Rinse thoroughly with clean water to remove all residues. Allow to dry. Feather edges of sound coatings and mechanically dry abrade any glossy surfaces to provide rough surface. Remove all dust by vacuum cleaning. Apply two coat Stir Base well and mixed 50% of two components Base to hardener 1 : 1 ratio by weight and mix till the mixture is homogeneous. Thin with Clean water up to 50 % by volume and apply one direction and allow drying for 24 hours. Apply second coat, thin with clean water maximum up to 10 % by volume in perpendicular to the first coat. Once mixed, Lankem Repel H2O has pot life of 6 hour only. If it hardens cannot be used thereafter. Return surplus material to container and clean with water immediately after use Please refer to the Safety, Health and Environmental Information on the container and Material Safety Data Sheet. When preparing all surfaces avoid the inhalation of dust and/or metal particles. Wear a suitable facemask. Store in secure, dry conditions and inaccessible to children or animals. Containers should be kept closed during storage. Do not empty into drains, watercourses or access routes to septic tanks.

COATING SYSTEM APPLICATION

CLEANING HEALTH AND SAFETY

GENERAL INFORMATION Under normal and frost free conditions this product will remain usable for up to two years if stored correctly and unopened. Every care is taken to ensure that all information provided on this Technical Data Sheet is accurate. Lankem Ceylon PLC is unable to guarantee results as it has no control over the conditions under which its products are applied. Before using this product please ensure you have the latest information. For help or more information contact Lankem Ceylon PLC.

Lankem Ceylon PLC No. 267, Union Place, Colombo 02, Sri Lanka Tel: +94 117766000 Fax: +94 114734683 Web: www.lankemrobbialac.lk

Вам также может понравиться