Академический Документы
Профессиональный Документы
Культура Документы
1. Set RELEASE=0.05 (CCW), RANGE=60 (CCW), OUTPUT=0 (12 o’clock) 1. Set RELEASE=0.05 (CCW), RANGE=60 (CCW), OUTPUT=0 (12 o’clock) 1. Set RELEASE=0.05 (CCW), RANGE=60 (CCW), OUTPUT=0 (12 o’clock)
2. Adjust THRESHOLD until desired gain reduction has been achieved 2. Adjust THRESHOLD to get about 6-15 dB of gain reduction on “ess” sounds, and 2. Adjust THRESHOLD such that the desired portions of the sound DON’T cause any
3. Adjust RELEASE to set recovery time. You might need to re-adjust THRESHOLD. 0-1 dB of gain reduction otherwise. gain reduction (no LEDs light up), while the undesired noise cause gain reduction.
3. Adjust RELEASE to get a smooth reduction. 3. Set RELEASE as high as possible, while still maintaining the desired amount of gain
Side-Chain Limiting/Ducking reduction.
DETECTOR SOURCE: EXT 4. Use RANGE to set the maximum amount of gain reduction, if necessary.
1. Insert the Dyna-Mite on the track you wish to process (the main signal). Keying
2. Send the “key” signal (for instance a bass drum) to a bus, and then select that bus DETECTOR SOURCE: EXT
as “side chain input”/”external input”, which in most host software is selected in the
plug-in header. 1. Insert the Dyna-Mite on the track you wish to process (the main signal).
Hard Gating
3. This “key” will activate the gate, which will perform gain reduction on the main 2. Send the “key” signal (for instance a bass drum) to a bus, and then select that bus
MODE: EXP
signal. as “side chain input”/”external input”, which in most host software is selected in the
DETECTOR SOURCE: INT (or DS-FM for high freq. sensitive gating)
4. Use same basic setup as “Basic Limiting”, except DETECTOR SOURCE: EXT plug-in header.
DETECTOR TYPE: GATE
3. This “key” will activate the gate, which will perform gain reduction on the main
signal.
1. Set RELEASE=0.05 (CCW), RANGE=60 (CCW), OUTPUT=0 (12 o’clock)
4. Use same basic setup as “Soft Noise Gating” or “Hard Gating”, except DETECTOR
2. Adjust THRESHOLD by ear.
SOURCE: EXT
3. Toggle between INT and DS-FM and listen to the difference.
4. Use RELEASE to set the time it takes to reach full gain reduction and RANGE to set
the maximum amount of possible gain reduction.