Академический Документы
Профессиональный Документы
Культура Документы
thus requires a dust collecting facilities to meet stringent environmental restriction. Coal being consumed by Japanese power companies has relatively low sulphur content, say less than 1.0%, which gives high apparent electric resistibility of dust thus high efficient electrostatic precipitator (ESP) is required. In general high sulphur content of coal increases dust collecting efficiency thus requires relatively simple electrostatic precipitator. Principle of ESP Basic principle of ESP is that all dust particles in flue gas are electrically charged by corona discharge and attracted by electrodes and pile up on electrode plates. When the dust piled up on electrodes becomes thick, it would be removed by hammer shock and drop to the hoppers. Electrodes would normally being connected by link chain which rotates with relatively low speed (0.5 m/min) and piled up dust is removed by rotating brushes above the hoppers. Discharge Pole Electrode 2. 1.
Electric resistibility of dust and dust collecting efficiency Dust collecting efficiency is largely affected by electric resistibility of dust and electric resistibility changes according to followings as: a. flue gas temperature b. moisture and SO3 contents in flue gas c. coal properties and ash composition In general electric resistibility ranging 106~1011-cm would normally give favorable collecting efficiency. 4. a. Type of ESP Low temperature ESP Low temperature ESP is installed after air heater where gas temperature would normally be 120oC~150oC. < 30 mg/Nm3
3.
Boiler
De-NOX
AH
ESP
Electric resistibility of dust with the temperature range of 120oC~150oC is relatively high which would results in reducing dust collecting efficiency. Even with some improving technologies 30 mg/Nm3 at the outlet would be considered the limits. b. High temperature ESP High temperature ESP is installed after economizer where flue gas temperature would normally be 320oC~380oC.
Boiler
ESP
De-NOX
AH
< 30 mg/Nm3
Original aim of this system was to increase dust collecting efficiency in relatively high gas temperature where electric resistibility of dust would be relatively low. However it is observed that this system has turned out to be no significant advantages compared to low temperature ESP. 30 mg/Nm3 at the outlet of ESP would be considered the limit. Low Temperature ESP High Alkaline Low Sulphur C l High Alkaline High Sulphur Coal Electric Resistibility (-cm) 1011
1012
108
100
200
300
400
100
106
108
1010
1012
1014
c.
High efficiency ESP This system has been developed to cope with very stringent environmental restriction. ESP is installed after air heater and GGH where flue gas temperature would normally be 95oC~105oC. Non-leak GGH Boiler AH G G H ESP DeSOX G G H chimney
< 10 mg/Nm3
DeNOX
5.
Ash distribution Location of Hopper Clinker hopper Economizer hopper Air heater hopper ESP Pyrite hopper (pulverizer) Ash (%) 5 ~ 15 2~ 5 1~ 2 92 ~ 78 0.1 ~ 1.0 Type of Ash clinker Fly ash Fly ash Fly ash (dust) Pyrite