Академический Документы
Профессиональный Документы
Культура Документы
Congratulations on your Full Speed Ahead product. Please read these instructions and follow
them for correct use. Since specific tools and experience are necessary for proper installation,
instructions and instructions for other FSA products are available for download at
http://www.fullspeedahead.com/techdoc
Specification
Components
If you have questions, please visit our web site contact page at :
http://www.fullspeedahead.com/contact
Warranty
Full Speed Ahead (FSA) warrants all FSA, Gravity, Vision and RPM products to be free from
defects in materials or workmanship for a period of two years from original purchase date
Revision Date 10-Feb-09 www.fullspeedahead.com unless otherwise stated in the full warranty policy. Page
ZS072-v1 The warranty
2 of 3is non-transferable and valid
Crankset installation
1. Ensure that the Bottom Bracket (BB) shell ⓞ I.D. is clean and free from metal chips, dirt, or excess paint.
2. Apply a thin layer of grease to the BB circlip groove. Using a circlip plier, collapse the Circlip ① and insert it into the circlip groove in as shown in above above arrangement. Ensure the
Circlip is fully seated. Using the FSA bearing installation tool # EE041 and a headset press, press one BB30 Bearing ② at a time into the BB shell as shown in above arrangement.
Press each BB30 Bearing into the BB shell until the BB30 Bearing is firmly against the Circlip.
3. Install the spacer ⑧ and the Drive Side Bearing Shield ③ onto the splindle. Carefully insert the right crank arm through the BB30 Bearings.
4. The self Extracting Crank Bolt ⑦ is pre-installed into the Left Crank Arm ④. Install the Left Crank Arm onto spindle. Torque the Crank Bolt 450-550 kgf.cm / 45-55 Nm / 390-485 in.lbs.
Note: The Preload Nut ⑤ must have a Set Screw ⑥ and circlip installed in the assembly.
5. With a M36 spanner wrench, adjust the Preload Nut toward the BB until it contacts the BB30 Bearing. With a 1.5mm allen wrench, tighten the Preload Nut Set Screw to secure the
Preload Nut.
Full Speed Ahead, USA Full Speed Ahead, Europe TH INDUSTRIES / FSA Asia
12810 NE 178th St. Suite 102 Via Del Lavoro, 56 487 Ko-Chung Rd. Ta-Li City 412
Woodinville, WA 98072 20040 Busnago, Milan, ltaly Taichung County, Taiwan
Tel: 1_425_488_8653 Tel: +39_039_688_5265 Tel: +886_4_2406_8641
Fax: +39_039_682_3336 Fax: +886_4_2406_8076
Fax: 1_425_489_1082