Вы находитесь на странице: 1из 7

GROBTV_Q&A Which of the following camera tubes uses lead oxide (PbO) for the photoconductive target plate?

a. Plumbicon b. Vidicon c. Saticon d. image orthicon Camera signal output w/o sync is called a. non-composite video b. black burst c. generator lock video d. composite video A low contrast picture in which white seems flat and lacking in detail suggests a. low beam current b. high gain in pre-amplifier c. excessive gamma d. insufficient scanning width Which of the ff camera tubes has minimum lag? (Board Nov.2006) a. plumbicon b. vidicon c. saticon d. iconoscope The part of the visible spectrum where camera pick-up tubes have the greatest output a. yellow-green b. red c. blue d. infrared Precise scanning size and linearity are most important in (Board Nov.2006) a. a single-tube color pickup b. a plumbicon c. a black-and-white camera d. a saticon Beam alignment magnets for the camera tube are adjusted while rocking which control? a. electrical focus b. optical focus c. beam current d. shading Special effects and production switching are done by the a. SEG b. CCU c. ENG camera d. sync generator The gamma of the picture tube is a. 2.2 b. 0.4545 c. 1.0 d. 1.4 If the camera cannot be placed far away enough to include everything in the scene, change the lens to one with a. shorter focal length b. lower f rating c. higher f rating d. longer focal length A typical value of vidicon dark current is a. 0.2uA b. About 200uA c. 8mA d. 800mA

A lens has an 8-cm focal length and 4-cm diameter. Its f rating is a. 2 b. 4 c. 8 d. 32 In the sawtooth waveform for linear scanning a. the complete cycle includes trace and retrace b. the linear rise is for flyback c. the sharp reversal in amplitude produces trace d. the beam moves faster during trace than retrace Given a 635-us vertical retrace time, the number of complete horizontal lines scanned during vertical flyback is a. 10 b. 20 c. 30 d. 63 One-half line spacing between the start positions for scanning even and odd fields produces a. exact interlacing b. linear scanning c. line pairing d. fishtailing The number of lines scanned per frame in the raster on the picture tube screen a. 525 b. 262 c. 20 e. high gain in pre-amplifier f. excessive gamma g. insufficient scanning width Which of the ff camera tubes has minimum lag? (Board Nov.2006) e. plumbicon f. vidicon g. saticon h. iconoscope The part of the visible spectrum where camera pick-up tubes have the greatest output e. yellow-green f. red g. blue h. infrared Precise scanning size and linearity are most important in (Board Nov.2006) e. a single-tube color pickup f. a plumbicon g. a black-and-white camera h. a saticon Beam alignment magnets for the camera tube are adjusted while rocking which control? e. electrical focus f. optical focus g. beam current h. shading Special effects and production switching are done by the e. SEG i. yellow-green j. red k. blue l. infrared Precise scanning size and linearity are most important in (Board Nov.2006) i. a single-tube color pickup

j. k. l.

a plumbicon a black-and-white camera a saticon

Beam alignment magnets for the camera tube are adjusted while rocking which control? i. electrical focus j. optical focus k. beam current l. shading Special effects and production switching are done by the f. SEG g. CCU h. ENG camera i. sync generator The gamma of the picture tube is e. 2.2 f. 0.4545 g. 1.0 h. 1.4 If the camera cannot be placed far away enough to include everything in the scene, change the lens to one with e. shorter focal length f. lower f rating g. higher f rating h. longer focal length A typical value of vidicon dark current is e. 0.2uA f. About 200uA g. 8mA h. 800mA A lens has an 8-cm focal length and 4-cm diameter. Its f rating is e. 2 f. 4 g. 8 h. 32 In the sawtooth waveform for linear scanning e. the complete cycle includes trace and retrace GROBTV_Q&A Which of the following camera tubes uses lead oxide (PbO) for the photoconductive target plate? e. Plumbicon f. Vidicon g. Saticon h. image orthicon Camera signal output w/o sync is called e. non-composite video f. black burst g. generator lock video h. composite video A low contrast picture in which white seems flat and lacking in detail suggests h. low beam current i. high gain in pre-amplifier j. excessive gamma k. insufficient scanning width Which of the ff camera tubes has minimum lag? (Board Nov.2006) i. plumbicon j. vidicon k. saticon l. iconoscope

The part of the visible spectrum where camera pick-up tubes have the greatest output m. yellow-green n. red o. blue p. infrared GROBTV_Q&A Which of the following camera tubes uses lead oxide (PbO) for the photoconductive target plate? i. Plumbicon j. Vidicon k. Saticon l. image orthicon Camera signal output w/o sync is called i. non-composite video j. black burst k. generator lock video l. composite video A low contrast picture in which white seems flat and lacking in detail suggests l. low beam current m. high gain in pre-amplifier n. excessive gamma o. insufficient scanning width Which of the ff camera tubes has minimum lag? (Board Nov.2006) m. plumbicon n. vidicon o. saticon p. iconoscope The part of the visible spectrum where camera pick-up tubes have the greatest output q. yellow-green r. red s. blue t. infrared Precise scanning size and linearity are most important in (Board Nov.2006) m. a single-tube color pickup n. a plumbicon o. a black-and-white camera p. a saticon Beam alignment magnets for the camera tube are adjusted while rocking which control? m. electrical focus n. optical focus o. beam current p. shading Special effects and production switching are done by the j. SEG k. CCU l. ENG camera m. sync generator The gamma of the picture tube is i. 2.2 j. 0.4545 k. 1.0 l. 1.4 If the camera cannot be placed far away enough to include everything in the scene, change the lens to one with i. shorter focal length j. lower f rating k. higher f rating l. longer focal length

A typical value of vidicon dark current is i. 0.2uA j. About 200uA k. 8mA l. 800mA A lens has an 8-cm focal length and 4-cm diameter. Its f rating is i. 2 j. 4 k. 8 l. 32 In the sawtooth waveform for linear scanning f. the complete cycle includes trace and retrace g. the linear rise is for flyback h. the sharp reversal in amplitude produces trace i. the beam moves faster during trace than retrace Given a 635-us vertical retrace time, the number of complete horizontal lines scanned during vertical flyback is e. 10 f. 20 g. 30 h. 63 One-half line spacing between the start positions for scanning even and odd fields produces e. exact interlacing f. linear scanning g. line pairing h. fishtailing The number of lines scanned per frame in the raster on the picture tube screen d. 525 e. 262 f. 20 p. high gain in pre-amplifier q. excessive gamma r. insufficient scanning width Which of the ff camera tubes has minimum lag? (Board Nov.2006) q. plumbicon r. vidicon s. saticon Which of the following camera tubes uses lead oxide (PbO) for the photoconductive target plate? m. Plumbicon n. Vidicon o. Saticon p. image orthicon Camera signal output w/o sync is called m. non-composite video n. black burst o. generator lock video p. composite video A low contrast picture in which white seems flat and lacking in detail suggests s. low beam current t. high gain in pre-amplifier u. excessive gamma v. insufficient scanning width Which of the ff camera tubes has minimum lag? (Board Nov.2006) t. plumbicon u. vidicon v. saticon w. iconoscope

The part of the visible spectrum where camera pick-up tubes have the greatest output u. yellow-green v. red w. blue x. infrared Precise scanning size and linearity are most important in (Board Nov.2006) q. a single-tube color pickup GROBTV_Q&A Which of the following camera tubes uses lead oxide (PbO) for the photoconductive target plate? q. Plumbicon r. Vidicon s. Saticon t. image orthicon Camera signal output w/o sync is called q. non-composite video r. black burst s. generator lock video t. composite video A low contrast picture in which white seems flat and lacking in detail suggests w. low beam current x. high gain in pre-amplifier y. excessive gamma z. insufficient scanning width r. s. t. a plumbicon a black-and-white camera a saticon

Beam alignment magnets for the camera tube are adjusted while rocking which control? q. electrical focus r. optical focus s. beam current t. shading Special effects and production switching are done by the n. SEG o. CCU p. ENG camera q. sync generator The gamma of the picture tube is m. 2.2 n. 0.4545 o. 1.0 p. 1.4 GROBTV_Q&A Which of the following camera tubes uses lead oxide (PbO) for the photoconductive target plate? u. Plumbicon v. Vidicon w. Saticon x. image orthicon Camera signal output w/o sync is called u. non-composite video v. black burst w. generator lock video x. composite video A low contrast picture in which white seems flat and lacking in detail suggests aa. low beam current bb. high gain in pre-amplifier cc. excessive gamma

dd. insufficient scanning width Which of the ff camera tubes has minimum lag? (Board Nov.2006) x. plumbicon y. vidicon z. saticon aa. iconoscope The part of the visible spectrum where camera pick-up tubes have the greatest output y. yellow-green z. red u. a single-tube color pickup v. a plumbicon w. a black-and-white camera x. a saticon Beam alignment magnets for the camera tube are adjusted while rocking which control? u. electrical focus y. image orthicon Camera signal output w/o sync is called y. non-composite video Precise scanning size and linearity are most important in (Board Nov.2006) y. a single-tube color pickup z. a plumbicon aa. a black-and-white camera bb. a saticon Beam alignment magnets for the camera tube are adjusted while rocking which control? v. electrical focus w. optical focus x. beam current y. shading Which of the ff camera tubes has minimum lag? (Board Nov.2006) bb. plumbicon cc. vidicon dd. saticon ee. iconoscope The part of the visible spectrum where camera pick-up tubes have the greatest output aa. yellow-green bb. red cc. blue dd. infrared z. generator lock video aa. composite video A low contrast picture in which white seems flat and lacking in detail suggests ee. low beam current ff. high gain in pre-amplifier gg. excessive gamma hh. insufficient scanning width Which of the ff camera tubes has minimum lag? (Board Nov.2006) ff. plumbicon

Вам также может понравиться