Академический Документы
Профессиональный Документы
Культура Документы
Pattern pieces 1 5 Size 34 3333 Size 36 4444 Size 38 55 Size 40 6666 Size 42 7777
s Insert invisible zip at front slit edges, as described hereafter. Open the zip and push the coil back with your thumbnail to reveal the seam between the tape/ band and the coil. Place the open zip face down on the right side of
1 2
one opening edge. So that the zip can be stitched in place exactly along the marked seam-line, calculate the distance between the band and the fabric as follows: seam allowance width minus 1 cm (3/8 inch) = distance from the edge of the fabric. The bottom end of the zip will overhand the marked end of the opening. Place the special presser foot on the zip so that the coil is in the notch to the right of the needle (gure 1). Stitch zip in place from the top to the marked end of the opening. Close the zip.
Place the other zip band face down on the other opening edge and pin in place at the top. Open zip again. Place the presser foot on the top end of the zip so that the coil is in the notch to left of the needle (gure 2). Stitch the zip in place from the top to the end of the opening. Close zip. Now stitch centre front seam from bottom to top (up to zip). Turn back the loose lower end of the zip onto the seam allowances. Stitch as close as possible to the last stitch of the zip seams. Trim off the surplus zip and bind the end with a scrap of fabric. s Stitch the side seams on waistband pieces. Stitch outer waistband pieces onto upper edge of trousers, leaving ends of waistband overhanging from centre front. Press seam allowances of joining seams onto waistband pieces. Place inside waistband pieces right sides together with the stitched outer waistband pieces and pin edges together. Place seam allowances at lower edges of waistband down again in front. Stitch across front ends of waistband and upper edges of waistband. Trim seam allowances. Turn waistband pieces. s Stitch two pocket pieces, with right sides together, leaving narrow edges open at the top. Trim seam allowances. Turn pockets and press. Topstitch integrated beltcarriers and pocket opening edge at 5 mm (3/16 inch). Pin pockets on trouser pieces at placement line and stitch 5 mm (3/16 inch) wide. Now pull belt carriers down again and pin in place. s Place inside back waistband pieces up again and press seam allowances at upper edge of waistband open about 5 cm (2 ins) long, then smooth at over the joining seam. Topstitch along waistband close to edges. Work buttonholes in the front ends of waistband as marked and on the left for inside button. s Place belt carriers on pockets up again, stitch crosswise as marked. Turn ends in and stitch at upper edge of waistband. s Press hem allowances to inside, turn in to a width of 2.5 cm (1 inch) and stitch in place.
Copyright 2006 by Verlag Aenne Burda GmbH & Co. KG, Am Kestendamm 1, D-77652 Offenburg. All rights reserved. All designs and contributions are copyrighted. Reproduction for commercial purposes is prohibited. The publishers do not accept responsibility for damages occuring from improper use of materials, improper carrying out of tips or instructions or improper use of completed models.