0 оценок0% нашли этот документ полезным (0 голосов)
55 просмотров1 страница
The following factors must be considered when sizing and selecting the appropriate array. The factors are based on Cooper Basin experience and conditions and must be modified for installations in other areas. Panel Quantity and Dimensions Chosen to best suit the physical constraints of the application.
The following factors must be considered when sizing and selecting the appropriate array. The factors are based on Cooper Basin experience and conditions and must be modified for installations in other areas. Panel Quantity and Dimensions Chosen to best suit the physical constraints of the application.
Авторское право:
Attribution Non-Commercial (BY-NC)
Доступные форматы
Скачайте в формате PDF, TXT или читайте онлайн в Scribd
The following factors must be considered when sizing and selecting the appropriate array. The factors are based on Cooper Basin experience and conditions and must be modified for installations in other areas. Panel Quantity and Dimensions Chosen to best suit the physical constraints of the application.
Авторское право:
Attribution Non-Commercial (BY-NC)
Доступные форматы
Скачайте в формате PDF, TXT или читайте онлайн в Scribd
Rev Date: 11-Aug-2011 ssued by Project Management Office Engineering Team Santos Ltd Printed document may not be current issue. Check 'TMS' ABN 80 007 550 923
3.2.2 SoIar Array Sizing and SeIection The solar array can be sized and selected based on the following calculation of the electrical load. f the load has been calculated manually the solar array can be chosen from the manufacturer's literature or, alternatively, the commercial solar sizing packages usually provide array recommendations. The following factors must be considered when sizing and selecting the appropriate array. These factors are based on Cooper Basin experience and conditions and must be modified for installations in other areas.
Factor Recommendation Notes Sun hours per day (Lowest number of sun hours per day) This should be for the worst month of the year. E.g. For Moomba, SA, the worst month is June where PSH = 4.65. This information is available from the Bureau of Meteorology (BOM) or from solar panel manufacturers for other regions. Number of days required to recharge battery from maximum depth of discharge To be determined per application This will affect the number of solar panels required Optimum panel angle The panel is to face North. The tilt angle may be fixed at 45 for the Cooper Basin or may be varied to suit alternative latitudes and/or seasonal variations in the load. This angle is a compromise between the optimum summer and winter angles. nformation is available from BOM or solar panel manufacturers for other regions. Panel Voltage 12V or 24V DC Selected to suit the requirements of the solar regulator and the main load devices i.e. to minimise the need for voltage converters. Panel Type Crystalline silicon PV modules shall comply with EC 61215. Thin film PV modules shall comply with EC 61646. Tedlar back plate, EVA encapsulate, tempered glass front, anodized aluminium alloy frame. Refer to Santos specification 1515-60-S003 for preferred vendors and models commonly used in the Cooper Basin. Panel Quantity and Dimensions Chosen to best suit the physical constraints of the application e.g. wind loads, mobile installations, single post stands etc The panels in any single installation should all be of the same type. The smallest number of large panels is usually the best combination. Options Electrical connection terminals in a weatherproof junction box Panels should have protected terminals (not cable tails) for the connection of the power and signal cables.