Академический Документы
Профессиональный Документы
Культура Документы
For
Site Sharing
1. General Existing Site Sharing information
Candidate Address: Contact person: Area/Location: Existing Tower type: Physical appearance of the tower: Space availability on the tower Equipment Shelter:
School compound Hospital/ Clinic
Contact Number/s:
Military Compound Mountain area Residential Road side Others: .
Monopole height . m
Height available for Installation of antennas: 30 Collocate with CKD shelter possible: Yes No
Cable tray available for usage: Yes No Proposed equipment : Existing Access road: Yes No
Revision number: 02 Date of issue: December 06, 2012 References: M4. TSS Approved
23 of 38
Document title: Site Sharing TSSR Document number: 163357/Mega/Batch 3G/ Release status: Released
Site Sharing
2. Power Supply
Installation of aerial cable allowed: Yes No Power cable required to be installed underground: Yes No Distance from the nearest transformer: .. m Additional poles required to reach the 3 phase supply: Quantity pcs Ground condition where cables will pass: Length of required underground Concrete m installation m Soil m Others: specify . length .. m No. of poles required: - pcs.
Connect to PLN:
Any private property which will be affected by pole location and Right of way for the PLN connection: Yes No (Please show in the drawing.) Connect to Building: Type of supply available: single phase three phase Spare breakers available for use: (capacity and qty) .. Length of power cable from the source to our proposed sub-meter: ..m
Explain the need for permanent generator: Supply permanent .. Generator: Available space Distance of the proposed Soundproof required: Rooftop location from site: .. m Yes No others Other important information / special requirement:
3.
Grounding System
Grounding System Available: Yes No Reading of available grounding (Existing): .ohms Possibility to connect with existing grounding (please discuss with owner): Yes No
Estimated length of exposed (yellow green) grounding cable required: .m Demolition required for the installation of the copper rods: Yes (specify type and qty) . No
Revision number: 02 Date of issue: December 06, 2012 References: M4. TSS Approved
24 of 38
Document title: Site Sharing TSSR Document number: 163357/Mega/Batch 3G/ Release status: Released
Site Sharing
4. Existing Antenna Information a. Radio Requirement
Technology Antenna Type Number or Size
*) see note 1
DCS
3 3
GSM
Antenna Orientation (deg.) & Mounting Position (Leg 1,2,3,4) Feeder Length (meters): Feeder size/type
(i.e. 7/8; 1 ; etc):
30&1,90&2, 210&3
40
42
b. Transmission Requirement
Proposed Microwave Antenna Information Tower Leg Mounting Position
(Leg 1,2,3,4)
No 1 2 3 4 5 6 7 8
Height
(agl)
Azimuth to F.E.
(Deg)
Type of Antenna
(HP, Std, Grid, etc) *) see note 2
Feeder Cable
(Type & Diameter)
Leg 1
31
7.81
HP
Leg 4
Revision number: 02 Date of issue: December 06, 2012 References: M4. TSS Approved 25 of 38
Leg 3
Document title: Site Sharing TSSR Document number: 163357/Mega/Batch 3G/ Release status: Released
Site Sharing
ATTENDANCE:
Team
Construction Supervisor Acquisition Supervisor TR/MW Planner Radio Planner Implementation Supervisor Others attending
PO (Principle Owner)
Survey result:
Accepted
Rejected
Revision number: 02 Date of issue: December 06, 2012 References: M4. TSS Approved
26 of 38
Document title: Site Sharing TSSR Document number: 163357/Mega/Batch 3G/ Release status: Released
Site Sharing
5. Drawings and sketches
a. Access to site including the dimensions and distance of the road which is not accessible by car: b. Complete proposed layout (tower/pole position/equipment/ACPDB/cable route,etc. with all dimensions including set back from property line on all sides) c. Reflect any overhead/underground utilities crossing the site (powerline, telephone line, pipesetc.) d. Reflect existing facilities/obstructions/trees.etc. e. Reflect any high tension Cables running outside the building which can affect delivery (approx. height) f. Sketch the proposed route for power connection; specify the distances as stated in above data g. SITE CONTOUR / ELEVATION (reflect approximate contour of site/elevation view; provide the elevation reading per 3m)
Site Layout
0 30 SST 44M
Pintu
Kwh Kwh
Propose Hcpt
Genset
Bts Bts
Revision number: 02 Date of issue: December 06, 2012 References: M4. TSS Approved
27 of 38
Document title: Site Sharing TSSR Document number: 163357/Mega/Batch 3G/ Release status: Released
Site Sharing
Antenna Placement
42 M.A.G.L
40 M.A.G.L
Revision number: 02 Date of issue: December 06, 2012 References: M4. TSS Approved
28 of 38
Document title: Site Sharing TSSR Document number: 163357/Mega/Batch 3G/ Release status: Released
Site Sharing
Note: Photo documentation should include but not limited to the following:
a. b. c. d. e. f. g.
Actual proposed site status Panoramic Photos. Access information from the nearest road going to the actual site. Include information on the narrowest access Power source. Including photo of the 3 Phase power source (i.e. 3 phase PLN pole) and nearest Transformer Cable tray route and grounding route; including power route going to source Incase there is need to demolish existing structure, photo of which should also be presented
Panoramic Photo
0 30
60
90
120
Revision number: 02 Date of issue: December 06, 2012 References: M4. TSS Approved 29 of 38
150
Document title: Site Sharing TSSR Document number: 163357/Mega/Batch 3G/ Release status: Released
Site Sharing
180
210
240
Revision number: 02 Date of issue: December 06, 2012 References: M4. TSS Approved 30 of 38
270
Document title: Site Sharing TSSR Document number: 163357/Mega/Batch 3G/ Release status: Released
Site Sharing
300
330
Proposed Equipment
Document title: Site Sharing TSSR Document number: 163357/Mega/Batch 3G/ Release status: Released
Site Sharing
Revision number: 02 Date of issue: December 06, 2012 References: M4. TSS Approved
32 of 38
Document title: Site Sharing TSSR Document number: 163357/Mega/Batch 3G/ Release status: Released
Site Sharing
VERTICAL TRAY
HORIZONTAL TRAY
Site Sharing
TOWER PICTURE 1 TOWER PICTURE 2
TOP DOWN 1
TOP DOWN 2
TOP DOWN 3
Revision number: 02 Date of issue: December 06, 2012 References: M4. TSS Approved 34 of 38
TOP DOWN 4
Document title: Site Sharing TSSR Document number: 163357/Mega/Batch 3G/ Release status: Released
Site Sharing
5.A. Detailed Sketch of Transmission Cables and Transmission Cable Ladder System
a. b. c. d. Provide details of the type, size and number of existing transmission cables including relative positions and arrangement on the cable ladder system. A new sketch for (a) above is required whenever there is a change in the number of cables and the sketch should indicate the top and bottom tower elevations where the cable arrangement is applicable. Provide details of the cable ladder system including width, type and size of ladder rails, type size and spacing of cable support brackets. If the transmission cable ladder system is integral with the climbing ladder system then this sketch must include details of the climbing ladder system including the following : - Width, type and size of climbing ladder rails. - Diameter, type and spacing of ladder rungs. - Safety cage vertical flat bar size and arrangement. - Safety cage horizontal flat bar size and spacing. Provide measurement of vacant space available on the cable ladder system. If the transmission cable ladder system is isolated from the climbing ladder system then show the position on the tower.
e. f.
Revision number: 02 Date of issue: December 06, 2012 References: M4. TSS Approved
35 of 38
Document title: Site Sharing TSSR Document number: 163357/Mega/Batch 3G/ Release status: Released
Site Sharing
Proposed Antenna Sector 1 Proposed Antenna Sector 2
Revision number: 00 Date of issue: November 03, 2008 References: M4. TSS Approved
36 of 37
Document title: Site Sharing TSSR Document number: 2056 Release status: Released
Site Sharing
4.A. HCPT Propose Antenna Information a. Radio Requirement
Technology Sector Antenna Type Number Number of Antennas Antenna Orientation (deg.) & Tower Leg Mounting Position
(Leg 1,2,3,4)
2G
1
DX-17102170-6519.5i-M
3G
3
DX-1710-217065-19.5i-M
2
DX-1710-217065-19.5i-M
1
DX-1710-217065-19.5i-M
2
DX-17102170-6519.5i-M
3
DX-17102170-6519.5i-M
1 60/Leg 1 30 x 2 7/8" 30 m
1 180/Leg 2 30 x 2 7/8" 30 m
1 240/Leg 3 30 x 2 7/8" 30 m
1 60/Leg 1 30 x 2 7/8" 30 m
1 180/Leg 2 30 x 2 7/8" 30 m
1 240/Leg 3 30 x 2 7/8" 30 m
b. Transmission Requirement
Proposed Microwave Antenna Information Near End Site Tower Leg Mounting Position
(Leg 1,2,3,4)
No
Heigh t
(M.Agl)
Azimut h to F.E.
(Deg)
Type of Antenna
(HP, Std, Grid, etc)
Feeder Cable
(Type & Diameter)
Heigh t
(M.Agl)
Azimuth to N.E.
(Deg)
1 2 3 4 5 6
163357
31
7.81
HP
1/4
30
187.81
Leg 1
Leg 2
Leg 4
Leg 3
Revision number: 00 Date of issue: November 03, 2008 References: M4. TSS Approved
37 of 37
Document title: Site Sharing TSSR Document number: 2056 Release status: Released