Академический Документы
Профессиональный Документы
Культура Документы
v = o = = ?j = ` ?
Summary of Results
23% Correct of 39 Score d ite m s:
9 C orre ct: 30 Incorre ct: 23% 77%
1.
Which of the following techniques can be used in the sinusoidal ac analysis of transistor networks? Your Answer: Small-signal Correct Answer: Small- or large-signal
2.
What is the limit of the efficiency defined by = P o / P i? Your Answer: Greater than 1 Correct Answer: Less than 1
3.
Which of the following define(s) the conversion efficiency? Your Answer: Ac power to the load/ac input power Correct Answer: Ac power to the load/dc power supplied
4.
Which of the following should be done to obtain the ac equivalent of a network? Your Answer: Set all dc sources to zero Correct Answer: All of the above
5.
The _____ model suffers from being limited to a particular set of operating conditions if it is to be considered accurate. Your Answer: Correct Answer: hybrid equivalent
6.
The _____ model fails to account for the output impedance level of the device and the feedback effect from output to input. Your Answer: Correct Answer: re
7.
K ~ K L L ~
Which of the following is (are) true regarding the input impedance for frequencies in the midrange 100 kHz of a BJT transistor amplifier?
NLS
NM LNO LNO
v = o = = ?j = ` ?
Your Answer: An ohmmeter cannot be used to measure the small-signal ac input impedance. Correct Answer: All of the above
8.
Which of the following is (are) true regarding the output impedance for frequencies in the midrange 100 kHz of a BJT transistor amplifier? Your Answer: An ohmmeter cannot be used to measure the small-signal ac output impedance. Correct Answer: All of the above
9.
What is the range of the current gain for BJT transistor amplifiers? Your Answer: above 100 Correct Answer: All of the above
10.
The input impedance of a BJT amplifier is purely _____ in nature and can vary from a few _____ to _____. Your Answer: capacitive, microfarads, farads Correct Answer: resistive, ohms, megohms
11.
For BJT amplifiers, the _____ gain typically ranges from a level just less than 1 to a level that may exceed 1000. Your Answer: current
12.
What is the unit of the parameter h o ? Your Answer: Ohm Correct Answer: Siemen
13.
Which of the h-parameters corresponds to re in a common-base configuration? Your Answer: h fb Correct Answer: h ib
14.
What is the range of the input impedance of a common-base configuration? Your Answer: 100 k to 500 k
K ~ K L L ~
O LS
NM LNO LNO
v = o = = ?j = ` ?
15.
What is the typical value of the current gain of a common-base configuration? Your Answer: Between 100 and 200 Correct Answer: Less than 1
16.
What is the controlling current in a common-base configuration? Your Answer: Ib Correct Answer: Ie
17.
What is the typical range of the output impedance of a common-emitter configuration? Your Answer: 40 k to 50 k
18.
Under which of the following conditions is the output impedance of the network approximately equal to RC for a common-emitter fixed-bias configuration? Your Answer: ro > ro Correct Answer: ro 10RC
19.
Under which of the following condition(s) is the current gain Your Answer: ro 10RC and RB 10re
20.
What does the negative sign in the voltage gain of the common-emitter fixed-bias configuration indicate? Your Answer: Gain is larger than 1. Correct Answer: The output and input voltages are 180 out of phase.
21.
For the common-emitter fixed-bias configuration, there is a _____ phase shift between the input and output signals. Your Answer: 90 Correct Answer: 180
22.
Which of the following configurations has an output impedance Zo equal to RC ? Your Answer: Common-emitter voltage-divider without bypass capacitor Correct Answer: All of the above
K ~ K L L ~
PLS
NM LNO LNO
v = o = = ?j = ` ?
23.
Which of the following configurations has a voltage gain of RC /re ? Your Answer: Fixed-bias common-emitter and voltage-divider with bypass capacitor
24.
Which of the following configurations has the lowest output impedance? Your Answer: Emitter-follower
25.
The _____ configuration is frequently used for impedance matching. Your Answer: emitter-follower
26.
The emitter-follower configuration has a _____ impedance at the input and a _____ impedance at the output. Your Answer: high, low
27.
Which of the following gains is less than 1 for a common-base configuration? Your Answer: Ap Correct Answer: Ai
28.
Which of the following conditions must be met to allow the use of the approximate approach in a voltage-divider bias configuration? Your Answer: Correct Answer: RE < 10R2 re < 10R2
29.
Which one of the following configurations has the lowest input impedance? Your Answer: Common-base
30.
For the collector dc feedback configuration, there is a _____ phase shift between the input and output signals. Your Answer: 45 Correct Answer: 180
31.
Which of the following represent(s) the advantage(s) of the system approach over the rmodel approach? Your Answer: Thevenin's theorem can be used.
K ~ K L L ~
Q LS
NM LNO LNO
v = o = = ?j = ` ?
32.
The loaded voltage gain of an amplifier is always more than the no-load level. Your Answer: True Correct Answer: False
33.
The smaller the level of RL , the larger the level of ac voltage gain. Your Answer: True Correct Answer: False
34.
Which of the following is (are) true to achieve a good overall voltage gain for the circuit? Your Answer: The effect of Rs and RL must be considered as a product. Correct Answer: The effect of Rs and RL must be considered as a product and evaluated individually.
35.
The _____ the source resistance and/or _____ the load resistance, the less the overall gain of an amplifier. Your Answer: smaller, smaller Correct Answer: larger, smaller
36.
The current gain for the Darlington connection is _____. Your Answer: Correct Answer:
37.
38.
Which of the following is referred to as the reverse transfer voltage ratio? Your Answer: h i Correct Answer: h r
39.
In an unbypassed emitter bias configuration h ie replaces _____ in the re model. Your Answer: re
K ~ K L L ~
RLS
NM LNO LNO
v = o = = ?j = ` ?
Correct Answer:
re
Copyright 1995 - 2010 Pearson Education . A ll rights reserved. Pearson Prentice Hall is an imprint of Pearson . Legal Notice | Privacy Policy | Permissions
K ~ K L L ~
SLS