Академический Документы
Профессиональный Документы
Культура Документы
BW-B35202
5 DIAMETER ROLL
BW-B34352
4 DIAMETER ROLL
BW-B35352
5 DIAMETER ROLL
BW-CSLB34TR200
4 DIAMETER ROLL
CEMA B
BW-CSLB34TR350
4 DIAMETER ROLL
BW-CSLB35TR350
5 DIAMETER ROLL
48
RETURN IDLER
CEMA B
RETURN TRAINING IDLER
BW-CSLB35A200CM
5 DIAMETER ROLL
BW-CSLB35A350CM
5 DIAMETER ROLL
Dimensions in inches. Weight in pounds. All dimensions approximate. Obtain certied drawings for exact dimensions. For wide base troughing idlers, add W to the end of the part number.
The 4 and 5 diameter rolls are of one-piece construction with steel shells and an engineered polymer roll end. The roll end is secured by an interference press t and is locked to the shaft. The 17mm shaft provides strength and the short moment arm minimizes shaft slope at the bearing which increases bearing life. Rolls are tted at each end with a special 17mm deep groove, high capacity, precision ball bearing. These bearings are double shielded and permanently lubricated.
Removable Rolls
Rolls are secured in the frame assembly by special clips providing a rigid, one-piece unit, yet allowing easy roll removal when necessary.
End and center stands are die formed from steel plate, and end stands are channel formed for greater rigidity. Stands and foot plates are xture-welded to the self-cleaning inverted base angle, assuring accurate roll alignment.
Engineered polymer roll end provides a lightweight roll that reduces noise, corrosion and material build-up.
An interference press t secures the roll end to the shell. The inner shield acts as a inger to divert contaminants away from the bearing cavity.
A 17mm ball bearing is double shielded and permanently lubricated. The back seal is molded into the head design and provides added protection for the bearing cavity. Two-piece shield forms a horizontal, grease filled labyrinth and provides a barrier to contaminants entering the bearing cavity.
The outer shield locks to the shaft to maintain horizontal labyrinth clearances.
Goodman products pictured, described, or listed in this publication are illustrative only. Application and use of these products must be in accordance with applicable codes and regulations and must be arranged and/or provided with covers or other guards where necessary to assure safety of personnel.