Академический Документы
Профессиональный Документы
Культура Документы
NG SKID
CENTER OF GRAVITY
ER OF TY
KF STEP PANEL
ANDING SKID
OUTER LAN
Parts list
1 sheet 18 x 3 1/16" (1.5mm 1/8" x 14" car 1/32 music wi Hot glue Welders glue 3M Spray 77 Paint
Hardware Req
24 gram moto Motor mount Prop: GWS 8 Prop saver ESC Servos: 3 - 5 Reciever Control horns EZ connector Battery: 2s 36
WI
Specifications:
st
18 x 36 1.3# 6mm epp foam. .5mm) carbon rod for control rods. 4" carbon tube for leading edge/prop protector usic wire for control rod ends and wire hoop skids. e s glue ay 77
re Required:
29-MAY-2009 - Change A - Added to accept optional horizontal stabil For Private Use Only Commercial Rights Reserved
n RCGroups.com ps.com
INNER LANDING
FUSELAGE
AL STABILIZER
Here is a guide
1.Cut all foam 2. Hinge all co 3. Laminate lo 4. Optional: do 5. Install fusela 6. Install foam 7. Hook up ele 8. Install electr 9. Install contr 10. Install lead 11. Install wire
For the maide Check cg and I use +/- 45 de Elevons shoul Launch nose h
NDING SKID
OUTER LAND
Trim cg and co
4.00
LANDING GEAR IS .032" MUSIC WIRE 9-3/4 FLEX BOTH ENDS OF WIRE AND INSERT I SPRING TENSION HOLDS WIRE IN PLACE
foam pieces all control surfaces ate lower KF piece nal: do your cool paint job now fuselage foam skid assemblies up electrics, check operation, center servos electrics control rods and horns ll leading edge tube ll wire hoop landing gear
maiden flight: g and control movements 45 degrees and 75% expo on all surfaces to start should be slightly up; 1/16" or 1/8", rudder straight nose high, about 45 degrees and 1/3 throttle. It should float away and climb slowly.
PLASTIC TUBES GLUED TO INS OF SKID ASSEMBLIES. RC CAR GUIDE CAN BE USED FOR TUB ALSO 1/8" NYLON TUBING IS S
't forget the most important thing - Have fun! CENTER OF GRAVITY
4.00in
KID ASSEMBLY
NOTE: PLUGS REQUIRED THERE IS A 1/4" LONG PLUG IN THE END OF THE LANDING GEAR TUBES TO ACT AS WIRE STOPS. A PIECE OF WIRE WAS USED FOR THIS ON THE PROTOTYPE.