Вы находитесь на странице: 1из 4

Prosis - Print

Page 1 of 4

Service Information
Document Title: Function Group: Information Type: Service Information Date: 10/08/2009

Profile: EXC, EC210B LC (Volvo) [GB]

V-ECU (MID187) Vehicle control unit, passive measuring conditions

Figure 1 Passive resistance measurement against cable harness, vehicle control unit (V-ECU) disconnected Conditions 1) Control unit disconnected 2) Multi-pin breaker box connected against cable harness

NOTE NOTE
For measuring voltage, the following applies:

For measuring resistance, the following applies:

3b) Turn start switch to the OFF position, turn master switch to the OFF position and 3a) Turn master switch to the ON position, measure the resistance with the multimeter.

http://localhost/Prosis/Pages/Print.aspx?PrintType=4&ObjectID=224676&infotype=1,2,5,...

8/10/2009

Prosis - Print

Page 2 of 4

turn start switch to the ON position and measure the voltage with the multimeter.

NOTE
4)Engine off

During all resistance measurements, the master switch must be turned OFF.

Abbreviation U Ubat Ulow R Direct voltage in volts (V) Battery voltage Voltage near to 0 volt or 0 volt Resistance in ohm ()

Explanation

V-ECU Passive measuring


Pin JA1 JA2 JA3 JA4 JA5 JA6 JA7 JA8 JA9 JA10 JA11 JA12 JA13 JA14 JA15 JA16 JA17 JA18 JA19 JA20 JA21 JA22 JA23 JA24 JA25 JA26 JA27 JA28 JA29 JA30 JA31 Signal / component Contronics key V Contronics clock Preheater indicator Not connected MA9102, power shift proportional valve ground Not connected FU25, fuse for auxiliary proportional valve Measuring points Correct value Miscellaneous See active measuring. See active measuring. See active measuring. JA5 - JA32 R 1520

See active measuring.

Not connected

RE3701, EMS power cut off relay Rotary switch ground Not connected

JA13 - JB8

R 315 10 %

Float position pilot pressure JA17 - JB8 switch SW9103, travel speed selection switch SE9101, attach pilot pressure switch Safety lever switch Not connected SW2704, emergency RPM control and stop switch (EMS power check) SW9104, quickfit switch Contronics key # Contronics key > Contronics data Coolant level indicator Coolant temperature indicator Not connected MA9101, flow control JA30 - JA56 proportional valve ground Not connected

See active measuring. See active measuring. See active measuring. See active measuring.

See active measuring. See active measuring. See active measuring. See active measuring. See active measuring. See active measuring. See active measuring. R 1520

http://localhost/Prosis/Pages/Print.aspx?PrintType=4&ObjectID=224676&infotype=1,2,5,...

8/10/2009

Prosis - Print

Page 3 of 4

JA32 JA33 JA34 JA35 JA36 JA37 JA38 JA39 JA40 JA41 JA42 JA43 JA44 JA45 JA46 JA47 JA48 JA49 JA50 JA51 JA52 JA53 JA54 JA55 JA56 JA57 JA58 JA59 JA60 JA61 JA62 JA63 JA64 JA65 JA66 JA67 JA68 JA69 JA70

MA9102, power shift proportional valve signal FU25, fuse for proportional valve VECU status FU27, fuse for conflux shut off MA9107, power boost solenoid valve MA9105 / MA9106, conflux shut off solenoid valve RE9102, travel motor relay SW2701, engine speed control switch Not connected SW9105, quickfit switch (confirm) SE9103, travel pilot pressure switch SW2702, Power max mode select switch Not connected

JA32 - JA5

R 1520 See active measuring.

JA34 - JB8

R 320345 K See active measuring.

JA36 - JB8 JA37 - JB8 JA38 - JB8 JA39 - JA14

R 2030 R 1015 R 315 10 % R 46.547.5 K

See active measuring. See active measuring. JA44 - JB8 R 0 (power max mode select switch: ON only) See active measuring.

SW2704, emergency RPM JA47 - JB8 control and stop switch (IVS) Contronics key "* Contronics enable Not connected Air cleaner indicator Float position indicator Not connected MA9101, flow control proportional valve signal Not connected Float position solenoid valve FU27, fuse for power boost solenoid valve RE3101, battery relay cut off signal SW9101, flow control switch signal Not connected SE9102, hammer pilot pressure switch SW2703, auto idle select switch MA9117, hammer selection solenoid valve (hammer select check) (option) Float position switch SW9109 / SW9110, Rotator switch, left / right (option) JA59 - JB8 JA56 - JA30

R 2.892.91 K See active measuring. See active measuring. See active measuring.

R 1520

R 2030 See active measuring. See active measuring. See active measuring.

See active measuring. See active measuring.

See active measuring. See active measuring. -------------------------------------

http://localhost/Prosis/Pages/Print.aspx?PrintType=4&ObjectID=224676&infotype=1,2,5,...

8/10/2009

Prosis - Print

Page 4 of 4

----JB1 JB2 JB3 JB4 JB5 JB6 JB7 JB8 JB9 JB10 JB11 JB12 JB13 JB14 JB15 JB16

---------------------------------------- --------------SW9107, boost / hammer / shear selecting switch SW3301, engine start key (R2) Not connected J1587 B (white color) Shield ground (J1939) CAN L (J1939 L, green color) JB6 - JB14 Battery ground Battery ground SW3301, engine start key (ACC) Not connected Rotary switch power (option) J1587 A (red color) Shield ground (J1587) CAN H (J1939 H, yellow JB14 - JB6 color) Battery +24 V Battery +24 V

--

-------See active measuring. See active measuring. See active measuring.

R 60

See active measuring. See active measuring. See active measuring. R 60 See active measuring. See active measuring.

http://localhost/Prosis/Pages/Print.aspx?PrintType=4&ObjectID=224676&infotype=1,2,5,...

8/10/2009

Вам также может понравиться