Академический Документы
Профессиональный Документы
Культура Документы
Project Name
Project No.
Phone
Country
Outdoors open Location of use covered Underground Indoor Details of climatic conditions Centre distance Conveying flight (provide a diagram on page 4 of the questionnaire if necessary) Conveying length L Conveying height H Gradient of the system uphill downhill m m m m
Section with maximum (descending) gradient max Curve convex: Radius Re Sections with differing gradients Conveying speed v Mass flow Im Volume flow IV Degree of uniformity of mass or volume flow Load coefficient Designation of the material handled Bulk density Angle of repose m
concave: Radius Ra
Material flow
Feeding direction in longitudinal direction in tranverse direction Height of fall Material feed Garland idlers Impact idlers Feeding device (impact plates or similar) Chute constriction Material discharge Via head pulley Tripper car Scraper Width B Endless belt length Conveyor belt Support on top run: Support on return run: on carrying idlers on carrying idlers with support rings Carrying idler arrangement Idlers Mass (rotating components of an idler set) mRo Top run Moment of inertia Diameter dRo Tilted position Flat-to-trough transition length l Trough-to-flat transition length l Return idler arrangement Return run Mass (rotating components of an idler set) mRu Diameter dRu Tilted position mm mm -part Pulley lift hTr Pulley lift hTr Troughing angle u Spacing Iu mm mm m kg mm -part Troughing angle o Spacing Io m kg kg/m2 mm sliding sliding mm m Length of constriction m Troughing angle m
Tail
FT4
Conveying direction
Head
FT1
1
FTr4
FTr1
FT3
FT2
3
FT3/4
3
FTr3
FTr2
FT1/2
Pulleys driven/braked
Diameter DTr Angle of wrap Pulley surface Condition Number of drives at Power (total) Slip ring motor
: : : :
1
bare dry Pulley 1: - installed - estimated
, 2 , 2
, 3 , 3 rubberized wet
, 4 , 4 Ceramic
mm
Pulley 2:
Pulley 4: kW kW
(related to the motor torque in the steady operating state at rated mass flow): (related to the rated motor torque): s tA Pulley 3: Pulley 4: Nm
Pulley 1: Pulley 2: Number of brakes on Total braking torque (related to the motor shaft) Braking Braking factor pB pB0 Braking distance sB Takeup pulley Takeup device at
(related to the motor torque in the steady operating state at rated mass flow): (related to the rated motor torque): m flying System head Existing takeup length fixed System tail m
Takeup device
Scraper Other devices Belt turnover New system Extension Replacement Observations
Further details Projected design Required design Previous design Suitability satisfactory
yes
no
open
E 09.09
Send Questionaire