Академический Документы
Профессиональный Документы
Культура Документы
11/27/2013
Assembly Drawings
1. Screw Jack
11/27/2013
Part-1: Create body of the Screw jack 1. Select XZ Plane 2. Draw the 2D sketch as shown 3. Use revolved protrusion command to create 3D feature, Angle 3600
11/27/2013
Part-2: Create nut of the screw jack 1. Select XZ Plane 2. Draw the 2D sketch as shown 3. Use revolved protrusion command to create 3D feature, Angle 3600
11/27/2013
Part-3: Create Screw Spindle of the screw jack (Step-1) 1. Select XZ Plane 2. Draw the 2D sketch as shown 3. Use revolved protrusion command to create 3D feature, Angle 3600
11/27/2013
Part-3: Create Screw Spindle of the screw jack ( Step-2) 1. Select XZ Plane 2. Draw the 2D sketch as shown 3. Use Cut out command to create Symmetric through hole
11/27/2013
Part-3: Create Screw Spindle of the screw jack ( Step-3) 1. Select XY Plane 2. Draw the 2D sketch as shown 3. Use Cut out command to create Symmetric through hole
11/27/2013
Part-3: Create Screw Spindle of the screw jack ( Step-4) 1. Select the Plane as shown 2. Go to hole option, set the parameters as shown in dialogue box
11/27/2013
Part-4: Create CUP of the screw jack (Step-1) 1. Select XZ Plane 2. Draw the 2D sketch as shown 3. Use revolved protrusion command to create 3D feature, angle 3600
11/27/2013
Part-4: Create CUP of the screw jack (Step-2) 1. Select XZ Plane 2. Draw the 2D sketch as shown 3. Use Cut out command to create the profile as shown 4. Use Circular pattern to create remaining features as shown
11/27/2013
10
Part-5: Create Special washer of the screw jack 1. Select XZ Plane 2. Draw the 2D sketch as shown 3. Use revolved protrusion command to create 3D feature, angle 3600
11/27/2013
11
Part-6: Create Special washer of the screw jack (Step-1) 1. Select XZ Plane 2. Draw the 2D sketch as shown 3. Use revolved protrusion command to create 3D feature, angle 3600
11/27/2013
12
Part-6: Create Special washer of the screw jack (Step-2) 1. Select top surface as shown 2. Draw the 2D sketch as shown 3. Use cut out command to create 3D feature, depth 3mm
11/27/2013
13
Part-6: Create Special washer of the screw jack (Step-3) 1. Select cylindrical surface as shown 2. Use thread command to create thread feature with the parameters as shown below
11/27/2013
14
Part-7: Create Tommy Bar of the screw jack Select XZ Plane Draw the 2D sketch as shown Use revolved protrusion command to create 3D feature, angle 3600
11/27/2013
15